WenmarOpen by Wenmar Pro

Service bulletin SSM 50048

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
TypeService bulletin
NHTSA id10201018
Published by NHTSA2021-09-04
Manufacturer's numberSSM 50048
Manufacturer's date2021-08-17
NHTSA componentELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY THERMAL:MANAGEMENT:SOFTWARE

NHTSA's summary

Some 2020-2021 Corsair/Aviator/Navigator vehicles may have diagnostic trouble code (DTC) U3000:49 DTC stored in the remote function actuator (RFA) module preventing paring-connecting any phone as a key to the vehicle. If this DTC is detected during pre-delivery inspection (PDI) or while diagnosing phone as a key pare/connection issue, remove the RFA fuse or disconnect the battery terminals for minimum of 5 minutes then reinstall. Start a new FDRS session and verify that U3000:49 is no longer present. Ensure that phone as a key is enabled and a phone can be paired to the vehicle. If the concern is still present, follow normal diagnostics procedures in Workshop Manual (WSM), Section 419-01C.

The document

The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.

Components

Electrical system, Hybrid and electric drive

Trouble codes named

U3000

Vehicles listed
LINCOLN AVIATOR2020, 2021
LINCOLN CORSAIR2020, 2021
LINCOLN NAVIGATOR2020, 2021

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Recalls for the same vehicles and component
20260702026-02-18. High Voltage
20260052026-01-09. Electrical
20256282025-11-14. High Voltage
25V7890002025-11-14. ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY
20255542025-10-10. Electrical
25V3490002025-05-23. ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY
25V3460002025-05-23. ELECTRICAL SYSTEM:BODY CONTROL MODULE:SOFTWARE
20247812024-12-20. High Voltage
24V9540002024-12-20. ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:MANAGEMENT SYSTEM/ENERGY CONTROL MODULE (BMS/BECM)
20235072023-09-12. High Voltage

A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.

Other bulletins for the same vehicles and component
TSB 26-23252026-10-05. Service bulletin. Some of the vehicles listed in the Model statement above may exhibit a front courtesy lamp that is inoperative. This may be due to a concern with the front courtesy lamp light module.
TSB 26-23952026-09-01. Service bulletin. This article supersedes 26-2287. Reason for update: update the labor operation numbers to add MT to operations C, F, G, H, J, K, L and M, and correct the part number LIMZ-4A015-B to L1MZ-4A015-B. Some of the vehicles listed in the Model statement above may exhibit at least one of the following conditions: Harsh engagement Delayed engagement Harsh shift Delayed shift Illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC)s P0751, P0752, P0756, P0757, P0761, P0762, P0766, P0767, P0771, P0772, P2700, P2701, P2702, P2703, P2704, P2705, P2707, P2708, P0729, P0731, P0732, P0733, P0734, P0735, P0736, P076F, P07D9, P07F6 and/or P07F7 stored in the powertrain control module (PCM) or transmission control module (TCM). This may be due to axial movement of the CDF clutch cylinder sleeve causing hydraulic circuit leaks. NOTE: If internal transmission service is required to address a concern detected with the CDF clutch cylinder following this article, technicians should carefully inspect and replace other transmission components and flush transmission fluid cooler only as ne
26N152026-09-01. Other. Customer Satisfaction Program 26N15 Certain 2020-2026 Model Year Escape and 2021-2026 Model Year Corsair Plug-in Hybrid Electric Vehicles (PHEV) – High Voltage Battery Replacement
SSM550592026-08-03. Service bulletin. Some 2021-2023 F-150 vehicles equipped with a 3.5L PowerBoost engine, 2020-2026 Explorer vehicles equipped with a 3.3L hybrid engine, and 2020-2023 Lincoln Aviator vehicles equipped with a 3.0L EcoBoost hybrid engine may exhibit an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble code (DTC) P0A1E stored in the powertrain control module (PCM). The vehicle may be unable to enter electric-only drive modes as expected during normal drive cycles. This may be due to the belt integrated starter generator (BISG). For vehicles with this condition, follow the necessary Pinpoint Test in Workshop Manual (WSM), Section 303-06 for DTC P0A1E and repair the vehicle as directed. Note that previous replacement of the BISG does not negate the need for subsequent BISG replacements if directed to do so by the appropriate Pinpoint Test diagnostics. Engineering is investigating this BISG quality concern. Monitor PTS for updates regarding this investigation.
26E042026-08-03. Emissions. NEW VEHICLE DELIVERY HOLD - Emissions Recall 26E04 Certain 2021-2025 Model Year F-150, Maverick, Mustang, Ranger, Expedition, Bronco Sport, Explorer, Bronco, Navigator, and Aviator Vehicles Powertrain Control Module Software Update
SSM 550282026-07-28. Service bulletin. Some 2021-2024 Ford and Lincoln vehicles may exhibit an "Updating SYNC" message on the vehicle center display screen after an over the air (OTA) update. The message can be cleared from the center display screen and SYNC can be used normally, but it will re-appear at every subsequent ignition cycle. Inform customers that engineering is currently working on a software update solution for this condition to be delivered OTA expected in late Q3 2026. Software will update automatically if vehicle connectivity is enabled in the vehicles settings. Monitor Professional Technician System (PTS) for additional information.
SSM 550372026-07-27. Service bulletin. Some 2018-2024 Expedition and 2018-2027 Navigator vehicles equipped with a rear seat entertainment system/Lincoln Play may experience various system concerns. Rear seat entertainment systems are not on a controller area network (CAN) and are not supported by the Ford Diagnostic and Repair System (FDRS). Certain system concerns may be resolved through software updates which will automatically download once each individual monitor is connected to Wi-Fi. Diagnostic support for rear seat entertainment systems is provided by VOXX electronics. If necessary, contact the VOXX Customer Service Department at 1-866-869-7888. If possible, record the device serial number by selecting the gear/Setup icon > Settings > Device and Software > About. If the unit will not power up, the serial number is on a label on the back of the monitor. It is helpful to know the date the issue occurred, how long the monitors were on prior to the issue, what app/input/media was being used, and if the system software was recently updated prior to the concern starting. For claiming, refer to the Warranty and Policy manual for
23B642026-04-30. Other. Customer Satisfaction Program 23B64 Certain 2020-2024 Model Year Multiple Vehicle Lines Equipped with High Voltage Batteries Battery Energy Control Module (BECM) Software Update
SSM 547202026-04-10. Service bulletin. Various 2020-2026 Ford and Lincoln vehicles equipped with blind spot information system (BLIS) may experience an inoperative blind spot monitoring with a "Blind Spot System Fault" message displayed in the instrument panel cluster (IPC). This may also be accompanied by diagnostic trouble codes (DTCs) B118C:11 and/or B118C:15 stored in the driver door module (DDM), and/or B118D:11 and/or B118D:15 stored in the passenger door module (PDM). This may be due to the wiring connector from the mirror to the BLIS module. If diagnostics lead to an internal mirror wiring harness fault, a new lower level BLIS light pigtail is now released for service. It is not necessary to replace the exterior mirror assembly. Use part number SC3Z-14A411-B to resolve the concern.
24L10 S12026-04-07. Other. Certain 2021-2025 Model Year Corsair Vehicles- Flat Tow Rating Change On the affected vehicles, documentation in the owner’s manual incorrectly states that 2021 – 2025 Corsair PHEV (Plug-in Hybrid Electric Vehicles) can be recreationally flat towed. You cannot recreationally flat tow these vehicles with all wheels on the ground because damage to the powertrain may occur. All 2023-2025 model year vehicles will require dealers to perform a software update to the Accessory Protocol Interface Module (APIM) to install an updated digital owner’s manual. This action may require updates to other modules on the vehicle to receive the correct software.