Service bulletin 04581581A$
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10140150 |
| Published by NHTSA | 2018-06-11 |
| Manufacturer's number | 04581581A$ |
| Manufacturer's date | 2016-03-30 |
| NHTSA component | FUEL SYSTEM, GASOLINE |
NHTSA's summary
Pump - vacuum For DS vacuum pump concerns only; If the vacuum pump continues to run even when the ignition is off; before replacing vacuum pump, please call Tim Parks on cell (248) 245-9395 or Fernando Betancourt on cell (248) 202-7871. If you do not receive a return call within 15 minutes, proceed with the repair.~
The document
The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.
Components
Fuel system
| RAM 1500 | 2015, 2016 |
|---|
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 2022303 | 2022-06-09. Fuel System |
|---|---|
| 22V406000 | 2022-06-09. FUEL SYSTEM, DIESEL:DELIVERY:FUEL PUMP |
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| 9100743 | 2025-12-17. Service bulletin. If Safety Recall Z46 has not been completed, order 68235275AB. |
|---|---|
| 9100744 | 2025-12-17. Service bulletin. If Safety Recall Z46 has been completed, order 68632011AA. |
| S2214000003 | 2022-11-07. Service bulletin. Guidelines For The Use Of Alternative Diesel Fuels. |
| 9003773 | 2022-10-31. Service bulletin. DS Fuel Filler Housing If replacing the housing for a cracked/damaged condition, please call Jordan Weber at (818) 730-2758 prior to removing any parts. If there is no response within 15 minutes, please take a close-up picture that clearly shows the damage and send it and the VIN to Jordan.Weber@fcagroup.com, then replace the housing and filler tube as an assembly without further disturbing the rivets holding the housing to the tube. Please return the part to FCA for analysis. |
| 04581581A | 2022-10-24. Service bulletin. Pump - vacuum For DS vacuum pump concerns only; If the vacuum pump continues to run even when the ignition is off; before replacing vacuum pump, please call Tim Parks on cell (248) 245-9395 or Fernando Betancourt on cell (248) 202-7871. If you do not receive a return call within 15 minutes, proceed with the repair.~ |
| S1625000005 | 2022-10-17. Service bulletin. (Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR Inducement - Forced Engine Shutdown. |
| S2218000001 | 2022-10-17. Service bulletin. Customer concern includes Mil-On/Check Engine Lamp-On. There also may or may not be driveability-related concerns that accompany the Mil-On condition. Upon further investigation, there may be a fault code for P062A-FUEL PUMP CONTROL PERFORMANCE. |
| 9003704 | 2022-09-26. Service bulletin. Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. The fluid in the 8 speeds can be detected with a black light and there are aftermarket spray on leak detection materials to help ensure that the leak is properly diagnosed and not from another location such as cooler lines, heater tubes, or case porosity. Please note that the transmission pan gasket is available for many of the 8 speed applications FCA offers. Please review the available quick connect and transfer tube parts, as replacement of the TMU may not be required. If a TOC line connection is found to be the source, the quick connect may need replacement. If the leak source is coming from the connection of the TMU to the transmission, the transfer tube may need replacement. When parts are returned to the QEC the retaining clips (snap ring) for the quick disconnect fittings are missing. (This leaves a question as to whether the clips were missing from the assembly plant, or the technician removed them in order to make line removal easier.) Please return the clips with the transmission heater and note if they were not there to begin with. For any questions regarding transmission heater, contact FCA Redacted Content. If no response in 15 minutes, proceed with repair. |
| S1818000024 | 2022-09-26. Service bulletin. Diesel Fuel Injector Cleaning Procedure |
| 2500121 | 2022-09-26. Service bulletin. Dual EVAP System Extreme Duty Vapor Canister Filter Kit This informational bulletin is to make technicians aware that an EVAP dual vapor canister filter kit(Mopar part #68478013AA)is available in place of the OEM single vapor canister filter.This kit should not be installed on vehicles driven in normal conditions that are not subjected to the below symptom/conditions. Customers operating fleet or severe/extreme duty gasoline vehicles in continuous dusty driving conditions can plug the single OE filter system and may experience a Malfunction Indicator Lamp (MIL) illumination. Upon furtherinvestigation the technician may find that the following Diagnostic Trouble Codes (DTCs) have been set:P0441 - EVAP Purge System Performance. P062A - Fuel Pump Control Performance. Customers may also experience the following conditions:Hard to fill fuel tank with fuel. Premature shut-off of the gas nozzle when refueling. Flow back of fuel while refueling. |