Service bulletin 06116
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10020173 |
| Published by NHTSA | 2006-08-04 |
| Manufacturer's number | 06116 |
| Manufacturer's date | 2006-01-01 |
| NHTSA component | ENGINE AND ENGINE COOLING:ENGINE |
NHTSA's summary
POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT - SERVICE TIP. *TT
The document
No address for NHTSA's copy can be built for this communication. Ask the dealer for it by the manufacturer's number.
Components
Engine
| FORD ESCAPE | 2004, 2005, 2006 |
|---|---|
| FORD ESCAPE HYBRID | 2005 (the catalog's model; the bulletin names a series or trim of it) |
| FORD FOCUS | 2003, 2004, 2005, 2006 |
| FORD FUSION | 2006 |
| FORD RANGER | 2001, 2002, 2003, 2004, 2005, 2006 |
| MERCURY MARINER | 2005, 2006 |
| MERCURY MARINER HEV | 2006 (the catalog's model; the bulletin names a series or trim of it) |
| MERCURY MILAN | 2006 |
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 2014374 | 2014-09-04. Engine |
|---|---|
| 12V353000 | 2012-07-26. VEHICLE SPEED CONTROL:CABLES; ENGINE AND ENGINE COOLING |
| 2004426 | 2004-12-08. Engine |
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| SSM 52243 | 2024-02-14. Service bulletin. When performing any transmission fluid change or topoff involving Motorcraft® Premium ATF, MERCON® V has replaced all versions of Motorcraft® Premium ATF and can be used going forward. Mixing Motorcraft® Premium ATF and MERCON® V in the same transmission is acceptable. After 31-Jan-2024, Motorcraft® Premium ATF will no longer be manufactured and will only be available until inventory depletes. |
|---|---|
| SSM 46085 | 2017-08-01. Service bulletin. The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information. |
| TSB-12-8-1 | 2012-12-12. Service bulletin. FORD/LINCOLN/MERCURY: MAY HAVE SLUDGE BUILDUP IN THROTTLE BODY LEADING TO LESS AIRFLOW OR ENGINE IDLING RPM FLUCTUATION AND HARD STARTS OR BATTERY DISCONNECT OR DEAD BATTERY AFTER KEEP ALIVE MEMORY (KAM) CLEAR. MODELS 2003-05 THUNDERBIRD, 05-06 MUSTANG, 06-08 FUSION, 04-05 EXPLORER, 05-06 EXPEDITION, 05-07 F-150; 2003-06 LS, 06 ZEPHYR, 05-06 NAVIGATOR; 06-08 MILAN. *PE |
| TSB-10-18-10 | 2011-04-18. Service bulletin. FORD/MERCURY: MIL ON WITH DTC P0351-P0356; MULTIPLE COIL PRIMARY CIRCUIT. BUILT ON OR BEFORE 10/03/05. SOME VEHICLES EQUIPPED WITH A 3.0L ENGINE MAY EXHIBIT A MULFUNCTION INDICATOR LAMP (MIL) ON WITH TWO OR MORE DIAGNOSTIC TROUBLE CODES (DTCS) FOR COIL ON PLUG (COP) PRIMARY CIRCUIT FAULTS. *PE |
| TSB-09-15-3 | 2010-06-26. Service bulletin. FORD/MERCURY: SOME VEHICLES MAY SET DIAGNOSTIC TROUBLE CODES (DTCS) P0A81 (BATTERY PACK COOLING FAN 1 CONTROL CIRCUIT) AND/OR P0A96 (BATTERY PACK COOLING FAN 2 CONTROL CIRCUIT) IN THE TRACTION BATTERY CONTROL MODULE (TBCM). THESE CODES BY THEMSELVES NORMALLY DO NOT RESULT IN ANY SYMPTOMS THAT ARE NOTICEABLE TO THE CUSTOMER. REPLACE BOTH HIGH VOLTAGE TRACTION BATTERY (HVTB) COOLING FANS. *PE |
| TSB-08-15-1 | 2009-06-26. Service bulletin. FORD/MERCURY: VEHICLES USED IN CERTAIN COMMERCIAL APPLICATIONS SUCH AS TAXI'S AND SECURITY SERVICES WHERE EXTENDED LOW SPEED RUN TIME AND EXTENDED IDLING MAY EXHIBIT A RED TRIANGLE LIGHT AND CODES INDICATING A TRANSAXLE OVERTEMP. THIS CONDITION MAY RESULT IN REDUCED POWER AS THE SYSTEM ACTIVATES FAIL SAFE OPERATION. *PE |
| CSP-08B01 | 2008-10-24. Service bulletin. FORD: CERTAIN 1999-2001 MODEL YEAR VEHICLES UP TO 6000 LB GVWR REGISTERED IN NEW YORK AND CERTAIN 2001 VEHICLES UP TO 6000 LB GVWR REGISTERED IN THE STATE OF MAINE, CERTIFIED FOR SALE IN CALIFORNIA-FEDERAL EMISSION WARRANTY REFUND. *PE |
| 0756 | 2007-06-11. Service bulletin. ENGINE STALLING ON ENGAGEMENT/STOPPING. *KB |
| 061614 | 2007-02-27. Service bulletin. SPARK KNOCK, HARD START AND/OR HESITATION - VEHICLES BUILT AFTER 08-02-2004 WITH A 3.0L ENGINE. *KB |
| 06166 | 2007-02-27. Service bulletin. POSSIBLE ENGINE DAMAGE - INSTALL SPECIAL SERVICE TOOLS PRIOR TO REMOVING CRANKSHAFT PULLEY BOLT. *KB |