WenmarOpen by Wenmar Pro

Service bulletin 17406

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
TypeService bulletin
NHTSA id10008288
Published by NHTSA2004-07-26
Manufacturer's number17406
Manufacturer's date2004-09-01
Replaces18147
NHTSA componentENGINE AND ENGINE COOLING:ENGINE

NHTSA's summary

LOW POWER, POOR FUEL ECONOMY, FUEL GELLING COLD, EXCESSIVE WHITE SMOKE COLD, OR HARD START. *MJ THIS OASIS UPDATES PREVIOUS OASIS DATED 12/01/03. *TT

The document

No address for NHTSA's copy can be built for this communication. Ask the dealer for it by the manufacturer's number.

Components

Engine

Vehicles listed
FORD ECONOLINE1999 to 2003
FORD EXCURSION1999
FORD EXCURSION2000, 2001, 2002, 2003, 2004, 2005
FORD F-2502004
FORD F-250 SD1999, 2000, 2001, 2002, 2003 (the catalog's model; the bulletin names a series or trim of it)
FORD F-250 SD2005 (the catalog's model; the bulletin names a series or trim of it)
FORD F-3502004
FORD F-350 SD1999, 2000, 2001, 2002, 2003 (the catalog's model; the bulletin names a series or trim of it)
FORD F-350 SD2005 (the catalog's model; the bulletin names a series or trim of it)
FORD F-450 SD1999, 2000, 2001, 2002, 2003, 2004 (the catalog's model; the bulletin names a series or trim of it)
FORD F-550 SD1999, 2000, 2001, 2002, 2003, 2004 (the catalog's model; the bulletin names a series or trim of it)
FORD F-6501999
FORD F-6502000, 2001, 2002, 2003
FORD F-650 SD2004, 2005 (the catalog's model; the bulletin names a series or trim of it)
FORD F7501999
FORD F7502000, 2001, 2002, 2003, 2004, 2005

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Recalls for the same vehicles and component
20074032007-12-12. Engine
07V5530002007-12-05. ENGINE AND ENGINE COOLING:ENGINE:DIESEL
19990611999-04-15. Engine

A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.

Other bulletins for the same vehicles and component
25E092026-07-01. Emissions. NEW VEHICLE DEMONSTRATION / DELIVERY HOLD Emissions Recall 25E09 Certain 2022 Model Year F-250 - F-600 Vehicles with 6.7L Engines Powertrain Control Module Programming and Particulate Matter Sensor Installation
24L052025-10-03. Other. Certain 2011-2022 Model Year Super Duty Vehicles Equipped with 6.7L Engine - Emission Control Information Label Update for Qualified Vehicles
SSM 460852017-08-01. Service bulletin. The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
TSB-14-01142014-09-17. Service bulletin. LINCOLN/FORD: WHEN DRIVING FROM IDLE UP TO 1200 RPM, THERE MAY BE AN INTERMITTENT RATTLE NOISE COMING FROM ENGINE. 2004-2013 F-150, F-250, F-350, EXPEDITION, MARK LT, NAVIGATOR. *PE
ASI-444042014-06-24. Service bulletin. FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003-2007 F SUPER DUTY, 2004-2010 E SERIES, 2003-2005 EXCURSION.
TSB-11-4-32011-06-28. Service bulletin. FORD: 2005-2011 F250/F350. THE FUEL FILL NOZZLE MAY AUTOMATICALLY SHUT OFF TOO EARLY. *RM
TSB-09-20-122010-04-20. Service bulletin. FORD: SOME SUPER DUTY TRUCKS EQUIPPED WITH A 5.4L 3V OR 6.8L 3V ENGINE MAY EXPERIENCE PREMATURE AUTOMATIC SHUT OFF OF THE FUEL FILL NOZZLE. *PE
TSB-09-15-62009-12-09. Service bulletin. FORD: SOME VEHICLES EQUIPPED WITH THE 6.0L ENGINE MAY EXPERIENCE A P006A, P132, P0401 OR P0402 DIAGNOSTIC TROUBLE CODE (DTC) WITH A LACK OF POWER CONDITION, SURGE, OR TURBOCHARGER FLUTTER AFTER PERFORMING FIELD SERVICE ACTION (FSA) 06E17, OR AFTER RECALIBRATING THE VEHICLE WITH THE INFERRED EXHAUST PRESSURE (EBP) STRATEGY. *PE
TSB-08-26-32009-06-01. Service bulletin. FORD: SOME VEHICLES WITH DIESEL ENGINES MAY EXPERIENCE NO STARTS, HARD STARTS OR ROUGH RUNNING WHEN COLD AND MAY BE ACCOMPANIED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0611, P1378 AND/OR ALL 8 INJECTOR CIRCUIT CODES. *PE
TSB-08-16-132009-05-20. Service bulletin. FORD: SOME VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINE MAY EXHIBIT ANY ONE OR COMBINATION OF THE FOLLOWING CONCERNS-LACK OF POWER, WHITE/BLACK SMOKE OR A SURGE. *PE