Other 24L05
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Other |
|---|---|
| NHTSA id | 11023852 |
| Published by NHTSA | 2025-10-03 |
| Manufacturer's number | 24L05 |
| Manufacturer's date | 2025-09-24 |
| NHTSA component | ENGINE; UNKNOWN OR OTHER |
NHTSA's summary
Certain 2011-2022 Model Year Super Duty Vehicles Equipped with 6.7L Engine - Emission Control Information Label Update for Qualified Vehicles
The document
The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.
Components
Engine
| FORD F-250 | 2011, 2012, 2013, 2014 |
|---|---|
| FORD F-350 | 2011, 2012, 2013, 2014 |
| FORD F-350 SD | 2001, 2002 (the catalog's model; the bulletin names a series or trim of it) |
| FORD F-350 SD | 2018, 2019 (the catalog's model; the bulletin names a series or trim of it) |
| FORD F-450 SD | 2011, 2012, 2013, 2014, 2015, 2016, 2017, 2018, 2019, 2020, 2021, 2022 (the catalog's model; the bulletin names a series or trim of it) |
| FORD F-550 SD | 2011, 2012, 2013, 2014, 2015, 2016, 2017, 2018, 2019, 2020, 2021, 2022 (the catalog's model; the bulletin names a series or trim of it) |
| FORD redundant F-250 | 2015 to 2022 |
| FORD redundant F-350 | 2015 to 2016 |
| FORD redundant F-350 | 2018 to 2021 |
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 19V278000 | 2019-04-08. ENGINE; EQUIPMENT:ELECTRICAL |
|---|---|
| 18V894000 | 2018-12-18. ENGINE |
| 15V371000 | 2015-06-15. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM |
| 2015125 | 2015-03-24. Engine |
| 15V052000 | 2015-01-30. ENGINE AND ENGINE COOLING:ENGINE |
| 14V411000 | 2014-07-08. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE |
| 14V382000 | 2014-06-10. EQUIPMENT; ENGINE AND ENGINE COOLING:ENGINE:GASOLINE |
| 14V379000 | 2014-06-10. EQUIPMENT; ENGINE AND ENGINE COOLING:ENGINE:GASOLINE |
| 2013372 | 2013-10-30. Engine |
| 13V535000 | 2013-10-30. ENGINE |
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| 26E02 | 2026-09-01. Other. NEW VEHICLE DELIVERY HOLD Emissions Recall 26E02 Certain 2016-2019 F-650 - 750 and 2017-2019 F-350 - 550 Vehicles Equipped With 6.7L Diesel Engines Crankcase Ventilation (CCV) Inspection And Replacement |
|---|---|
| 26N03 | 2026-09-01. Other. Customer Satisfaction Program 26N03 Certain 2017-2019 Model Year Super Duty Vehicles w/ 6.7L Diesel Engines Diesel Particulate Filter Replacement, If Required After Dealer Evaluation |
| SSM 55098 | 2026-08-25. Service bulletin. Some 2013-2016 Super Duty vehicles equipped with a 6.7L diesel engine and 2015-2019 Transit vehicles equipped with a 3.2L diesel engine may not pass a state smog test due to the exhaust gas system (EGS) monitor that will not run after completing the exhaust gas sensor drive cycle located within Section 2 of the Powertrain Control/Emissions Diagnostics (PC/ED) Manual > Drive Cycles. This may be due to the vehicles diesel oxidation catalyst (DOC) age counter being under the 120-minute age requirement. There is an all-new "PCM Catalytic Converter Age Evaluation" application within the latest version of the Ford Diagnosis and Repair System (FDRS). Use this new FDRS application to determine the age (in minutes) of the DOC. If the age is less than 120 minutes, perform manual regenerations to increase the catalyst age counter to satisfy the monitor age requirement. If further assistance is needed, contact the technical assistance center (TAC). Note: this article only applies to the EGS monitor. Problems with other vehicle monitors not running successfully must be addressed using normal diagnostics located i |
| TSB 26-2375 | 2026-08-19. Service bulletin. This article supersedes TSB 26-2050 to increase the labor operation allowance of labor operations A and B. Some of the vehicles listed in the Model statement above may exhibit all of the following conditions: Poor shift quality Illuminated powertrain malfunction (wrench) indicator with diagnostic trouble codes (DTC) P2704 and P0771 stored in the PCM/TCM. This may be due to a calibration in the TCM and/or wear between the input shaft and the E clutch hub causing the input shaft O-rings to become damaged resulting in an open E clutch circuit. Additional model information: 6.7L Diesel Engine 2022-2024 F-550 or F-600 F-Super Duty vehicles built on or before 15-May-2024 with over 5,000 miles (8,000km) |
| 25M01 | 2026-08-04. Other. Customer Satisfaction Program 25M01 Certain 2021 Model Year F-150 3.0L Diesel Engine and 2020-2022 Model Year Super Duty with 6.7L Diesel Engine Nitrogen Oxide (NOx) Sensor Replacement, If Required After Dealer Evaluation Reference: Emissions Recalls 22E02, 22E04, 23E01, and 25E09 |
| 25E09 | 2026-07-01. Emissions. NEW VEHICLE DEMONSTRATION / DELIVERY HOLD Emissions Recall 25E09 Certain 2022 Model Year F-250 - F-600 Vehicles with 6.7L Engines Powertrain Control Module Programming and Particulate Matter Sensor Installation |
| 25N14 | 2026-07-01. Other. Certain 2022 Model Year F-250 - F-600 with 6.7L Diesel Engines One-Time Replacement for Diesel Particulate Filter Assembly Failures, If Required After Dealer Evaluation |
| 22N05-S3 | 2026-07-01. Service bulletin. Customer Satisfaction Program 22N05 - Supplement #3 Certain 2022 Model Year Super Duty with 6.7L Diesel Engine One-Time Replacement for Diesel Particulate Filter Assembly If Required After Dealer Evaluation |
| TSB 26-2256 | 2026-06-22. Service bulletin. This article supersedes TSB 25-2572 to update the Parts List to correct the part number LC3Z-6006-L to LC3Z-6781-A, remove the flex plate bolts AL3Z-6379-BA from the parts list as these bolts are in kit LC3Z-6781-A, update the claim quantity of the part number W709771-S440 to 9 pieces (F-650/F750-Engine Replacement), W706447-S437 and W715068-S437 to 4 pieces, W712861-S439 to 8 pieces(F-Super Duty Pickup And Chassis Cab-Engine Replacement) / 8 pieces (F-53 Motorhome/F-59 Stripped Chassis Cab/F-650,F750 Engine Replacement) / W714286-S442 to 4 pieces (F-Super Duty Pickup And Chassis Cab-Camshaft and Tappet Repair / F-Super Duty Pickup And Chassis Cab-Engine Replacement), include LC3Z-6020-A for the Engine replacement lists, include 1 fuel injector seal kit to the Camshaft and Tappet repair lists, include 4 pieces of W520114-S440 to the E Series-Camshaft and Tappet Repair list, and update the engine oil part numbers XO-5W30-Q1SP and CXO-5W30-LSP6. Some of the vehicles listed in the Model statement above may exhibit an upper engine ticking or tapping noise at idle. Customers may also report experiencing ro |
| SSM 54690 | 2026-04-06. Service bulletin. Some 2013-2016 Super Duty vehicles equipped with a 6.7L diesel engine and 2015-2019 Transit vehicles equipped with a 3.2L diesel engine may not pass a state smog test due to the exhaust gas system (EGS) monitor that will not run after completing the Exhaust Gas Sensor drive cycle located within Section 2 of the Powertrain Control/Emissions Diagnostics (PC/ED) Manual > Drive Cycles. This may be due to the vehicles diesel oxidation catalyst (DOC) age counter being under the 120-minute requirement. Engineering is investigating this issue and working on a solution. |