Transport Canada recall 2023423
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | Transport Canada (Canada) |
|---|---|
| Campaign number | 2023423 |
| Manufacturer's number | RS183 |
| Reported | 2023-08-01 |
| Component | Powertrain |
| Notification type | Safety Mfr |
| Units potentially affected | 13037 |
What is wrong
Issue:
On certain vehicles, fluid could leak onto the printed circuit board for the hydraulic clutch actuator (HCA). If this happens, the circuit board could short circuit.
Safety Risk:
A short circuit could create the risk of an engine compartment fire while driving.
Corrective Actions:
Kia will notify owners by mail and advise you to take your vehicle to a dealership to inspect the hydraulic clutch actuator (HCA), and replace it if necessary. The technician will also install a new fuse for the HCA to reduce the risk of a fire.
| 2017 KIA NIRO | |
|---|---|
| 2018 KIA NIRO | |
| 2019 KIA NIRO | |
| 2020 KIA NIRO | |
| 2021 KIA NIRO | |
| 2022 KIA NIRO |
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| TSB_TRA046_R5 | 2025-04-23. Service bulletin. TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, and the transmission oil cooler is transferred to the new transmission. |
|---|---|
| TSB_TRA046_R4 | 2024-06-04. Service bulletin. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced. |
| TSB_TRA046_R3 | 2022-12-06. Service bulletin. TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles in the chart starting on page 2. |
| TSB_ELE247 | 2021-10-02. Service bulletin. TECHNICAL SERVICE BULLETIN: SERVICE ACTION: HCU/LDC LOGIC IMPROVEMENT FOR P-DTC (SA484) - This bulletin provides the procedure to update the software logic of the Hybrid Control Unit/Low Voltage DC/DC Converter (HCU/LDC) system on some 2020-2021MY Niro HEV (DE HEV) and Niro PHEV (DE PHEV) vehicles produced in the date ranges shown below, which may incorrectly set a Power Train Diagnostic Trouble Code (P-DTC). |
| TSB_ELE234_R1 | 2021-05-19. Service bulletin. TECHNICAL SERVICE BULLETIN: DRIVE UNIT INSPECTION & REPLACEMENT FOR EV MOTOR RUMBLE NOISE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to inspect and repair the EV motor drive unit and reduction gear on some 2019MY~ Niro EV (DE EV) vehicles produced from December 5, 2018, which may exhibit an abnormal rumble noise while driving (refer to noise sample videos below). The rumble noise may be heard repeatedly when the traction motor is operating, while driving slowly in "D" range, or when slowly accelerating/decelerating between 0~25 mph. |
| TSB_TRA093 | 2021-03-04. Service bulletin. TECHNICAL SERVICE BULLETIN: 6-SPEED DCT SHIFT IMPACT/NOISE INSPECTION AND OIL REPLACEMENT - This bulletin provides the inspection method and procedure on some 2019-2020MY Niro (DE HEV/PHEV) vehicles equipped with 6-speed Dual Clutch Transmission (DCT), produced after January 11, 2019, which may exhibit an intermittent noise and/or shift impact. The shift impact may be a noticeable “shift shock”, “clunk”, or other abnormal symptom felt when the vehicle starts after a complete stop. |
| TSB_TRA092 | 2021-01-06. Service bulletin. TECHNICAL SERVICE BULLETIN: 6-SPEED DOUBLE CLUTCH OR DCT REPLACEMENT - This bulletin provides the procedure to replace the Double Clutch set or Double Clutch Transmission (DCT) assembly on some 2018-2019MY Niro (DE HEV, DE PHEV) vehicles, equipped with the 6-Speed DCT, which may exhibit an abnormal “Grrrr and/or grinding” noise when down shifting from 4th to 3rd gear. |
| TSB_TRA046_R1 | 2020-05-05. Service bulletin. TECHNICAL SERVICE BULLETIN: - TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles on page 2. Refer to the shop manual on KGIS for the specific Kia model for the correct transmission fluid check/fill procedures. |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.