Transport Canada recall 2022242
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | Transport Canada (Canada) |
|---|---|
| Campaign number | 2022242 |
| Manufacturer's number | R0216 (21DA11) |
| Reported | 2022-05-07 |
| Component | Fuel System |
| Notification type | Safety Mfr |
| Units potentially affected | 13474 |
What is wrong
Issue:
Over time, the fuel feed line to the high-pressure fuel pump could leak. If this happens, there could be a fuel odour or fuel leak in the engine compartment.
Note: This recall includes all vehicles that didn't have the fuel feed line replaced under recall R0166 (Transport Canada #2020-084).
Safety Risk:
A fuel leak can create the risk of a fire.
Corrective Actions:
Hyundai will notify owners by mail and instruct you to take your vehicle to a dealership to replace the fuel feed line.
| 2013 HYUNDAI SONATA | |
|---|---|
| 2014 HYUNDAI SONATA |
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| 964DBP | 2021-09-17. Service bulletin. 2011-2015MY Sonata Hybrid (YFE) vehicles Onboard Refueling Vapor Recovery (ORVR) system may exceed its capacity in certain situations. This campaign provides information on the procedures to install an Auxiliary Canister to increase the ORVR system capacity. There are no drivability concerns associated with this condition. |
|---|---|
| 21-01-036H | 2021-09-17. Service bulletin. 2011-2015MY Sonata Hybrid (YF HEV) vehicles Onboard Refueling Vapor Recovery (ORVR) system may exceed its capacity in certain situations. This bulletin provides the procedure to install an Auxiliary Canister to increase the ORVR system capacity. There are no drivability concerns associated with this condition. |
| 19-FL-001H | 2019-03-18. Service bulletin. In a gasoline direct injection (GDI) engine, highly pressurized gasoline is injected via a common rail fuel line and injectors that deliver fuel directly into the combustion chamber of each cylinder. In comparison, in a conventional multi-point fuel injection (MPI) engine, relatively low pressure gasoline is injected into the intake port of each cylinder. Due to high fuel pressures in a GDI system, servicing the GDI system requires special attention and handling procedures. This bulletin provides special service information and specification for the GDI fuel system components. |
| 5NPH9L4R02 | 2017-09-22. Service bulletin. Hyundai has launched a service campaign to inspect and if needed, repair the evaporative emissions canister and bracket on certain model year 2011? 2015 Hyundai Sonata Hybrid and 2012 ? 2016 Veloster vehicles. This campaign affects such vehicles registered in and operated in Alaska, Connecticut, Delaware, Illinois, Indiana, Iowa, Kansas, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, Nebraska, New Hampshire, New Jersey, New York, North Dakota, Ohio, Pennsylvania, Rhode Island, South Dakota, Utah, Vermont, West Virginia, and Wisconsin, and the District of Columbia. Reason for this Service Campaign During winter months, large quantities of salt are used to de-ice roads in the states noted above. Road salt and water can corrode the bracket holding the canister in place; as well as the seal within the canister. This can result in the need to replace these components and if necessary, the canister itself. |
| 5NP-Z2J3V-04 | 2017-08-10. Service bulletin. Some Veloster (FS) and Sonata Hybrid (YF HEV) vehicles may experience a check engine warning light ON with any of the following DTCs found stored: ? P0442 - Evaporative System (EVAP) - Small Leak ? P0455 - Evaporative System (EVAP) - Large Leak ? P0456 - Evaporative System (EVAP) - Very Small Leak |
| 14-FL-002 | 2016-03-31. Service bulletin. SUMMARY TO BE PROVIDED ON A FUTURE DATE. |
| TSB-13-FL-003 | 2013-09-21. Service bulletin. HYUNDAI: INFORMATION REGARDING THE INSPECTION PROCEDURE FOR FUEL LEVEL SENDER AND SYMPTOMS OF CHECK ENGINE LIGHT ON, ERRATIC OR UNRESPONSIVE FUEL GAUGE OR FUEL GAUGE DOES NOT REACH FULL LEVEL AFTER FILLING UP. MODELS 2012-2014 GENESIS, 2006-2014 SONATA, 2010-2014 TUCSON. *PE |
| FIR-0909 | 2013-09-10. Service bulletin. HYUNDAI: PROCEDURE INFORMATION PROVIDED ON SYMPTOMS AND INSPECTION OF FUEL LEVEL SENDER WITH CERTAIN SYMPTOMS. MODELS 2006-2011 SONATA, 2012 GENESIS, 2010 TUCSON. *PE |
| TSB-13-FL-002 | 2013-06-18. Service bulletin. HYUNDAI: THE THROTTLE CONTROL (ETC) BODY, ON SOME VEHIICLES, NEEDS TO BE CLEANED AND PROCEDURAL INFORMATION IS BEING PROVIDED, DUE TO DEPOSITS FOUND AT VALVE-TO-BORE INTERFACE. MODELS 2011-2013 ELANTRA, 2010-2013 GENESIS COUPE, 2010-2013 SANTA FE, 2006-2013 SONATA, 2010-2013 TUCSON. *PE |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.