Transport Canada recall 2019535
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | Transport Canada (Canada) |
|---|---|
| Campaign number | 2019535 |
| Manufacturer's number | VB1 |
| Reported | 2019-10-25 |
| Component | Engine |
| Notification type | Safety Mfr |
| Units potentially affected | 50259 |
What is wrong
Issue:
On certain trucks equipped with a 3.0-L EcoDiesel engine, the exhaust gas recirculation (EGR) cooler could crack internally and leak. If this happens, a driver may notice a low coolant level or a heater that does not work properly.
Safety Risk:
A cracked EGR cooler could create the risk of an engine fire.
Corrective Actions:
FCA Canada will notify owners by mail and instruct you to take your vehicle to a dealer to replace the EGR cooler. Dealers will also inspect intake manifold and replace it as necessary.
| 2014 RAM 1500 | |
|---|---|
| 2015 RAM 1500 | |
| 2016 RAM 1500 | |
| 2017 RAM 1500 | |
| 2018 RAM 1500 | |
| 2019 RAM 1500 |
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| 9100898 | 2026-09-17. Service bulletin. Engine PNs: MY 24-26 WD/DT (5.7L) Code P00B is being misdiagnosed and incorrect parts are being installed causing over repair. Refer to SOL S2609000006 The IAFM Foam Engine Valley Cover (PN 53013735AB) does not provide sufficient clearance for proper routing of the MDS solenoid jumper harness (PN 05148163AE). As a result, the harness may become compressed by the foam cover. To prevent unnecessary part replacement, the MDS solenoid jumper harness (PN 05148163AE) should be inspected for damage or pinch conditions prior to replacing the following part numbers: Engine PNs: 68409343AA 68409357AA 68450915AA OCV PNs: 53022338AB Phaser PNs: 53022298AA 53022298AB |
|---|---|
| 9100839 | 2026-06-18. Service bulletin. 3-way valves are available in STAR Parts as two distinct components and must be selected correctly based on application. The High Temp 3-way valve (68309834AC) is located between the engine and the bulkhead at the rear of the engine compartment. The Low Temp 3-way valve (68448241AA) is located between the engine and the radiator at the front of the engine. When ordering or servicing, ensure the correct valve is identified and installed in the proper location, as incorrect part selection may lead to improper thermal system operation and repeat repairs. |
| 18-044-26 | 2026-03-25. Service bulletin. Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must SYMPTOM: exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● **P0111-00 - Intake Air Temperature Sensor 1 Circuit Range Performance Bank 1. (In Active or Stored status) ● P0071-00 - Ambient Air Temperature Sensor Performance. (In Active or Stored status) ● P0072-00 - Ambient Air Temperature Sensor Circuit "A" Low. (In Active or Stored status) ● P0073-00 - Ambient Air Temperature Sensor Circuit "A" High. (In Active or Stored status) ● P0011-00 - Bank 1 Camshaft 1 Position Timing Over Advanced Or. (In Active or Stored status) ● P25E4-00 - B Camshaft Position - Unable To Achieve Locked Position Bank 1. (In Active or Stored status) ● P05BD-00 - Stop-Start Mode Switch Range/Performance. (In Active or Stored status) ● P0116-00 - Engine Coolant Temperature Sensor 1 Performance. (In Active or Stored status) ● P062B-00 - Internal Control Module Fuel Injector Control Performance. (In Active or Stored status) ● P0604-00 - Internal Control Module Random Access Memory Ram Error. (In Active or Stored status) ● P060C-00 - Internal Control Module Main Processor Performance. (In Active or Stored status)** ● P018B-00 - Fuel Pressure Sensor "B" Circuit Range/performance. **(In Active or Stored status)** ● P1CEA-00 - Boost Side EVAP Purge System Performance. **(In Active or Stored status)** ● P06DD-00 - Engine Oil Pressure Control Circuit Performance/Stuck Off. **(In Active or Stored status)** ● P00C6-00 - Fuel Rail Pressure Too Low - Engine Cranking. **(In Active or Stored status)** ● P0300-00 - Multiple Cylinder Misfire. **(In Active or Stored status)** Customers may also experience one or more of the following: ● **Oil Level High Warning in the Instrument Panel Cluster (IPC).** ● Fully Autonomous Parking Assist (FAPA) is not deactivated when accelerator pedal is pressed. ● Vehicle is not heating up fast enough at freezi |
| 109621 | 2026-01-28. Warranty extension. D-25-17 Rev. A ALL Model Years 2019 - 2021 VF, DS, LA, LD and LX with a 3.6L Engine for Camshaft and/or Rocker Arm Replacements |
| 109767 | 2026-01-28. Warranty extension. ID-25-14 Rev. A ALL Model Years 2019 - 2021 VF, DS, LA, LD and LX with a 3.6L Engine for Camshaft and/or Rocker Arm Replacements |
| 109727 | 2026-01-28. Service bulletin. Water Pump & Chain Case Cover |
| 109724 | 2026-01-28. Service bulletin. Water Pump & Chain Case Cover |
| S2509000009 | 2025-11-05. Service bulletin. Engine Oil Leak |
| 107563 | 2025-10-02. Warranty extension. D-25-17 ALL Model Years 2019 - 2021 VF, DS, LA, LD and LX with a 3.6L Engine for Camshaft and Rocker Arm Replacements |
| 107564 | 2025-10-02. Warranty extension. ID-25-14 ALL Model Years 2019 - 2021 VF, DS, LA, LD and LX with a 3.6L Engine for Camshaft and Rocker Arm Replacements |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.