Transport Canada recall 2016337
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | Transport Canada (Canada) |
|---|---|
| Campaign number | 2016337 |
| Manufacturer's number | S48 |
| Reported | 2016-06-29 |
| Component | Powertrain |
| Notification type | Safety Mfr |
| Units potentially affected | 42 |
What is wrong
On certain cab chassis trucks, due to a defect in the transfer case, the rear main output shaft could fracture. This could result in a loss of motive power, which, in conjunction with traffic and road conditions, and the driver's reactions may increase the risk of a crash. This would also cause a loss of PARK functionality when in two wheel drive, potentially leading to unintended vehicle movement. These issues could result in injury and/or damage to property Correction: Dealers will replace the transfer case. Note: The vehicle will remain operable in four wheel drive.
| 2016 RAM 3500 | |
|---|---|
| 2016 RAM 4500 | |
| 2016 RAM 5500 |
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| 102307 | 2025-01-06. Service bulletin. GEAR - REACTION SUN |
|---|---|
| 102387 | 2025-01-04. Service bulletin. SEAL - OUTPUT SHAFT |
| 102389 | 2025-01-04. Service bulletin. SEAL - OUTPUT SHAFT |
| 101232 | 2024-11-07. Service bulletin. Plate - Planetary |
| S1623000028 Rev. | 2023-02-13. Service bulletin. Outside Power Fold Rearview Mirror Noise Or Loose At Pivot. Mirror Contacts Door Window Glass In The Folded Position. |
| 1813022REVA | 2023-01-17. Service bulletin. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. The customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following DTCs: P20EE - SCR NOx Catalyst Efficiency Below Threshold - Bank 1. P1C54 - SCR NOx Catalyst Missing. P229F - Aftertreatment NOx Sensor Circuit Performance - Bank 1 Sensor 2. P207F - Reductant Quality Performance. P2002 - Diesel Particulate Filter Efficiency Below Threshold. P2201 - Aftertreatment NOx Sensor Circuit Performance - Bank 1 Sensor 1. P202E - (Diesel Exhaust Fluid) Reductant Injector Performance. P0300 - Multiple Cylinder Misfire. P0301-00 - Cylinder 1 Misfire. P0302-00 - Cylinder 2 Misfire. P0303-00 - Cylinder 3 Misfire. P0304-00 - Cylinder 4 Misfire. P0305-00 - Cylinder 5 Misfire. P0306-00 - Cylinder 6 Misfire. P249E - Closed Loop SCR Reductant Injection Control At Limit - Flow Too High. P0128 - Thermostat Rationality. P218F - Reductant No Flow Detected. U0001-00 - CAN C BUS. P24A5 - EGR Cooler Bypass Bank 1 Control Stuck. P1451 - Diesel Particulate Filter System Performance. P229E - NOx Sensor Circuit - Bank 1 Sensor 2. P0218 - Transmission High Temperature Operation Activated (68RFE Only). P0868 - Line Pressure Low, MIL Action (68RFE Only). U110E - Lost Ambient Temperature Message. P205E - (Diesel Exhaust Fluid) Reductant Tank Temperature Sensor Circuit Intermittent (setting when the block heater is plugged in). The following DTCs have been changed from a one trip fault to a two trip fault:P0421 - Catalyst 1 Efficiency Below Threshold Bank 1. P2280 - Air Flow Restriction / Leak Between Air Cleaner And MAF. P203C - (Diesel Exhaust Fluid) Reductant Level Sensor Circuit Low. P208D - (Diesel Exhaust Fluid) Reductant Pump Control Circuit High. In addition to addressing the above DTCs, |
| 1813022 | 2023-01-17. Service bulletin. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. The customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following DTCs. P0401 - EGR System Performance. P2281 - Air Leak Between MAF and Throttle Body. P0402 - Egr Flow Excessive Detected. P0234 - Turbocharger Overboost Condition. P049D - Egr Control Position Exceeded Learning Limit. P040B - Exhaust Gas Recirculation Temperature Sensor "A" Circuit Performance. P064F - Unauthorized Software/Calibration Detected. P20EE - SCR NOx Catalyst Efficiency Below Threshold - Bank 1. P1C54 - SCR NOx Catalyst Missing. P229F -Aftertreatment NOx Sensor Circuit Performance - Bank 1 Sensor 2. P207F - Reductant Quality Performance. P2002 - Diesel Particulate Filter Efficiency Below Threshold. P2201 - Aftertreatment NOx Sensor Circuit Performance - Bank 1 Sensor 1. P202E - (Diesel Exhaust Fluid) Reductant Injector Performance. P0300 - Multiple Cylinder Misfire. P0301-00 - Cylinder 1 Misfire. P0302-00 - Cylinder 2 Misfire. P0303-00 - Cylinder 3 Misfire. P0304-00 - Cylinder 4 Misfire. P0305-00 - Cylinder 5 Misfire. P0306-00 - Cylinder 6 Misfire. P249E - Closed Loop SCR Reductant Injection Control At Limit - Flow Too High. P0128 - Thermostat Rationality. P218F - Reductant No Flow Detected. U0001-00 - CAN C BUS. P24A5 - EGR Cooler Bypass Bank 1 Control Stuck. P1451 - Diesel Particulate Filter System Performance. P229E - NOx Sensor Circuit - Bank 1 Sensor 2. P0218 - Transmission High Temperature Operation Activated (68RFE Only). P0868 - Line Pressure Low, MIL Action (68RFE Only). U110E - Lost Ambient Temperature Message. P205E - (Diesel Exhaust Fluid) Reductant Tank Temperature Sensor Circuit Intermittent (setting when the block heater is plugged in). |
| S1709000010 | 2023-01-09. Service bulletin. Customer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that camshaft/lifter replacement is necessary. |
| 1802716REVB | 2022-12-19. Service bulletin. Flash: 6.7L Diagnostic And System Improvements This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. The following DTCs have been changed from a one trip fault to a two trip fault: · P0421 - Catalyst 1 Efficiency Below Threshold Bank 1. · P2280 - Air Flow Restriction / Leak Between Air Cleaner And MAF. · P203C - (Diesel Exhaust Fluid) Reductant Level Sensor Circuit Low. · P208D - (Diesel Exhaust Fluid) Reductant Pump Control Circuit High. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation a technician may find the following DTCs set in the PCM memory: · **P0128 - Thermostat Rationality Improvements.** · P2281 - Air Leak Between MAF and Throttle Body. · P218F - Reductant No Flow Detected. · P0218 - Transmission High Temperature Operation Activated (68RFE Only). · P0868 - Line Pressure Low, MIL Action (68RFE Only). · U110E - Lost Ambient Temperature Message. · P205E - (Diesel Exhaust Fluid) Reductant Tank Temperature Sensor Circuit Intermittent (setting when the block heater is plugged in). In addition to addressing the above DTCs, the following powertrain system improvements/enhancements are also included in this software release: · **Engine Noise Improvements. · Engine Hesitation Improvement. · Improved Engine Fuel Economy.** · Reduction in engine noise during regeneration at idle. · 68RFE Transmission Overall Shift Quality Improvements. · Test results fix for partial range misfire (68RFE Only). · Ambient Air Temperature Improvements. · Stationary Desoot with wiTECH Fix. · OBD Misfire Monitoring Improvement (68RFE Only). |
| 1801517 | 2022-10-31. Service bulletin. Flash: 6.7L Diagnostic and System Improvements This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. The following Diagnostic Trouble Codes (DTCs) have been changed from a one trip fault to a two trip fault:P0421 - Catalyst 1 Efficiency Below Threshold Bank 1. P2280 - Air Flow Restriction / Leak Between Air Cleaner And MAF. P203C - (Diesel Exhaust Fluid) Reductant Level Sensor Circuit Low. P208D - (Diesel Exhaust Fluid) Reductant Pump Control Circuit High. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation a technician may find the following DTCs set in the PCM memory:P218F - Reductant No Flow Detected. P202E - (Diesel Exhaust Fluid) Reductant Injector Performance. U0001-00 - CAN C BUS. P24A5 - EGR Cooler Bypass Bank 1 Control Stuck. P1451 - Diesel Particulate Filter System Performance. P229E - NOx Sensor Circuit - Bank 1 Sensor 2. P0128 - Thermostat Rationality Improvements. P2281 - Air Leak Between MAF and Throttle Body. P0218 - Transmission High Temperature Operation Activated (68RFE Only). P0868 - Line Pressure Low, MIL Action (68RFE Only). U110E - Lost Ambient Temperature Message. P205E - (Diesel Exhaust Fluid) Reductant Tank Temperature Sensor Circuit Intermittent (setting when the block heater is plugged in). In addition to addressing the above DTCs, the following powertrain system improvements/enhancements are also included in this software release:Fuel pressure override test improvement for wiTECH. AC pressure sensor error threshold change. No crank, No start fix. Improvement to correct engine feels like low or reduced power. Engine Noise Improvements Improved Engine Fuel Economy. Reduction in engine noise during regeneration at idle. 68RFE Transmission Overall Shift Quality Improvements. Test results fix for partial range misfire (68RFE Only). Ambient Air Temperature Improvemen |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.