WenmarOpen by Wenmar Pro

Recalls that may apply to the 2005 Volvo XC90

A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.

By component

United States: NHTSA, as of 2026-10-19
10V5660002010-11-08. EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM). VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
09V4830002009-12-18. FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP. VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE. Built 2002-08-07 to 2004-06-11.
07V2210002007-05-25. ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES. ON CERTAIN PASSENGER VEHICLES, IT HAS BEEN DETERMINED THAT WHILE DOING BATTERY MAINTENANCE THE JACK'S CRANK HANDLE CAN BE MISPLACED UNDER A BRACKET WHICH RETAINS THE BATTERY. Built 2004-06-07 to 2005-05-13.
06V1550002006-05-05. STEERING:LINKAGES:TIE ROD ASSEMBLY. ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT. Built 2004-06-07 to 2005-05-13.
06V1440002006-04-28. VISIBILITY:WINDSHIELD WIPER/WASHER. ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION. Built 2004-02-17 to 2005-05-13.
05V5290002005-11-17. ELECTRICAL SYSTEM:STARTER ASSEMBLY:SOLENOID. ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, DUE TO AN ERROR IN THE FACTORY ASSEMBLY INSTRUCTION, THE B+TERMINAL MAY BE IN CONFLICT WITH THE STARTER MOTOR SOLENOID. IF THIS OCCURS, THE CONFLICT BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID MAY DEVELOP INTO A SHORT CIRCUIT OF THE BATTERY CABLE TO GROUND. Built 2004-06-17 to 2005-06-02.
Canada: Transport Canada, as of 2026-10-19
20103962010-11-08. Accessories. On certain vehicles, there is a possibility of overheating issues of batteries in the Garmin nüvi® 760 when certain batteries manufactured within a limited date code range are used in certain Garmin nüvi® 760 models with a specific printed circuit board (PCB) design. The interaction of these factors can, in some circumstances, increase the possibility of overheating, which may lead to a fire. Correction: Dealers will direct customers who have an affected unit to the Garmin Web site, which explains how to verify if their units are involved and includes procedures to follow for product exchange.
20061082006-05-08. Steering. On certain vehicles, deformation at high loads may cause loss of clamping force of the outer tie rod and allow the nut to loosen. This may eventually lead to a fatigue fracture of the outer tie rod assembly. Tie rod separation could lead to a loss of steering control which could result in a vehicle crash. Correction: Dealers will replace outer tie rods with updated versions.
20060932006-04-26. Visual System. On certain vehicles the windshield wiper pivot splines may be damaged due to failure to remove snow from the windshield. This would result in a loss of wiper operation and resultant detriment to vision. Correction: Dealers will replace wiper arms and retaining nuts.
20060662006-03-27. Seats And Restraints. Certain Volvo 850, S40, V40, V50, V70, XC70 and XC90 equipped with integrated child booster cushions were incorrectly labelled during vehicle assembly. The label indicates that the booster cushion can be used for children weighing between 15 and 36 kg (33 and 80 lb). CMVSS 213 states that the minimum weight for use must be 18 kg (40 lb). Should an underweight child be placed in the booster cushion and the vehicle is involved in a crash, the child may have a greater risk of injury. Correction: Volvo Canada will send a letter to owners explaining this problem and will supply updated weight limit decal to be applied to each side window.
20053652005-11-17. Electrical. On certain vehicles, the positive battery cable may wear against the starter solenoid. The resulting chafe damage could develop into an electrical short. This can be noticed in different ways. If the vehicle is parked, smoke may appear from under the hood and/or it may be impossible to start the car. If the short circuit happens during driving, not only will the engine stall, but the electrical power could also be lost, resulting in warning lamps being deactivated. Correction: Dealers will relocate the battery cable.

A campaign lists a year, a make and a model, and often only some of the vehicles built. A list with nothing on it is not a clearance either. The lookups below check one VIN.

Check one vehicle officially

Contains information licensed under the Open Government Licence – Canada.