Service bulletins for the 2011 Volkswagen Touareg
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
894 on file from NHTSA, as of 2026-10-19.
By type
By component
By trouble code
By topic
Only bulletins with component: Electrical system are shown. Show all
| TT 57-10-11 | 2017-12-05. Service bulletin. ELECTRICAL SYSTEM. Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs If a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched OFF. This can be accomplished by selecting the test plan through GFF or through Vehicle Self Diagnosis in adaptation channel 99. Failure to deactivate factory mode will create a concern where the door locks will not lock and/or unlock with the switch and/or the remotes. |
|---|---|
| V911406 2031434 | 2017-12-05. Service bulletin. EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.; ELECTRICAL SYSTEM:SOFTWARE. Technical Bulletin (Radio Software issues): Customer may report one of the following concerns: * HD Radio does not play back in stereo (plays in mono) * Intermittent erratic display problems * Displayed radio station does not match the station being played The product solution for this issue was improved software This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available. |
| TT 24-13-03 | 2017-12-05. Service bulletin. ELECTRICAL SYSTEM. Tech Tips (Engine Control Module Fault P130A ?Hide Cylinder?): This document informs that DTC P130A ?Hide Cylinder? indicates that excessive misfiring has occurred. As a result, the ECM has turned off a fuel injector to prevent catalyst damage. To address this fault, diagnose and repair all misfire concerns that are present. Repairing the other faults will resolve the P130A. |
| TT 57-12-10 | 2017-12-05. Service bulletin. ELECTRICAL SYSTEM. Tech Tips (Touareg Key Adaptation): When adapting keys on a 2011-2014 Touareg, it is necessary to complete the ?Adapt Immobilizer? test plan under 05 access start module. This document informs on the procedure to the ?Adapt Immobilizer? test plan |
| TT 90-13-02 | 2017-12-05. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Tech Tips (Resetting Inspection Service and Interval Service): This document references a difference between The procedure for resetting the "Reset Inspection Service" which is different from "Reset Interval Service". It provides a graphic on where to select, and diagnose these issues |
| TT 91-14-02 | 2017-12-05. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Tech Tips (MDI Functions with iPhone 5 Variants (5, 5c, 5s and iPad fourth generation, iPod Nano seventh generation)): The Apple iPhone 5, iPhone 5c, and iPhone 5s, as well as the iPad 4th generation and iPod Nano 7th generation use a proprietary ?Lightning? connector that is different than the 30-pin dock connector found on previous iPhone and iPad/iPod models. A new MDI cable (?MDI Adapter Cable ? Lightning Charger?) is now available through the VW Accessories eCatalog that is made for use with iPhone 5 variants as well as the previously mentioned iPad/iPod models. This cable should provide full functionality on any vehicle equipped with a UMI (Unified Multimedia Interface). On MY 13 and older vehicles equipped with an MDI, the software level of the MDI must be at or above SW 240 (see Technical Bulletin 2024337) in order to be fully functional. |
| TT 91-14-03 | 2017-12-05. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Tech Tips (Vehicles equipped with Premium (RCD 510) Radios ? Coding Information for Replacing ?AC? Suffix Radios with ?AF? Suffix Replacement Unit): When replacing the radio on a 2010 ? 2011 vehicle equipped with a Premium 8 (RCD 510) radio with part number ending in the suffix ?AC? (1K0 035 180 AC), if the replacement part has a suffix ?AF?, make sure that online coding is performed. DO NOT PERFORM ANY SOFTWARE UPDATE OF THE ?AF? RADIO USING AN SD CARD OR ANY OTHER MEANS. No software updates are available for ?AF? suffix radios. Any attempt to update the software using an SD card or other means can result in permanent damage to the radio. |
| Reference - Refl | 2017-12-05. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle |
| V011407 2014603 | 2017-12-05. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU). |
| V601401 2019568 | 2017-12-05. Service bulletin. STRUCTURE; ELECTRICAL SYSTEM. Technical Bulletin (Sunroof / Sunshade, Will Not Open): The panoramic sunroof, regular sunroof or sunshade cannot be opened. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available. |
| TT911101 | 2017-11-12. Service bulletin. ELECTRICAL SYSTEM. Update to existing Tech Tip 91-11-01 for later model years, to direct technicians to the bluetooth compatibility chart. |
| TT 66-11-01 | 2017-11-08. Service bulletin. TRAILER HITCHES; ELECTRICAL SYSTEM. Tech Tips: Touareg with Trailer Hitch ? J345 Trailer Recognition Control Module and/or Trailer Brake Controller Installation |
| TT 90-11-10 | 2017-11-08. Service bulletin. ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL. Tech Tips (Instrument Cluster Production Mode): This document informs the procedure to remove the production mode setting when it is displayed in the instrument cluster. |
| V011518 2023591 | 2017-11-08. Service bulletin. FUEL SYSTEM, DIESEL; ELECTRICAL SYSTEM. Technical Bulletin (TDI Clean Diesel I/M (Inspection Maintenance) Testing Issues due to Readiness Not Set): A Volkswagen TDI clean diesel is not ready for I/M (Inspection Maintenance) testing due to readiness codes not being fully set. Some readiness codes on TDI clean diesel vehicles require special driving conditions to be set. This document contains how to read the OBD readiness codes to diagnosis the status of the car, and gives examples on what is necessary to have the car up to spec |
| V201503 2031426 | 2017-11-08. Service bulletin. ELECTRICAL SYSTEM; ENGINE; FUEL SYSTEM, GASOLINE. Technical Bulletin: High Pressure Fuel Pump Diagnosis. Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. This document contains the procedure to update the programming on the diagnostic hardware. This document contains the fault codes necessary to check the warranty coverage for servicing this issue. |
| V261505 2041110 | 2017-11-08. Service bulletin. ELECTRICAL SYSTEM. Technical Bulletin (Selective Catalyst Reduction (SCR) heater electronics being ) contaminated with Ad Blue): This document informs what repairs are needed to fix the issue. This document contains the fault codes necessary to check the warranty coverage for servicing this issue. |
| V231502 2041057 | 2017-11-08. Service bulletin. FUEL SYSTEM, DIESEL; ELECTRICAL SYSTEM. Technical Bulletin (No Start, or Rough Running issues): When diagnosing the condition(No Start, or Rough Running) on a common rail diesel vehicle, if no root cause is found after checking all other components and all GFF diagnostic procedures have been performed, it may be necessary to check for metallic particles in the High Pressure Fuel Pump using the service section of this document. |
| TT 57-12-10 | 2017-11-08. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. Tech Tips: When adapting keys on a Touareg, it is necessary to complete the ?Adapt Immobilizer? test |
| TT 64-14-02 | 2017-11-08. Service bulletin. VISIBILITY:POWER WINDOW DEVICES AND CONTROLS; VISIBILITY:GLASS, SIDE/REAR; ELECTRICAL SYSTEM. Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage. |
| V011511 2040202 | 2017-11-08. Service bulletin. ELECTRICAL SYSTEM. Technical Bulletin: Under certain driving conditions, the secondary air ports in the cylinder head can accumulate carbon over time causing restrictions. This document contains information on servicing the issues, and fault codes for diagnosing. The document also contains Road test time units in warranty tables |
| V201502 2031426 | 2017-11-08. Service bulletin. FUEL SYSTEM, GASOLINE; ELECTRICAL SYSTEM; ENGINE. Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements |
| TT 00-14-03 | 2017-11-08. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Tech Tips (SVM Update Instructions): This document informs when performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. |
| V481406 2038140 | 2017-11-08. Service bulletin. ELECTRICAL SYSTEM; STEERING; SERVICE BRAKES, HYDRAULIC. Technical Bulletin (Vibrations in Steering Wheel): After a short stationary period (sometimes as little as a few hours) flat spots can develop after the warm tire has cooled down. The effect the flat spotted tire has on the vehicles performance depends on the type, dimension, make, and pressure of the tire. This document informs how to identifiy Flat spots that alter the radial force variation and must be driven out before balancing the wheel. |
| V011528 2033805 | 2017-11-08. Service bulletin. ELECTRICAL SYSTEM. Technical Bulletin (Engine, Misfire Diagnostic Aid): This document informs that Multiple components SHOULD NOT be replaced for 1 misfiring cylinder. Repeat repairs must be carefully addressed to identify the root cause of the concern. If misfires are determined to be related to a specific component(s) (fuel injector, spark plug, ignition coil), replace only one defective component at a time and re-evaluate the concern |
| V191401 2022549 | 2017-10-31. Service bulletin. ELECTRICAL SYSTEM; ENGINE AND ENGINE COOLING. Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This documentation informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition is switched off in gasoline engine applications, and up to 16 minutes in diesel engine applications. The production solution to service this issue is that no production change is required. |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.