Service bulletins for the 2009 Volkswagen Routan
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
356 on file from NHTSA, as of 2026-10-19.
By type
By component
By trouble code
By topic
| TB-58-10-02 | 2011-02-09. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE; STRUCTURE:BODY:DOOR. VOLKSWAGEN: POWER SLIDING DOORS INOPERATIVE. DTC B2271 OR B2272 STORED IN FAULT MEMORY. THE POWER SLIDING DOORS WILL NOT OPEN FROM ANY OF THE SWITCHES. THE DOORS WILL WORK IN THE MANUAL MODE. THERE MAY BE DIAGNOSTIC TROUBLE CODES (DTC) STORED. THIS INVOLVES FLASH REPROGRAMMING THE POWER SLIDING DOOR MODULE REAR LEFT AND/OR RIGHT (PSDML/PSDMR) WITH NEW SOFTWARE. *PE |
|---|---|
| TB-58-09-03 | 2010-07-26. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE; STRUCTURE:BODY:DOOR. VOLKSWAGEN: UPDATE PROGRAMMING, POWER SLIDING DOOR MODULE-OVERLY SENSITIVE OBSTRUCTION DETECTION. VEHICLE MAY EXPERIENCE THE POWER SLIDING DOOR INTERMITTENTLY NOT FULLY CLOSING WHEN ACTIVATED WITH EITHER THE KEY FOB OR SWITCHES LOCATED IN THE VEHICLE. THE POWER SLIDING DOOR WILL BEGIN THE CLOSING PROCESS, BUT THEN REVERSE AT NEARLY THE CLOSING POINT, WITHOUT ANY OBVIOUS OBSTRUCTION. *PE |
| TB-97-09-03 | 2010-03-29. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. VOLKSWAGEN: SPEED SENSOR WIRE RETENTION (US ONLY). VEHICLES PRODUCED WITH THE 62TE TRANSMISSION (SALES CODE DG2) WERE SHIPPED WITH THE SPEED SENSOR WIRE THAT COULD CATCH ON THE CV BOOT CLAMP. IMPROVED WIRING HARNESS INSTALLATION BEGINNING WITH MODEL YEAR 2010 PRODUCTION. *PE |
| TB-07-09-03 | 2010-03-17. Service bulletin. VEHICLE SPEED CONTROL; POWER TRAIN:AUTOMATIC TRANSMISSION. VOLKSWAGEN: SECURE VEHICLE SPEED SENSOR WIRE (US ONLY). VEHICLES PRODUCED WITH THE 62TE TRANSMISSION, (SALES CODE DG2) WERE SHIPPED WITH THE SPEED SENSOR WIRE THAT COULD CATCH ON THE CV BOOT CLAMP. IMPROVED WIRING HARNESS INSTALLATION BEGINNING WITH MODEL YEAR 2010 PRODUCTION. *PE |
| TB-17D3-Y3 | 2009-09-29. Service bulletin. ENGINE AND ENGINE COOLING:COOLING SYSTEM. VOLKSWAGEN: INSPECT ENGINE OIL COOLER FOR DAMAGE AND REPLACE IF NECESSARY. *PE |
| SB-10C9-S1 | 2009-09-25. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV). VOLKSWAGEN: PCV VALVE INSPECTION OR REPLACEMENT. A SMALL NUMBER OF AFFECTED VEHICLES MAY HAVE BEEN BUILT WITH AN INCORRECT PCV VALVE. THIS CAN CAUSE SOME VEHICLES TO EXCEED FEDERAL AND/OR CALIFORNIA EMISSIONS STANDARDS AND MAY CAUSE THE VEHICLE TO FAIL AN EMISSION INSPECTION OR I/M SMOG CHECK TEST. *PE |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.