WenmarOpen by Wenmar Pro

Service bulletins for the 2002 Volkswagen Passat

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

234 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Only bulletins with component: Electrical system are shown. Show all

Bulletins, newest first
Edition862023-10-02. Service bulletin. ELECTRICAL SYSTEM; VISIBILITY:WINDSHIELD WIPER/WASHER; EXTERIOR LIGHTING:HEADLIGHTS. VW Elsa Newsletter
Edition1172023-10-02. Service bulletin. EXTERIOR LIGHTING; VISIBILITY:POWER WINDOW DEVICES AND CONTROLS; ELECTRICAL SYSTEM; STRUCTURE. VW Elsa Newsletter
Edition1162023-10-02. Service bulletin. ENGINE AND ENGINE COOLING; SEATS; VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM; ELECTRICAL SYSTEM; STRUCTURE. VW Elsa Newsletter
Edition1152023-10-02. Service bulletin. STRUCTURE; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); ELECTRICAL SYSTEM; VISIBILITY:POWER WINDOW DEVICES AND CONTROLS; ENGINE AND ENGINE COOLING. VW Elsa Newsletter
Edition262023-09-18. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT; FUEL SYSTEM, GASOLINE; STRUCTURE. VW Elsa Newsletter
Edition862023-09-18. Service bulletin. EXTERIOR LIGHTING; EQUIPMENT; ELECTRICAL SYSTEM; VISIBILITY:WINDSHIELD WIPER/WASHER. VW Elsa Newsletter
TB0114072023-08-28. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE; UNKNOWN OR OTHER. Software Version Management
Guide2023-08-14. Service bulletin. UNKNOWN OR OTHER; ELECTRICAL SYSTEM:SOFTWARE; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM). P0102, P1128, P1296 - WA front oxygen sensor faults
TT6414022023-07-31. Service bulletin. VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT; ELECTRICAL SYSTEM:IGNITION:SWITCH; UNKNOWN OR OTHER; ELECTRICAL SYSTEM. To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage. Proceed with checking any other lines as necessary. Once the damaged line is identified, repair utilizing the Repair kit by Permatex® ITEM 09117.
TT5713022023-07-17. Service bulletin. ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER. If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism. If roll pin is sticking out on either side (as shown below), do not replace key. Instead, use appropriate sized punch and hammer to drive in the roll pin so that it is flush with edge of mechanism.
TT4513012023-07-10. Service bulletin. WHEELS; SERVICE BRAKES, AIR:ANTILOCK:CONTROL UNIT/MODULE; BACK OVER PREVENTION; ELECTRICAL SYSTEM; STEERING; STEERING:STEERING WHEEL /HANDLE BAR:YAW/ANGLE SENSOR. After replacing a Bosch 5.7 ABS module, refer to the table below to determine correct module coding value based on vehicle PR codes. Listed login code must be entered under Access/authorization before coding is attempted. After completing coding, G85 steering angle sensor basic settings must be performed before cycling key. To perform G85 basic settings manually in Vehicle self-diagnosis (VAS PC) or Control Module OBD (ODIS), start by entering access/authorization code 40168. After code is accepted, turn steering wheel 1 turn left and back to center, one turn right, and then center steering wheel. Select basic settings and enter group 1. Once display changes to ?Sensor OK? or ?Calibration OK?, basic settings have been completed. Cycle key OFF and then back ON. Clear faults to verify repair.
TT0014032023-07-10. Service bulletin. EQUIPMENT; EQUIPMENT:ELECTRICAL:INFOTAINMENT:BLUETOOTH/WIFI; ELECTRICAL SYSTEM. When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended.
TT9714022023-06-13. Service bulletin. ELECTRICAL SYSTEM. The DLC is intended for use with diagnostic scan tools and by emissions testing stations. However, aftermarket devices (i.e., drive data recorders) that connect to the DLC have now become available.
TT8710052023-06-13. Service bulletin. SERVICE BRAKES, HYDRAULIC; ELECTRICAL SYSTEM. For concerns of no or intermittent A/C operation where pressure diagnosis does not lead to a cause, be sure to check the N25 A/C clutch coil. The fan control module may send a brief voltage signal to the clutch and then shut it off due to an open or high resistance in the coil circuit. The coil resistance should be between 3.5 and 4.5 ohms. If the reading is high or low when checked at the fan module, be sure to double check right at the coil to rule out any wiring concerns. Additionally, check ground circuit integrity for the clutch coil.
V2719012011894222023-01-06. Service bulletin. ELECTRICAL SYSTEM. Battery testing and charging using special tools VAS6161 & GRX3000VAS Charger. Updated to include additional model year applicability.
561065760A2022-09-26. Service bulletin. ELECTRICAL SYSTEM:STARTER ASSEMBLY. Installation of original remote start feature accessory
A0021552011732122022-01-05. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. This bulletin contains general instructions for software updates.
V011812_20146032019-08-07. Service bulletin. ELECTRICAL SYSTEM. Update vehicle metadata to include pull ahead models. Also includes R32 2002-2007 and 2002-2006 Jetta Wagon.
TT 91 19 012019-04-22. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. Alternative method for radio code retrieval.
V271901-20118942019-04-15. Service bulletin. ELECTRICAL SYSTEM. Battery Testing and Charging instruction. Updated to include model year 2019 applicability.
TT 9610112019-04-08. Service bulletin. ELECTRICAL SYSTEM. Update to model year applicability.
TT 2710022019-04-08. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY. Updated to include model year 2014 thru 2018 applicability.
TT 90-12-062019-04-08. Service bulletin. ELECTRICAL SYSTEM; FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM. Tech Tips (Fuel Gauge Inoperative after Instrument Cluster Replacement with Fault 00771 ?Fuel level sensor -G-?): An inoperative fuel gauge after instrument cluster replacement with fault 00771 ?Fuel level sensor -G-? may be caused by gateway (address word 19) coding. This document informs of the procedure to resolve this concern
Control Module R2019-04-08. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle
TT 45-06-542019-04-01. Service bulletin. ELECTRICAL SYSTEM; SERVICE BRAKES, AIR:ANTILOCK. Tech Tips (Bosch 5.3 ABS Control Module ? ABS Coding Tables): This document informs To code a Bosch 5.3 ABS control module, use Vehicle Self-diagnosis to enter the correct coding value from the tables in this document.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.