Service bulletins for the 2009 Volkswagen Jetta
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
1057 on file from NHTSA, as of 2026-10-19.
By type
By component
By trouble code
By topic
| Campaign Circula | 2017-12-05. Service bulletin. ELECTRICAL SYSTEM. Service Action: The F16 position fuse could fail prematurely due to possible degradation of the fuse?s coating material. If this happens, it could cause a partial loss (but not a complete failure) of vehicle lighting, including the loss of DRL illumination on one side of the vehicle, which in turn could render the vehicle less visible to other motorists and pedestrians during daylight hours. The corrective action taken was to Replace the existing F16 position fuse with a new, optimized hard-coated fuse. This document informs how to install the new fuse and how to make a claim for the work provided |
|---|---|
| TT 48-10-04 | 2017-12-05. Service bulletin. ELECTRICAL SYSTEM:WIRING. Tech Tips (with 1K0 Part Number J500 ? Replacement Steering Harness): If the steering rack is replaced on the above models for any reason, it is necessary to replace the steering harness as well. The new harness may be equipped with an extra connector. If all connections are made correctly, then it is necessary to remove that connector and tape the exposed wires back into the harness. Be sure to tape tightly in order to provide a water-tight repair. |
| Reference - Refl | 2017-12-05. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle |
| V001404 2010380 | 2017-12-05. Service bulletin. EQUIPMENT. Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions. |
| V011411 2034898 | 2017-12-05. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. Technical Bulletin (Exhaust Gas Recirculation Flow, Could be accompanied with Soot Accumulation): High soot loads prior to regeneration can cause possible restrictions in the EGR filter. The production solution for this issue is New software implemented in current production. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available. |
| V211403 2026771 | 2017-12-05. Service bulletin. ELECTRICAL SYSTEM. Technical Bulletin (Engine Lacks Performance, Engine Warning Light ON): Engine does not have any power and the engine warning light may be ON. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available. |
| V261402 2018962 | 2017-12-05. Service bulletin. ELECTRICAL SYSTEM:IGNITION; ELECTRICAL SYSTEM. Technical Bulletin (TDI Common Rail High Pitch Whine Noise after Switching Ignition OFF): With the implementation of the new ?Clean Diesel Technology?, changes to the EGR system were implemented as compared to previous Diesel engines. After switching ignition OFF, the EGR system must go through an adaption of the valves to maintain calibration. These noises are considered normal and no repairs are necessary. |
| V871402 2005566 | 2017-12-05. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. Technical Bulletin (HVAC, Unpleasant Odor): Condensation, which is a normal condition in all A/C systems, can cause a musty odor. If the odor is noticeable in the vehicle when the engine is not turned on, the cause may be mold and mildew in the passenger compartment, and not be related to the A/C system. All other possible sources of the odor must be investigated before this document can be performed. This document contains the procedure for the VW method to remove musty odors |
| V971401 2036976 | 2017-12-05. Service bulletin. ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS. Technical Bulletin (Under Hood Fuse Panel (SA/SB assembly) with part Supplied Without Power Distribution Bar): The supplied under hood fuse panel (SA/SB assembly) with part number 000 937 125 comes without the power distribution bar (SA panel). When replacing an under hood fuse panel, the technician must remove the power distribution bar from the original under hood fuse panel and install it on the new assembly. This document provides the procedure to service this issue |
| V011407 2014603 | 2017-12-05. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU). |
| V011408 2014815 | 2017-12-05. Service bulletin. ENGINE. Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of deposits on intake valves, intake manifold, fuel injectors and combustion chambers. -Engine runs rough after cold start. -Excessive engine cranking time. -Stumbles while driving. -Rough engine idle. -Loss of engine performance. -Poor fuel economy. This document informs of the procedure for the vehicle if it is diagnoised with poor quality gas |
| V151402 2032150 | 2017-12-05. Service bulletin. ENGINE. Technical Bulletin (Proper Removal of Engine Cover to Avoid Breakage): Pulling on the engine cover in some areas can cause damage. This document informs on the procedure to remove the engine cover. |
| V231402 2036656 | 2017-12-05. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER. Technical Bulletin (No Start, or Rough Running issues): When diagnosing a MIL ON, no-start or rough running concern on a common rail diesel vehicle, and no root cause is found after following all GFF diagnostic procedures, it may be necessary to check for metallic particles in the High Pressure Fuel Pump. If such an inspection is necessary, the guidelines in this document must be observed when removing the N290 Fuel Metering Valve |
| V231403 2036656 | 2017-12-05. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER. Technical Bulletin (No Start, or Rough Running due to Fuel Rail issues): When diagnosing the condition above on a common rail diesel vehicle, if no root cause is found after checking all other components and all GFF diagnostic procedures have been performed, it may be necessary to check for metallic particles in the High Pressure Fuel Pump using the service section of this document. If such an inspection is necessary, the following guidelines must be observed when removing the N290 Fuel Metering Valve. |
| V871401 2005566 | 2017-12-05. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Condensation is a normal characteristic in all A/C systems. If odor is noticeable continue to follow this document. Contaminants are effectively neutralized using the AIRCOMATIC? II Ultrasonic Climate System Cleaner (VAS 6189A) or AIRCOMATIC? III Ultrasonic Climate System Cleaner (VAS 6189B) and AIRCO-CLEAN? Ultrasonic HVAC Treatment (30208). All other cleaning methods are no longer permitted. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available. |
| V941402 2011521 | 2017-12-05. Service bulletin. EXTERIOR LIGHTING:HEADLIGHTS. Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic changes. This document discusses necessary to diagnosis, and potential remedy of the issue. |
| V871618_2043704 | 2017-11-14. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. Updated to include additional model year and required documentation instruction. |
| V011705 2018652 | 2017-11-12. Service bulletin. EQUIPMENT ADAPTIVE/MOBILITY. Update parts table. |
| V011708 2028037 | 2017-11-12. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. To update software version management (SVM) reflasg code. |
| V131701-2046780 | 2017-11-12. Service bulletin. EQUIPMENT ADAPTIVE/MOBILITY. Idler roller for ribbed bely now available as a parts kit. |
| V201701 2031426 | 2017-11-12. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. Update Parts Table. |
| V241703 2045138 | 2017-11-12. Service bulletin. ENGINE AND ENGINE COOLING. Remove engine coolant from parts table. |
| V231505 2041063 | 2017-11-08. Service bulletin. FUEL SYSTEM, DIESEL. Technical Bulletin (Fuel Rail/System Pressure, and Pressure Sensor issues): When diagnosing the Fuel Rail/System Pressure, and Pressure Sensor issue condition on a common rail diesel vehicle, if no root cause is found after checking all other components and all GFF diagnostic procedures have been performed, it may be necessary to check for metallic particles in the High Pressure Fuel Pump. This document contains the method to diagnose, and to service this issue |
| TT 90-11-10 | 2017-11-08. Service bulletin. ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL. Tech Tips (Instrument Cluster Production Mode): This document informs the procedure to remove the production mode setting when it is displayed in the instrument cluster. |
| V011518 2023591 | 2017-11-08. Service bulletin. FUEL SYSTEM, DIESEL; ELECTRICAL SYSTEM. Technical Bulletin (TDI Clean Diesel I/M (Inspection Maintenance) Testing Issues due to Readiness Not Set): A Volkswagen TDI clean diesel is not ready for I/M (Inspection Maintenance) testing due to readiness codes not being fully set. Some readiness codes on TDI clean diesel vehicles require special driving conditions to be set. This document contains how to read the OBD readiness codes to diagnosis the status of the car, and gives examples on what is necessary to have the car up to spec |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.