Service bulletin TT 48-10-04
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10124372 |
| Published by NHTSA | 2017-12-05 |
| Manufacturer's number | TT 48-10-04 |
| Manufacturer's date | 2010-05-28 |
| NHTSA component | ELECTRICAL SYSTEM:WIRING |
NHTSA's summary
Tech Tips (with 1K0 Part Number J500 ? Replacement Steering Harness): If the steering rack is replaced on the above models for any reason, it is necessary to replace the steering harness as well. The new harness may be equipped with an extra connector. If all connections are made correctly, then it is necessary to remove that connector and tape the exposed wires back into the harness. Be sure to tape tightly in order to provide a water-tight repair.
The document
The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.
Components
Electrical system, Wiring and fuses
| VOLKSWAGEN EOS | 2007, 2008, 2009 |
|---|---|
| VOLKSWAGEN GTI | 2006, 2007, 2008, 2009 |
| VOLKSWAGEN JETTA | 2005, 2006, 2007, 2008, 2009 |
| VOLKSWAGEN PASSAT | 2009 |
| VOLKSWAGEN RABBIT | 2007, 2008, 2009 |
| VOLKSWAGEN TIGUAN | 2009 |
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 13V569000 | 2013-11-22. EXTERIOR LIGHTING; ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS |
|---|
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| Edition65 | 2023-10-16. Service bulletin. Volkswagen Elsa Newsletter |
|---|---|
| 97AM | 2023-08-14. Service bulletin. 2009 - 2010 My Jetta Sedan and 2009 My Jetta Sedan and 2009 My GTI Fuse (Plug-in Position F16) |
| TT611204 | 2023-07-31. Service bulletin. When diagnosing a customer concern of convertible top inoperative with faults 03053-008 ?Left Roof Pillar Lock Sensor G558 implausible signal?, 03055-008 ?Rear Window Frame Left Lock Sensor G560 implausible signal?, and/or 03057-008 ?Rear Window Frame Opening Sensor G562 implausible signal? stored in convertible top, start by inspecting M35 splice in convertible top harness. Splice is located near left rear convertible top drain, as shown below. |
| TT911302 | 2023-06-13. Service bulletin. The Apple iPhone 5, iPad fourth generation, and iPod nano seventh generation use a proprietary ?Lightning? connector that is different than the 30 pin dock connector found on previous iPhone and iPod models. |
| TT 55-13-01 | 2017-12-14. Service bulletin. Tech Tips (Rear Lid Does Not Open After Handle Replacement): If the rear lid handle is replaced with part number 1J0 827 566L, the microswitch from the original handle must be transferred to the new handle. If original microswitch is not available, microswitch part number 1J5 962 104 B should be ordered and installed. |
| VWP-14-06 | 2017-12-05. Service bulletin. Warranty Information (Driver's Door Wiring Harness Limited Warranty Extension for MY 2005 or 2006 (A5) Jetta Vehicles): This document informs of extended warranty options available for Jetta vehicles. It informs how to make a claim on service rendered for the extended warranty, and how to determine which vehicles are eligible |
| V971401 2036976 | 2017-12-05. Service bulletin. Technical Bulletin (Under Hood Fuse Panel (SA/SB assembly) with part Supplied Without Power Distribution Bar): The supplied under hood fuse panel (SA/SB assembly) with part number 000 937 125 comes without the power distribution bar (SA panel). When replacing an under hood fuse panel, the technician must remove the power distribution bar from the original under hood fuse panel and install it on the new assembly. This document provides the procedure to service this issue |
| V241504 2038161 | 2017-11-08. Service bulletin. Technical Bulletin: This document has the fault codes to trouble shoot Intake Manifold Faults. It also contains the claim codes for warranty coverage |
| V011612_2018652 | 2017-06-15. Service bulletin. 2006-2008 WITH 2.0L (BPY) UPDATE SERVICE NUMBER IN WARRANTY TABLE. 2008-2009 ALL MODELS WITH 2.0L (CCTA,CBFA) UPDATE SERVICE NUMBER IN WARRANTY TABLE. |
| SA-97-AM | 2014-11-19. Service bulletin. VOLKSWAGEN: DUE TO POSSIBLE PREMATURE FAILURE OF F16 FUSE POSITION CAUSED BY DEGRADATION OF COATING MATERIAL, A PARTIAL LOSS OF LIGHTING WILL RENDER VEHICLE LESS VISIBLE, DURING DAYLIGHT HOURS. MODEL 2009-2010 JETTA SEDAN, 2009 GTI. *PE |