WenmarOpen by Wenmar Pro

Service bulletins for the 2010 Volkswagen Jetta SportWagen

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

921 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

By topic

Only bulletins with component: Exhaust and emissions are shown. Show all

Bulletins, newest first
VWP13132024-04-22. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL. Secondary Air Pressure Sensor Limited Warranty Extension
VWP13052024-04-22. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. Engine Exhaust Flap Limited Warranty Extension
2113022023-10-16. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. Rattling Noises from Engine Compartment Area or Exhaust System
TB0113302023-08-28. Service bulletin. FUEL SYSTEM, GASOLINE; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. MIL ON, DTC P0401 Exhaust Gas Recirculation Flow Insufficient Stored in ECM Fault Memory, Could be Accompanied with Fault P2463 DPF Soot Accumulation
2013062023-07-17. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. Activated Charcoal Filter System, Solenoid Valve 1 -N80- (Canister Purge Valve) Diagnosis
20348982022-06-13. Service bulletin. UNKNOWN OR OTHER; ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE). High soot loads prior to regeneration can cause possible restrictions in the EGR filter.
V0118132034898222022-06-07. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. High soot loads prior to regeneration can cause possible restrictions in the Exhaust Gas Recirculation (EGR) filter. Update to MAF labor operation number.
V0118132034898212022-06-07. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. High soot loads prior to regeneration can cause possible restrictions in the Exhaust Gas Recirculation (EGR) filter.
V0118132034898192021-11-05. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. Diagnosis for EGR flow insufficient. Update to parts table.
V0118132034898182021-07-02. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE). DTC P0401 diagnostic assistance, additional smoke test and cold air control valve test
V0118132034898172021-07-02. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE); ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. DTC P0401 diagnostic assistance, additional smoke test and cold air control valve test
V011813_20348982020-11-05. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE). Update to part quantity in Part Table.
TT 01-19-072019-12-06. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. Nox regeneration information. Updated to correct the tech tip number in the title.
TT 01-19-07_ver22019-12-06. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. Catalytic Converter Regeneration Scan Tool instruction.
V261902_20284152019-05-06. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM; ENGINE AND ENGINE COOLING. Update to labor operation numbers per Saga updates. Also applies to the 2006-2007 Beetle Convertible.
V241705 20473632019-04-15. Service bulletin. FUEL SYSTEM, GASOLINE; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE. Installation Instruction for fresh air line during CCTA Intake Manifold Replacement
V241704 20451382019-04-15. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE. Supersedes Technical Bulletin 24-17 03 (V241703) dated March 6, 2017 for information regarding a new style solenoid valve for Intake Manifold Flap
V241704 20451382019-04-15. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE. Ensure correct intake manifold is installed on engine, refer to ETKA.
VSS-17-122019-04-08. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL; EQUIPMENT. Volkswagen of America is requesting your cooperation in supplying us with technical information related to the repair process for vehicles on which the TDI Generation I, II, and III 2.0L emissions modification is being performed ?Campaigns 23U3?. Volkswagen will use this information to ensure prompt analysis and resolution of any emerging concerns.
23U3 rev 09012012019-04-08. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL. 2.0L TDI Engine (GEN 1) Emissions Modification ? Customer Only (Retail Sold) USA ONLY - The Environmental Protection Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. The emissions control systems on the vehicles will not control emissions under off-cycle conditions as effectively as during the federal test procedure. The extent of the emissions increase under off-cycle conditions depends upon how the vehicles are driven. Revision Summary Updated work instructions.
V011333 20348982019-04-08. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. Technical Bulletin (Exhaust Gas Recirculation Flow Insufficient issues): This document informs that high soot loads prior to regeneration can cause possible restrictions in the EGR filter. The production solution to this issue is New software being implemented in current production.
VSS-17-122019-04-08. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL. Volkswagen of America is requesting your cooperation in supplying us with technical information related to the repair process for vehicles on which the TDI Generation I, II, and III 2.0L emissions modification is being performed ?Campaigns 23U3?. Volkswagen will use this information to ensure prompt analysis and resolution of any emerging concerns.
23U3 rev 09012012019-04-08. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL. 2.0L TDI Engine (GEN 1) Emissions Modification ? Customer Only (Retail Sold) USA ONLY - The Environmental Protection Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. The emissions control systems on the vehicles will not control emissions under off-cycle conditions as effectively as during the federal test procedure. The extent of the emissions increase under off-cycle conditions depends upon how the vehicles are driven. Revision Summary Updated work instructions.
V211302 20240612019-04-01. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM. In order to complete proper diagnosis and ensure that the noise is coming from the turbocharger use the procedure in this document.
Customer Letter2019-04-01. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL. Volkswagen Note (Warranty Extension for Intake Manifold & Fuel Injectors Certain 2008-2011 Model Year Volkswagen Vehicles with 2.0 TFSI Engine): As part of Volkswagen?s ongoing commitment to our environment, and in cooperation with the United States Environmental Protection Agency and the California Air Resources Board, Volkswagen is informing customers of the decision to extend the customers Emissions Control Systems Warranty for the intake manifold and fuel injectors under specific conditions to 10 years or 120,000 miles, whichever occurs first.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.