WenmarOpen by Wenmar Pro

Service bulletins for the 2011 Toyota RAV4

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

283 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

By topic

Only bulletins with component: Transmission and driveline are shown. Show all

Bulletins, newest first
T-SB-0134-16-Rev2019-09-03. Service bulletin. POWER TRAIN; ELECTRICAL SYSTEM; ENGINE. TSB: REVISION NOTICE July 01, 2019 Rev2: ? Applicability has been updated to 2019 ? 2020 model year Toyota vehicles. ? The Techstream Preparation and Process Overview sections have been updated. October 30, 2017 Rev1: ? Applicability has been updated to include 2018 model year vehicles. Any previous printed versions of this bulletin should be discarded. SUPERSESSION NOTICE The information contained in this bulletin supersedes SB No. T-SB-0012-13. Service Bulletin No. T-SB-0012-13 is obsolete and any printed versions should be discarded. Be sure to review the entire content of this bulletin before proceeding. Flash reprogramming allows the Electronic Control Unit (ECU) software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the Technical Information System (TIS) and the Calibration Update Wizard (CUW). Flash calibration updates can only be applied to the vehicle/ECU combination for which they are intended. ECUs have internal security that will not allow them to be programmed with another ECU?s information. NOTE ECU is a Toyota term used to describe integrated computerized devices responsible for managing the operation of a system or subsystem. For the purposes of this bulletin, the term ?ECU? is used as a generic label for the following SAE J1930 standard references: ? Powertrain Control Module (PCM) ? Engine Control Module (ECM) ? Transmission Control Module (TCM) ? Any other Toyota specific control unit
ZF4-WPB POL15-042018-12-17. Service bulletin. POWER TRAIN. WPB: In certain 2006 to 2012 model year Rav4 4WD vehicles, Toyota has received some reports where the vehicle may exhibit a growl type noise from the rear differential coupling when driving as a result of contamination to the front bearing.
ZF4-Dealer Daily2018-12-17. Service bulletin. POWER TRAIN. DD: In our continuing efforts to help ensure the best in customer satisfaction, Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for Rear Differential Coupling Growl Noise on 2006-2012 model year RAV4 4WD vehicles. In some of these vehicles, Toyota has received some reports that the vehicle may exhibit a growl type noise from the rear differential coupling when driving due to contamination of the front bearing. Although the Rear Differential Assembly is covered by Toyota?s New Vehicle Limited Powertrain Warranty for 5 years or 60,000 miles (whichever occurs first), we at Toyota care about our customers? ownership experience. Toyota is now extending the warranty coverage for Rear Differential Coupling Growl Noise in the covered vehicles. Please see the Warranty Enhancement Program Details for additional information. The following information is provided to inform you and your staff of the program notification schedule and your degree of involvement.
ZF4-Dealer Lette2018-12-17. Service bulletin. POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT. DL: In our continuing efforts to help ensure the best in customer satisfaction, Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for Rear Differential Coupling Growl Noise on 2006-2012 model year RAV4 4WD vehicles. In some of these vehicles, Toyota has received some reports that the vehicle may exhibit a growl type noise from the rear differential coupling when driving due to contamination of the front bearing. Although the Rear Differential Assembly is covered by Toyota's New Vehicle Limited Powertrain Warranty for 5 years or 60,000 miles (whichever occurs first), we at Toyota care about our customers? ownership experience. Toyota is now extending the warranty coverage for Rear Differential Coupling Growl Noise in the covered vehicles. Please see the Warranty Enhancement Program Details for additional information. The following information is provided to inform you and your staff of the program notification schedule and your degree of involvement.
T-SB-001-11 Rev12018-11-05. Service bulletin. POWER TRAIN. TSB: REVISION NOTICE December 12, 2017 Rev1: The Warranty and Parts Information sections have been updated. Any previous printed versions of this bulletin should be discarded. Some 2009 ? 2011 model year RAV4 vehicles equipped with the 2AR-FE engine and four speed automatic transaxle (2WD and 4WD) may exhibit a rattle noise from the transaxle assembly between 25 and 35 mph. The Engine Control Module (ECM) (SAE term: Powertrain Control Module [PCM]) logic has been revised to address this condition.
T-SB-001-11 Rev12018-06-11. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); ENGINE. TSB: REVISION NOTICE December 12, 2017 Rev1: ? The Warranty and Parts Information sections have been updated. Any previous printed versions of this bulletin should be discarded. Some 2009 ? 2011 model year RAV4 vehicles equipped with the 2AR-FE engine and four speed automatic transaxle (2WD and 4WD) may exhibit a rattle noise from the transaxle assembly between 25 and 35 mph. The Engine Control Module (ECM) (SAE term: Powertrain Control Module [PCM]) logic has been revised to address this condition.
T-SB-0080-13 Rev2018-06-11. Service bulletin. SUSPENSION:FRONT:WHEEL BEARING; POWER TRAIN. TSB: Some 2006 - 2012 model year 4WD RAV4 vehicles may exhibit a growl type noise from the rear differential coupling when driving as a result of contamination to the front bearing. Follow the procedure in this bulletin to address this condition.
T-TT-0086-112018-04-23. Service bulletin. POWER TRAIN. TechTip: Condition - The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted.
T-SB-0391-08 Rev2018-04-23. Service bulletin. POWER TRAIN. This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.
T-SB-0080-132018-04-23. Service bulletin. POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT. Some 2006 ? 2012 model year 4WD RAV4 vehicles may exhibit a growl type noise from the rear differential coupling when driving as a result of contamination to the front bearing. Follow the procedure in this bulletin to address this condition.
T-SB-0071-11 Rev2018-04-02. Service bulletin. POWER TRAIN. The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL ?ON,? shifting issues, and/or transmission damage. Use the information in this bulletin when installing an automatic transmission/transaxle assembly
T-SB-0200-08 Rev2017-08-01. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. TSB: The purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 - 2014 model year automatic transmissions.
T-SB-0134-142017-08-01. Service bulletin. POWER TRAIN; POWER TRAIN:AUTOMATIC TRANSMISSION. TSB: The purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL "ON" shifting issues and/or transmission damage. Use the information in this bulletin when installing an automatic transmission/transaxle assembly.
T-SB-0260-08 Rev2017-08-01. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. TSB: The purpose of this bulletin is to assist in the identification and location of serial numbers on 2006 -2014 model year remanufactured automatic transmissions.
T-SB-0014-11 Rev2017-08-01. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER; POWER TRAIN:AUTOMATIC TRANSMISSION. TSB: The purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. Incorrect torque converter bolts or missing washers can cause damage to the torque converter assembly.
T-SB-0006-11 Rev2017-08-01. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION; POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES; POWER TRAIN. TSB: World Standard (WS) Automatic Transmission Fluid (ATF) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. Here are some important tips when working with ATF-WS in Toyota vehicles requiring it's use.
POL15-042017-03-03. Service bulletin. POWER TRAIN; POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT. WPB: IN CERTAIN 2006 TO 2012 MODEL YEAR RAV4 4WD VEHICLES, TOYOTA HAS RECEIVED SOME REPORTS WHERE THE VEHICLE MAY EXHIBIT A GROWL TYPE NOISE FROM THE REAR DIFFERENTIAL COUPLING WHEN DRIVING AS A RESULT OF CONTAMINATION TO THE FRONT BEARING.
ZF4_DEALERD 12/32017-03-03. Service bulletin. POWER TRAIN; POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT. "DD: IN OUR CONTINUING EFFORTS TO HELP ENSURE THE BEST IN CUSTOMER SATISFACTION, TOYOTA IS ANNOUNCING A WARRANTY ENHANCEMENT PROGRAM TO EXTEND THE WARRANTY COVERAGE FOR REAR DIFFERENTIAL COUPLING GROWL NOISE ON 2006-2012 MODEL YEAR RAV4 4WD VEHICLES. IN SOME OF THESE VEHICLES, TOYOTA HAS RECEIVED SOME REPORTS THAT THE VEHICLE MAY EXHIBIT A GROWL TYPE NOISE FROM THE REAR DIFFERENTIAL COUPLING WHEN DRIVING DUE TO CONTAMINATION OF THE FRONT BEARING. ALTHOUGH THE REAR DIFFERENTIAL ASSEMBLY IS COVERED BY TOYOTA’S NEW VEHICLE LIMITED POWERTRAIN WARRANTY FOR 5 YEARS OR 60,000 MILES (WHICHEVER OCCURS FIRST), WE AT TOYOTA CARE ABOUT OUR CUSTOMERS’ OWNERSHIP EXPERIENCE. TOYOTA IS NOW EXTENDING THE WARRANTY COVERAGE FOR REAR DIFFERENTIAL COUPLING GROWL NOISE IN THE COVERED VEHICLES. PLEASE SEE THE WARRANTY ENHANCEMENT PROGRAM DETAILS FOR ADDITIONAL INFORMATION. THE FOLLOWING INFORMATION IS PROVIDED TO INFORM YOU AND YOUR STAFF OF THE PROGRAM NOTIFICATION SCHEDULE AND YOUR DEGREE OF INVOLVEMENT."
ZF4_DEALER 12/32017-03-03. Service bulletin. POWER TRAIN; POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT. "DL: IN OUR CONTINUING EFFORTS TO HELP ENSURE THE BEST IN CUSTOMER SATISFACTION, TOYOTA IS ANNOUNCING A WARRANTY ENHANCEMENT PROGRAM TO EXTEND THE WARRANTY COVERAGE FOR REAR DIFFERENTIAL COUPLING GROWL NOISE ON 2006-2012 MODEL YEAR RAV4 4WD VEHICLES. IN SOME OF THESE VEHICLES, TOYOTA HAS RECEIVED SOME REPORTS THAT THE VEHICLE MAY EXHIBIT A GROWL TYPE NOISE FROM THE REAR DIFFERENTIAL COUPLING WHEN DRIVING DUE TO CONTAMINATION OF THE FRONT BEARING. ALTHOUGH THE REAR DIFFERENTIAL ASSEMBLY IS COVERED BY TOYOTA’S NEW VEHICLE LIMITED POWERTRAIN WARRANTY FOR 5 YEARS OR 60,000 MILES (WHICHEVER OCCURS FIRST), WE AT TOYOTA CARE ABOUT OUR CUSTOMERS’ OWNERSHIP EXPERIENCE. TOYOTA IS NOW EXTENDING THE WARRANTY COVERAGE FOR REAR DIFFERENTIAL COUPLING GROWL NOISE IN THE COVERED VEHICLES. PLEASE SEE THE WARRANTY ENHANCEMENT PROGRAM DETAILS FOR ADDITIONAL INFORMATION. THE FOLLOWING INFORMATION IS PROVIDED TO INFORM YOU AND YOUR STAFF OF THE PROGRAM NOTIFICATION SCHEDULE AND YOUR DEGREE OF INVOLVEMENT."
T-SB-0080-13 REV2017-02-23. Service bulletin. POWER TRAIN; POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT. TSB: SOME 2006 - 2012 MODEL YEAR 4WD RAV4 VEHICLES MAY EXHIBIT A GROWL TYPE NOISE FROM THE REAR DIFFERENTIAL COUPLING WHEN DRIVING AS A RESULT OF CONTAMINATION TO THE FRONT BEARING. FOLLOW THE PROCEDURE IN THIS BULLETIN TO ADDRESS THIS CONDITION.
TSB-0080-132013-08-26. Service bulletin. POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT; SUSPENSION:FRONT:WHEEL BEARING. TOYOTA: THE REAR DIFFERENTIAL COUPLING, WHEN DRIVING SOME VEHICLES, MAY EXHIBIT A GROWL NOISE, DUE TO CONTAMINATION TO FRONT BEARING. MODEL 2006-2012 RAV4 (42WD). *PE
SB-0001-112011-06-07. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. TOYOTA: 2009-2011 RAV4. THERE MAY BE A RATTLE NOISE FROM THE TRANSAXLE WHEN DRIVING AROUND 30MPH. *RM

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.