WenmarOpen by Wenmar Pro

Service bulletins for the 2007 Toyota PRIUS

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

219 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

By topic

Bulletins, newest first
T-SB-0144-08_Obs2018-04-23. Service bulletin. EQUIPMENT. TSB: OBSOLETE NOTICE November 21, 2017: This bulletin is now obsolete. Please see T-SB-0304-17.
T-SB-0012-13 Rev2018-04-02. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. TSB: OBSOLETE NOTICE: September 14, 2016: This bulletin is now obsolete. Please see T-SB-0134-16.
T-SB-0142-13 Rev2018-04-02. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. TSB: REVISION NOTICE November 10, 2016 Rev2: ? Applicability has been updated to include 2016 ? 2017 model year Toyota vehicles. ? Parts Information section has been updated. Some 2004 ? 2017 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bulletin to minimize the odors experienced.
T-TT-0010-10 Rev2018-04-02. Service bulletin. BACK OVER PREVENTION; ENGINE. Tech Tip: Low battery voltage can contribute to a MIL "ON" condition for P0335 (Crankshaft Position Sensor Circuit) and/or P0340 (Camshaft Position Sensor Circuit) due to inconsistent rotational speed of the engine's crankshaft.
T-SB-0174-12 Rev2018-04-02. Service bulletin. SERVICE BRAKES, AIR:ANTILOCK:CONTROL UNIT/MODULE. TSB: Some 2004 ? 2009 model year Prius vehicles may exhibit a MIL ?ON? and brake warning lights (ABS/VSC) illuminated in the instrument panel with Diagnostic Trouble Code (DTC) C1247 (Stroke Sensor Malfunction) stored in the ABS/VSC Electronic Control Unit (ECU). This DTC may set as a result of an overly sensitive monitoring logic without any other ABS/VSC system issue. Follow the Repair Procedure in this bulletin to properly diagnose the system and, if necessary, replace the ABS/VSC ECU with an ECU containing the updated monitoring logic.
T-SB-0012-13 Rev2018-04-02. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. TSB: Flash reprogramming allows the ECU software to be updated without replacing the ECU. Flash calibration updates for specific vehicle models/ECUs are released as field-fix procedures described in individual Service Bulletins. This bulletin details the Techstream ECU flash reprogramming process and outlines use of the Technical Information System (TIS) and the Calibration Update Wizard (CUW). Flash calibration updates can only be applied to the vehicle/ECU combination for which they are intended. ECUs have internal security that will not allow them to be programmed with another ECU?s information.
T-SB-0043-14 Rev2018-04-02. Service bulletin. EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES. TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased.
T-SB-0043-142018-04-02. Service bulletin. EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES. TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased.
T-TT-0365-152018-04-02. Service bulletin. EQUIPMENT. TT: A vehicle may arrive to the dealer with a MIL ?ON? condition and P0A80 stored in the memory. Some cases have been identified with internal modification done to the HV Battery. Modified or altered parts are not covered under warranty.
T-TT-0086-112018-04-02. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY; ENGINE. TechTip: Condition - The vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the Engine ECM has been interrupted.
T-TT-0303-142018-04-02. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY. TechTip: When a DTC is detected by the HV Battery ECU, the HV Control ECU will automatically store a P3000, Information Code 123 ?HV Battery Control System Malfunction? DTC. The purpose of the P3000/123 is to capture the state of the Hybrid Control System when the HV Battery ECU DTC sets. It does not indicate a malfunction of the HV Control ECU.
T-SB-0218-17_Rev2018-04-02. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; AIR BAGS. TSB: REVISION NOTICE July 20, 2017 Rev1: Applicability has been updated to exclude 2007 ? 2017 model year Avanza vehicles. Some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deployment of airbag and pre-tensioner assemblies as hazardous material treatment. Hazardous material treatment may require special training, certification or licensing in certain areas. TMS recommends that dealership personnel carefully review and follow ALL local and state regulations, and where necessary, contract with Environmental Protection Agency (EPA) Licensed Hazardous Waste Transportation and Disposal facilities.
T-TT-0118-11 Rev2018-04-02. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY. Technicians should confirm the following key points to minimize the potential for future MIL "ON" concerns after HV battery replacement.
T-PG006-00 Obsol2018-04-02. Service bulletin. EQUIPMENT:OTHER:LABELS. This bulletin is now obsolete. Please see T-SB-0054-13.
T-SB-0054-132018-04-02. Service bulletin. EQUIPMENT. California (CA), Federal (FED), and 50 State Certified emission control underhood labels (emission labels) may be obtained through your dealership?s Parts Department utilizing standard replacement parts ordering procedures. Follow the guidelines outlined in this bulletin to ensure proper label application.
T-SB-0141-10 Rev2018-04-02. Service bulletin. STRUCTURE:EMERGENCY:ESCAPE/EGRESS/EXIT; BACK OVER PREVENTION. If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers bonded to the lower edge of the windshield. This bulletin provides the recommended repair procedure to eliminate these types of noises from the windshield/rear glass area.
T-SB-0098-132018-04-02. Service bulletin. ENGINE AND ENGINE COOLING:COOLING SYSTEM. For vehicles that are used under certain severe operating conditions, the HV Battery Cooling Fan may experience an excessive buildup of dust, lint, or other debris that can reduce the efficiency of the HV Battery Cooling System. HV Battery Cooling Fan maintenance and cleaning should be performed to address this condition.
T-TT-0269-132018-04-02. Service bulletin. VISIBILITY:GLASS, SIDE/REAR. The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
T-TT-0268-132018-04-02. Service bulletin. EQUIPMENT:ELECTRICAL; ELECTRICAL SYSTEM. These concerns can be caused by changes made on the customer?s phone. Make sure to inquire with the customer if the connectivity concerns occurred after receiving an operating system update on their phone or they have restored their phone data/settings recently.
T-SB-0153-132018-04-02. Service bulletin. ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN. Some 2004 ? 2009 model year Prius vehicles may exhibit a MIL ?ON? condition with Diagnostic Trouble Code (DTC) P0A80 or P0A7F stored due to dust or debris build-up in the HV Battery Cooling Fan. Use the following repair procedure to address this condition.
T-SB-0122-11 Rev2018-04-02. Service bulletin. AIR BAGS; SEATS; EQUIPMENT. Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT recommended by Toyota may affect side airbag performance, in general or in part, during an accident. Modifications that negatively affect side airbag performance can result in severe occupant injuries. Seat covers are an integral part of this safety system. Replacing fabric seat covers with non-Toyota leather or other seat cover materials may compromise the effectiveness of this safety system. The design of the seat is complex, integrating safety and strength with comfort and luxury. Toyota strongly discourages modifying original equipment seats that have optional side airbags. Additionally, Toyota strongly advises against the installation or use of aftermarket seat covers, which could impair the performance of the side airbags in the event of an accident.
T-TT-0124-112018-04-02. Service bulletin. TIRES. Please refer to the following recommendations for the best practices for vehicle tire rotations.
TS-BO030-01 Obso2018-04-02. Service bulletin. VISIBILITY/WIPER. This bulletin is now obsolete. Please see T-SB-0185-13.
T-SB-0186-132018-04-02. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY. The purpose of this general information Service Bulletin is to inform the market that sub-component diagnosis and replacement is now available for the Hybrid Inverter with Converter Assembly equipped on 2004 ? 2009 model year Prius vehicles.
T-SB-0185-132018-04-02. Service bulletin. VISIBILITY. The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.