WenmarOpen by Wenmar Pro

Service bulletins for the 2005 Toyota 4Runner

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

227 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

By topic

Bulletins, newest first
T-PG006-00 Obsol2018-04-02. Service bulletin. EQUIPMENT:OTHER:LABELS. This bulletin is now obsolete. Please see T-SB-0054-13.
T-SB-0054-132018-04-02. Service bulletin. EQUIPMENT. California (CA), Federal (FED), and 50 State Certified emission control underhood labels (emission labels) may be obtained through your dealership?s Parts Department utilizing standard replacement parts ordering procedures. Follow the guidelines outlined in this bulletin to ensure proper label application.
T-SB-0141-10 Rev2018-04-02. Service bulletin. STRUCTURE:EMERGENCY:ESCAPE/EGRESS/EXIT; BACK OVER PREVENTION. If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers bonded to the lower edge of the windshield. This bulletin provides the recommended repair procedure to eliminate these types of noises from the windshield/rear glass area.
T-TT-0269-132018-04-02. Service bulletin. VISIBILITY:GLASS, SIDE/REAR. The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
T-SB-0230-12 Rev2018-04-02. Service bulletin. FUEL SYSTEM, GASOLINE; FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM. Some 2005 ? 2009 model year 4Runner, 2006 ? 2007 model year Land Cruiser, 2005 ? 2007 model year Sequoia, and 2005 ? 2006 model year Tundra vehicles equipped with the 2UZ-FE (4.7 L) engine may exhibit a MIL ?ON? condition for the following Diagnostic Trouble Codes (DTCs): ? P0412 ? Secondary Air Injection System Switching Valve ?A? Circuit ? P0418 ? Secondary Air Injection System Relay ?A? Circuit ? P1440/P1443 ? Secondary Air Injection System Control Valve Circuit Bank 1 / Bank 2 ? P1441/P1444 ? Secondary Air Injection System Switching Valve No. 2 Bank 1 / Bank 2 Stuck Open ? P2440 ? Secondary Air Injection System Switching Valve Stuck Open Bank 1 ? P1442/P1445 ? Secondary Air Injection System Switching Valve No. 2 Bank 1 / Bank 2 Stuck Close ? P2441 ? Secondary Air Injection System Switching Valve Stuck Close Bank 1 ? P2445 ? Secondary Air Injection System Pump Stuck Off Bank 1 This condition may be caused by debris passing through the air injection pump assembly and contaminating various components in the system. Use the following procedure to address this condition.
T-SB-0071-11 Rev2018-04-02. Service bulletin. POWER TRAIN. The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid MIL ?ON,? shifting issues, and/or transmission damage. Use the information in this bulletin when installing an automatic transmission/transaxle assembly
T-SB-0122-11 Rev2018-04-02. Service bulletin. AIR BAGS; SEATS; EQUIPMENT. Beginning in 1998, Toyota introduced side airbags as optional equipment. Toyota does NOT recommend replacement of original seat covers with non-Toyota leather or other seat cover materials on vehicles due to the following: Seat covers NOT recommended by Toyota may affect side airbag performance, in general or in part, during an accident. Modifications that negatively affect side airbag performance can result in severe occupant injuries. Seat covers are an integral part of this safety system. Replacing fabric seat covers with non-Toyota leather or other seat cover materials may compromise the effectiveness of this safety system. The design of the seat is complex, integrating safety and strength with comfort and luxury. Toyota strongly discourages modifying original equipment seats that have optional side airbags. Additionally, Toyota strongly advises against the installation or use of aftermarket seat covers, which could impair the performance of the side airbags in the event of an accident.
T-TT-0124-112018-04-02. Service bulletin. TIRES. Please refer to the following recommendations for the best practices for vehicle tire rotations.
TS-BO030-01 Obso2018-04-02. Service bulletin. VISIBILITY/WIPER. This bulletin is now obsolete. Please see T-SB-0185-13.
T-SB-0185-132018-04-02. Service bulletin. VISIBILITY. The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
T-SB-0142-132018-04-02. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. Some 2004 ? 2014 model year Toyota vehicles may exhibit odors naturally occurring from the HVAC system and/or related environmental factors. Although there is no way to eliminate these odors, follow the General Procedure in this bulletin to minimize the odors experienced.
T-SB-0141-132018-04-02. Service bulletin. EQUIPMENT; PARKING BRAKE. A new Special Service Tool (SST 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. This bulletin references the correct method for installing the Brake Pedal Force Gauge. Refer to the appropriate Repair Manual for parking brake pedal travel inspection and adjustment specification.
T-TT-0213-132018-04-02. Service bulletin. AIR BAGS. Toyota vehicles are equipped with Supplemental Restraint Systems (SRS), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. If a customer expresses any concerns that the SRS airbags or pre-tensioner devices did not perform as expected (including an unintended deployment event), please follow the steps in the recommendations section below.
T-SB-0187-12 Rev2018-04-02. Service bulletin. TIRES. Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to service. With a conventional tire it is not possible to drive for an extended amount of time with the tire at low pressures as damage to the tire may occur. With run-flat tires, due to reinforced sidewalls, it is possible to drive for up to 100 miles (160 km) at speeds less than 55 mph (90 km/h) with little or no damage to the tire.
T-TT-0132-112018-04-02. Service bulletin. EQUIPMENT; SERVICE BRAKES, HYDRAULIC. A key part to maintain the proper function and safe operation of the vehicle's braking system is to perform a visual inspection when installing brake pads, calipers, and discs. The following recommendations are intended to provide general tips for the inspection and/or installation of Toyota Complete Maintenance Care (TCMC) front brake pads and discs. Always refer to the model specific Repair manual and TIS publications for specific repair instructions.
ZE6_POL14-11_War2018-04-02. Service bulletin. ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL. Warranty Policy Bulletin POL14-11: REVISED March 22, 2017: Toyota has received reports where some vehicles may exhibit cracked and/or sticky/melting dashboards as a result of heat or humidity.
ZE6 Dealer Daily2018-04-02. Service bulletin. ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL. Dealer Daily: Voluntary Extension of Warranty Coverage for Cracked and/or Sticky/Melting Dashboards (Instrument Panels) as a Result of Heat or Humidity.
T-SB-0189-172018-04-02. Service bulletin. VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW. TSB: Some 2003 ? 2009 model year 4Runner vehicles may exhibit back door glass "broken" without external impact. This condition may be associated with rear window defogger usage before glass breakage. Updated rear glass has been developed to address this condition.
T-SB-0187-12_Rev2018-04-02. Service bulletin. TIRES. TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous printed versions of this bulletin should be discarded. Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to service. With a conventional tire it is not possible to drive for an extended amount of time with the tire at low pressures as damage to the tire may occur. With run-flat tires, due to reinforced sidewalls, it is possible to drive for up to 100 miles at speeds less than 55 mph with little or no damage to the tire. The U.S. Tire Manufacturers Association (UTSMA) provides guidelines and recommendations for tire repair and replacement. It also provides information related to: ? Basic tire information ? Tire maintenance and safety ? Driver education, tire safety curriculum.
ZG7_POL17-03_War2018-04-02. Service bulletin. VISIBILITY:GLASS, SIDE/REAR. Warranty Policy Bulletin POL17-03: Toyota has received reports of customer concerns where the vehicles rear hatch glass broke during defroster operation.
ZG7 Dealer Packa2018-04-02. Service bulletin. VISIBILITY:GLASS, SIDE/REAR. Dealer Package: Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for Broken Rear Hatch Glass on Certain 2003-2009 Model Year 4Runner Vehicles.
ZG7_Dealer Email2018-04-02. Service bulletin. VISIBILITY:GLASS, SIDE/REAR. Dealer Email: Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for Broken Rear Hatch Glass on Certain 2003-2009 Model Year 4Runner Vehicles.
ZG7_Region Email2018-04-02. Service bulletin. VISIBILITY:GLASS, SIDE/REAR. Region Email: Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for Broken Rear Hatch Glass on Certain 2003-2009 Model Year 4Runner Vehicles.
T-SB-0304-17_Rev2018-04-02. Service bulletin. EQUIPMENT. TSB: SUPERSESSION NOTICE The information contained in this bulletin supersedes Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, and T-SB-0144-08. Service Bulletin Nos. PG021-88, PG015-89, PG0015-90, PG002-91, PG002-93, PG005-97, PG007-01, PG007-07, and T-SB-0144-08 are obsolete and any printed versions should be discarded. Be sure to review the entire content of this bulletin before proceeding. REVISION NOTICE January 11, 2018 ? The Supersession Notice has been updated. Any previous printed versions of this bulletin should be discarded. Vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) may be available from Toyota, provided the request meets one of the criteria listed in this Service Bulletin.
T-SB-0187-12_Rev2018-03-12. Service bulletin. TIRES. TSB: REVISION NOTICE February 12, 2018 Rev2: ? Applicability has been updated to include 2015 ? 2018 model year vehicles. January 23, 2014 Rev1: ? Applicability has been updated to include 2013 ? 2014 model year vehicles. Any previous printed versions of this bulletin should be discarded. Toyota vehicles are equipped with either conventional or run-flat tires. Sometimes punctures may occur as a result of contact with road debris or other hazards. If a puncture occurs, it may be possible to repair the tire and return it to service. With a conventional tire it is not possible to drive for an extended amount of time with the tire at low pressures as damage to the tire may occur. With run-flat tires, due to reinforced sidewalls, it is possible to drive for up to 100 miles at speeds less than 55 mph with little or no damage to the tire. The U.S. Tire Manufacturers Association (UTSMA) provides guidelines and recommendations for tire repair and replacement. It also provides information related to: ? Basic tire information ? Tire maintenance and safety ? Driver education, tire safety curriculum.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.