WenmarOpen by Wenmar Pro

Service bulletins for the 2008 Suzuki XL7

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

65 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Bulletins, newest first
PIC5491J2017-04-10. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT. THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE AN ONSTAR SYSTEM THAT WILL NOT POWER UP. TECHNICIAN SHOULD TURN OFF THE IGNITION AND CANCEL RETAINED ACCESSORY POWER. AFTER THE VEHICLE HAS POWERED DOWN REMOVE POWER TO THE ONSTAR MODULE FOR FIVE MINUTES. AFTER THE POWER HAS BEEN REMOVED FOR FIVE MINUTES, IF THE ONSTAR SYSTEM IS WORKING RELEASE THE VEHICLE. IF THE ONSTAR SYSTEM IS STILL INOPERATIVE CONTINUE WITH PUBLISHED SERVICE INFORMATION DIAGNOSTICS.
PIP5226A2017-03-21. Service bulletin. EQUIPMENT. THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT FINDING NEEDLE BEARINGS DURING AN OIL CHANGE. TECHNICIAN WILL GAIN ACCESS TO THE ROLLER ROCKERS TO INSPECT THEM. ONLY REPLACE THE ROLLER ROCKER THAT IS MISSING NEEDLE BEARINGS. BE SURE TO CLEAN THE OIL DRAINS TO RETRIEVE THE NEEDLE BEARINGS. EACH ROLLER ROCKER HAS 66 BEARINGS.
SC-662014-02-05. Service bulletin. FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP. SUZUKI: WHERE PLASTIC SUPPLY OR RETURN PORT ON FUEL PUMP MODULE, THERE IS A CRACK THAT CAN CAUSE A FUEL LEAK AND WHILE BEING DRIVEN OR PARKING, FUEL ODOR MAY BE NOTICED AND COULD BECOME LARGER AND DRIP ON THE GROUND. MODEL 2007-2009 XL7. *PE
TSB-TS-27-073132014-01-30. Service bulletin. FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY. SUZUKI: WHEN VEHICLE IS EITHER PARKED OR BEEN DRIVEN, CAN SMELL AN ODOR OF FUEL, OR CAN OBSERVED FUEL DRIPPING, AROUND AREA OF FUEL TANK IN REAR OF VEHICLE, DUE TO CRACK IN PLASTIC SUPPLY OR RETURN PORT OF FUEL PUMP MODULE, CAUSING THE ODOR. MODEL 2007-2009 XL7. *PE
SI-0012-R2013-08-08. Service bulletin. ENGINE. SUZUKI: TIMING CHAIN SERVICE KITS ARE AVAILABLE. THE PURPOSE OF THE KITS ARE TO PROVIDE PARTS NEEDED IN ORDER TO SERVICE TIMING CHAINS THAT HAVE STRETCHED. *JS
TSB-39-082582012-11-06. Service bulletin. EXTERIOR LIGHTING:TURN SIGNAL; EXTERIOR LIGHTING:TURN SIGNAL:SWITCH. SUZUKI: THE TURN SIGNAL AND LAMPS ON TRAILER STAY ON OR INOPERATIVE DUE TO INCORRECT INSTALLATION OF LAMP RELAYS. MODEL 2007 XL7. *PE
PIP-4478A2010-11-15. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; WHEELS. BUICK/CHEVROLET/GMC/PONTIAC/SATURN/SUZUKI: ALL WHEEL DRIVE SYSTEM INOPERATIVE AND DTC C0550 SET. VARIOUS CONCERNS MAY BE RELATED TO A LOW BATTERY SUCH AS BUT NOT EXCLUSIVE TO A NO CRANK OR SLOW ENGINE CRANK CONCERNS OR MAY HAVE RECENTLY HAD TO HAVE THE VEHICLE JUMP STARTED. THIS MAY OCCUR DUE TO LOW VOLTAGE PRESENCE IN THE SYSTEM. *PE UPDATED ON 06/16/2011. *KB
TS-05-120992010-05-08. Service bulletin. AIR BAGS; ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL. SUZUKI: TECHNICIANS MAY ENCOUNTER AN INTERMITTENT OR CURRENT AIR BAG LIGHT ON IN THE INSTRUMENT PANEL WITH DTC(S) B0012, B0013, B0014, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 OR B0044 SET IN THE SDM (SENSING AND DIAGNOSTIC MODULE). CONNECTOR(S) MAY BE FOUND LOOSE, MISSING, OR BROKEN AT THE AIRBAG ASSOCIATED WITH THE STORED DTC(S). *PE
08-04-21-0022008-07-25. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. FLUID LEAK AT TRANSFER CASE WEEP HOLE (REPLACE FRONT WHEEL DRIVE INTERMEDIATE (INNER) SHAFT SEAL). *PE
TS 10 040482008-07-01. Service bulletin. POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE). AUTOMATIC TRANSMISSION FLUID LEAK FROM TRANSFER CASE. UP TO VIN 2S3DA5179883 (MFG DATE 12/21/07). *NJ
TS03 01108R2008-04-21. Service bulletin. AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE. AIR BAG LIGHT ON, WITH DTC B0081 SYMPTOM CODE [OF] (PASSENGER PRESENCE SYSTEM ERRATIC). *NJ
TS24 021182008-04-21. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. CHECK ENGINE LIGHT (ON), DTC P0128 (ENGINE COOLANT TEMPERATURE (ECT) BELOW THERMOSTAT REGULATING TEMPERATURE) - OUTSIDE TEMPERATURES BELOW FREEZING. *NJ
TS23011882008-03-21. Service bulletin. FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS. INCORRECT FUEL SENDER HARNESS CONNECTOR PLUGS (EMISSIONS CAMPAIGN 99-NF). ALL 2008 VEHICLES MANUFACTURED BEFORE SEPT. 18, 2007. MODEL XL7. VIN(S): 2S3D_417_86100013 - 2S3D_417_86108791. CSC WAS RECEIVED. *NJ
03121172008-01-30. Service bulletin. AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE. AIRBAG LIGHT ON, WITH DTC B0081 SYMPTOM CODE )OF) PASSENGER PRESENCE SYSTEM ERRATIC. *NJ
30103072008-01-29. Service bulletin. ELECTRICAL SYSTEM:WIRING. CUSTOMER SATISFACTION CAMPAIGN (NC), XM RADIO HARNESS INSTALLATION. *NJ

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.