Service bulletins for the 2010 Saturn Outlook
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
1265 on file from NHTSA, as of 2026-10-19.
By type
By component
By trouble code
By topic
Only bulletins with component: Engine are shown. Show all
| 16-NA-222 | 2017-05-25. Service bulletin. ENGINE. THIS INFORMATIONAL BULLETIN PROVIDES THE TECHNICIAN WITH WHAT MAY HAPPEN TO AN ENGINE DUE TO LACK OF MAINTENANCE. |
|---|---|
| PIP5282A | 2017-05-18. Service bulletin. ENGINE. THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ABOUT THE CALCULATION AND OPERATION OF THE ENGINE OIL LIFE MONITOR. THE MONITOR CALCULATES THE PERCENT OF OIL LIFE REMAINING, BASED ON 3 PATHWAYS. THE FIRST PATHWAY FOR OIL LIFE CALCULATION IS ENGINE REVOLUTIONS. THE SECOND PATHWAY FOR OIL LIFE CALCULATION IS THE MILEAGE FORM THE LAST REST FOR ALL GENERAL MOTORS POWERTRAINS EXCEPT THE VOLT. THE THIRD PATHWAY FOR OIL LIFE CALCULATION IS THE AMOUNT OF TIME THE OIL IS IN THE ENGINE. THE VOLT USES A 2 YEAR TIMER INSTEAD OF 1 YEAR. IT ALSO USES THE ENGINE REVOLUTION COUNTER. IT DOES NOT USE THE MILEAGE PATHWAY TO COUNT DOWN. |
| PIP5029G | 2017-05-16. Service bulletin. ENGINE. THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE A MALFUNCTION INDICATOR LAMP ON OR ENGINE MISFIRE, ROUGH IDLE, EXTENDED CRANK, OR CRANK NO START IN SOME CASES. TECHNICIAN WILL NEED TO PERFORM PUBLISHED SERVICE INFORMATION DIAGNOSTICS. IF TECHNICIAN FINDS CARBON, AN UPPER ENGINE AND VALVE CLEANING SHOULD BE PERFORMED. |
| PIT5165C | 2017-03-16. Service bulletin. EQUIPMENT; EQUIPMENT ADAPTIVE/MOBILITY; ENGINE AND ENGINE COOLING. THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ON THE STEP TO REPLACE THE POWER STEERING COOLER. TECHNICIAN WILL NEED TO BLOCK OFF THE HOSES NEAR THE COOLER CONNECTION WITH APPROPRIATE CLAMPS. AFTER THE HOSES ARE CLAMPED DISCONNECT THE COOLER FROM THE LINES AND REMOVE THE COOLER. BEFORE INSTALLING THE NEW COOLER PREFILL THE NEW COOLER ON THE BENCH AND CAP OFF THE PRE-FILLED COOLER ENDS FOR INSTALLATION. WHEN THE NEW COOLER IS INSTALLED REMOVE THE CLAMPS ON THE HOSES AND FOLLOW THE SERVICE INFORMATION FOR POWER STEERING SYSTEM BLEED PROCEDURE. |
| 08-06-01-011K | 2017-01-19. Service bulletin. ENGINE; ELECTRICAL SYSTEM. THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO PERFORM VARIOUS CHECKS AND REPAIRS TO CORRECT A CUSTOMER OF MALFUNCTION INDICATOR LAMP ON AND DTCS SET. |
| PIP4786C | 2016-10-20. Service bulletin. ENGINE AND ENGINE COOLING. THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT MAY HAVE LOW OIL PRESSURE MESSAGE. TECHNICIAN MAY ALSO FIND A DIAGNOSTIC TROUBLE CODE P0521 IN THE ENGINE CONTROL MODULE. TECHNICIAN SHOULD FOLLOW ALL PUBLISHED SERVICE INFORMATION DIAGNOSIS. WHEN USING A SCAN TOOL IF THE OIL PRESSURE IS LOW BUT THE OIL PRESSURE AT THE OIL FILTER HOUSING IS CORRECT, TECHNICIAN SHOULD INSPECT THE VALVE LIFTER OIL FILTER FOR DEBRIS/SLUDGE THAT COULD BE RESTRICTING OIL FLOW TO THE OIL PRESSURE SENSOR. TECHNICIAN SHOULD REMOVE THE VALVE LIFTER OIL FILTER AND CLEAN IT. IF THE VALVE LIFTER OIL FILTER CANNOT BE CLEANED REPLACE IT. |
| PI1394A | 2016-10-19. Service bulletin. ENGINE. THIS INFORMATIONAL BULLETIN PROVIDES ADDITIONAL INFORMATION ON HOW TO INSTALL PISTONS AND SUGGEST WHAT TOOLS TO USE. |
| 030604017I | 2016-10-18. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:DIESEL. THIS INFORMATIONAL BULLETIN EXPLAINS THE USE OF DIESEL FUEL ADDITIVES IN AN ENGINE, ARE NOT REQUIRED UNLESS THE CUSTOMER DESIRES ADDITIVES TO PREVENT FUEL CONCERNS DEPENDING ON FUEL OR TEMPERATURE RELATED CONDITIONS. |
| 030603004R | 2016-10-18. Service bulletin. ENGINE; ELECTRICAL SYSTEM:12V/24V/48V BATTERY. THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION ON HOW TO TEST A BATTERY AND WHAT IS NEEDED TO WARRANTY A BATTERY. |
| 000601026I | 2016-10-18. Service bulletin. ENGINE. THIS INFORMATIONAL BULLETINS PROVIDES INFORMATION ON THE INTAKE MANIFOLD INSPECTION/REPLACEMENT AFTER SERVERE INTERNAL ENGINE DAMAGE. |
| 000601012F | 2016-10-18. Service bulletin. ENGINE. THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION TO GM DEALERS ON THE CORRECT CLEANING METHODS WHEN CLEANING ENGINE GASKET SEALING SURFACES. |
| 16NA249 | 2016-10-14. Service bulletin. ENGINE AND ENGINE COOLING. THIS INFORMATIONAL BULLETIN EXPLAINS A POSSIBLE NORMAL WHINING NOISE FROM THE BALANCE SHAFT CHAIN IF THE VEHICLE HAS LESS THAN 10,000 MILES ON IT. |
| 16-NA-085 | 2016-10-05. Service bulletin. STRUCTURE; EQUIPMENT; ENGINE. THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION ON NEW DESIGN CYLINDER HEADS. |
| CSP-25630 | 2016-08-18. Service bulletin. EQUIPMENT; ENGINE. 25630 – CUSTOMER SATISFACTION PROGRAM. THESE VEHICLES MAY HAVE HAD REMANUFACTURED ENGINES INSTALLED DURING A SERVICE REPAIR THAT WERE BUILT WITH INCORRECT PISTON RINGS. THIS MAY RESULT IN ENGINE MISFIRES, LACK OF POWER, ROUGH RUNNING, OIL CONSUMPTION AND EVENTUALLY ENGINE FAILURE DUE TO OIL CONSUMPTION. DEALERS ARE TO INSPECT ENGINE SERIAL NUMBERS. IF THE SERIAL NUMBER MATCHES A LIST OF SUSPECT ENGINES, THE ENGINE WILL BE REPLACED. |
| SB-07-06-01-016C | 2016-08-09. Service bulletin. ENGINE. THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION INTERNAL ENGINE NOISE OR DAMAGE AFTER OIL FILTER REPLACEMENT |
| PIP5216C | 2016-07-07. Service bulletin. ENGINE. If a vehicle comes into the dealership with a knock noise, seized engine, lower end squeak or squeal or any condition that you suspect a rod or main bearing failure. |
| PIP-5216 | 2014-11-08. Service bulletin. ENGINE. BUICK/CADILLAC/CHEVROLET/SATURN/PONTIAC/ GMC: VEHICLE EXPERIENCE LOWER END SQUEAK OR SQUEAL, KNOCKING NOISE OR SEIZED ENGINE POSSIBLY THE MAIN BEARING OR ROD HAD FAILED. *PE |
| PIP-3423-K | 2014-05-20. Service bulletin. ENGINE. GM: SOME DTC CODES MAY BE SET, P0016, P0017, P0018, P0019, P0008, OR P0009. 3.6 LY7 WITH CAM ACTUATOR DTC.THE RELUCTOR FOR THE CRANKSHAFT SENSOR PRESSED ON THE CRANKSHAFT MAY HAVE MOVED. ALSO INCLUDED BUICK ALLURE MODEL YEAR 2005. *JS |
| SB-10-06-01-003C | 2013-11-29. Service bulletin. EQUIPMENT ADAPTIVE/MOBILITY; ENGINE. CADILLAC/BUICK/SATURN/PONTIAC/CHEVROLET/ GMC: DUE TO AN ABNORMAL ENGINE NOISE OR INTERNAL BY AN OIL FILTER MISAPPLICATION, FILTER DEBRIS MAY BE TRANSFERRED THROUGHOUT ENGINE AND MAY RESULT IN ENGINE DAMAGE. MODEL 2004-06 RENDEZVOUS, 2005-14 LACROSSE, 2008-14 ENCLAVE, MALIBU, EQUINOX, 2010-14 SRX, TERRAIN, 2013-14 ATS, XTS, 2009-14 TRAVERSE, 2014 IMPALA, 2007-14 ACADIA, 2007-09 G6, AURA, 2008-09 TORRENT, VUE, 2007-10 OUTLOOK. *PE |
| 12-06-01-009-D | 2013-09-23. Service bulletin. ENGINE. GM: SOME VEHICLES REQUIRE REPLACEMENTS FOR HIGH FEATURE V6 TIMING CHAIN KITS AND GUIDE REPLACEMENTS. ALSO INCLUDED CHEVROLET CAPTIVA. MODEL YEARS 2007-2013. *JS UPDATED 7/18/14. *PE |
| SB-13091 | 2013-07-19. Service bulletin. ENGINE AND ENGINE COOLING:COOLING SYSTEM. BUICK/CHEVROLET/GMC/SATURN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON CERTAIN VEHICLES, THE WATER PUMP SHAFT SEAL MAY EXPERIENCE A LEAKAGE CAUSED BY LOW ENGINE COOLANT LEVEL THAT MAY RESULT IN WATER PUMP FAILURE. MODELS 2008-2010 ENCLAVE, 2009-2010 TRAVERSE, 2007-2010 ACADIA, OUTLOOK. *PE |
| PB-13079 | 2013-06-27. Service bulletin. ENGINE AND ENGINE COOLING:COOLING SYSTEM. BUICK/CHEVROLET/GMC/SATURN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SOME VEHICLES ARE EXPERIENCING LOW LOW ENGINE COOLANT LEVEL, CAUSING LEAKAGE FROM WATER PUMP SHAFT SEAL AND NEED TO BE CHECKED. MODELS 2009-2013 ENCLAVE, TRAVERSE, ACADIA, 2009-2010 OUTLOOK. *PE |
| PI-0746 | 2012-08-02. Service bulletin. ENGINE. GENERAL MOTORS: MALFUNCTION INDICATOR LAMP (MIL) ON, POOR ACCELERATION, THROTTLE BODY FREEZING, MULTIPLE DTCS SET. ICE DEPOSITS AND/OR OIL DEPOSITS PRESENT IN AIR INLET DUCT. *JS UPDATED 9/19/12. *PE UPDATED 12/5/12. *PE UPDATED 05/03/2013 *JS UPDATED 09/30/2013 *JS UPDATED 7/28/14. *PE |
| PIT-5164 | 2012-06-18. Service bulletin. ENGINE; FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM. GM: FUEL GAUGE INOPERATIVE/FLUCTUATES HARD/NO START SES/CHECK ENGINE LIGHT ON. CONDITIONS MAY BE INTERMITTENT. UPON INVESTIGATION, THE TECHNICIAN MAY FIND VARIOUS DTCS SET. THIS CONDITION MAY BE DUE TO THE HARNESS RETAINER SLIPPING ON THE TUBING PUTTING PRESSURE ON THE HARNESS CAUSING CONNECTOR X305 TO BE PARTIALLY SEPARATED OR NOT FULLY SEATED. *JS |
| PI-0012 | 2011-11-19. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. BUICK/CADILLAC/CHEVROLET/GMC/PONTIAC/SATURN: DUE TO THE POSSIBILITY OF A DAMAGE LOCATOR PIN, THE CHECK ENGINE LIGHT COMES ON. *PE |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.