WenmarOpen by Wenmar Pro

Service bulletins for the 2019 Ram 4500

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

603 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

By topic

Only bulletins with component: Automatic transmission are shown. Show all

Bulletins, newest first
18071232023-08-21. Service bulletin. ELECTRICAL SYSTEM; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); POWER TRAIN. Flash: Powertrain Control Module (PCM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set: ? P1404 - EGR Close Position Performance. ? P0456 - EVAP System Small Leak. NOTE: If DTC P0456 is present use the wiTECH Small Leak Verification test (SLVT) to determine if a leak is present in the system. In addition, the customer may notice one or more of the following conditions: ? **Power Take Off (PTO) disable to high engine oil temperature (DD DP Only).** ? Abrupt gear engagement when transitioning from Park to Drive/Reverse gear state in Power Takeoff (PTO) Mode. ? Vehicle hesitation or surge at low vehicle speeds. ? Engine hesitation when turning steering wheel to end stop. ? Powertrain bump or hesitation around 16-24 kph (10-15 mph) vehicle speed. May be reported as rough or harsh transmission shifting in the same vehicle speed range This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software.
S18080001522023-04-17. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM). CEL (Check Engine Lamp) Illuminates, Recent PCM Replace or Flash Update Performed, Diagnostic Trouble Codes (DTCs) P057B Brake Pedal Position Sensor Circuit Performance, P1572 Brake Pedal Stuck, C0042-54 Brake Pedal Missing Calibration
21020222023-01-23. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); ELECTRICAL SYSTEM. Transmission Control Module (TCM) Updates
S1918000003RevA2022-10-17. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. Revision A: Intermittent Engine Buck, Surge, or Misfire.
Y172022-10-17. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE:SOFTWARE; POWER TRAIN. Customer Satisfaction Notification Y17 Transmission Software Update
18-011-212022-08-22. Service bulletin. ELECTRICAL SYSTEM; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); ENGINE AND ENGINE COOLING. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following DTCs have been set: P0607-00 - ECU Internal Performance. P20E8-00 - Reductant Pressure Too Low. P0301-00 - Cylinder 1 Misfire(Sym Cam only). P0302-00 - Cylinder 2 Misfire(Sym Cam only). P0303-00 - Cylinder 3 Misfire(Sym Cam only). P0304-00 - Cylinder 4 Misfire(Sym Cam only). P0305-00 - Cylinder 5 Misfire(Sym Cam only). P0306-00 - Cylinder 6 Misfire(Sym Cam only). P0299-00 - Turbocharger Underboost. P1D73-00 - AGS Performance. P0626 - Generator Field Control Circuit High. P218F - Reductant No Flow Detected. P2002 - Diesel Particulate Filter Efficiency Below Threshold. P24A5 - EGR Cooler Bypass Bank 1 Control Stuck. P0191 - Fuel Rail Pressure Sensor Circuit Performance. P0461 - Fuel Level Sensor 1 Performance. P0401 - EGR System Performance. P20EE - NOx Catalyst Efficiency Below Threshold. P061A - Level 2 Torque Performance. P061B - Internal Control Module Torque Calculation Performance. P061E - Internal Control Module Brake Signal Performance. P062C - Etc Level 2 MPH Performance. P0106 - Manifold Absolute Pressure Sensor Performance (In extreme cold ambient temperatures). P0116 - Engine Coolant Temperature Sensor Performance. P0420 - Catalyst System Efficiency Bank 1. P1507 - Crankcase Filter Restriction. P20E8 - (Diesel Exhaust Fluid) Reductant Pressure Too Low. P203F - (Diesel Exhaust Fluid) Reductant Level Too Low. P226C - Turbocharger Boost Control ?A? Slow Response (In extreme cold ambient temperatures). P2579 - Turbocharger Speed Sensor Circuit. U0101 - Lost Communication with TCM. U02A3 - Lost of Communication with PM Sensor. U3017 - Control Module Timer/Clock Performance.
18056222022-05-31. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); ELECTRICAL SYSTEM; ENGINE AND ENGINE COOLING; EQUIPMENT. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain ControlModule (ECM/PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or moreof the following DTCs have been set: P0506-00 - Idle Control System Rpm - Lower Than Expected. P0607-00 - ECU Internal Performance. P20E8-00 - Reductant Pressure Too Low. P0301-00 - Cylinder 1 Misfire(Sym Cam only). P0302-00 - Cylinder 2 Misfire(Sym Cam only). P0303-00 Cylinder 3 Misfire(Sym Cam only). P0304-00 - Cylinder 4 Misfire(Sym Cam only). P0305-00 - Cylinder 5 Misfire(Sym Cam only). P0306-00 - Cylinder 6 Misfire(Sym Cam only). P0299-00 - Turbocharger Underboost. P1D73-00 - AGS Performance. P0626 - Generator Field Control Circuit High. P218F - Reductant No Flow Detected. P2002 - Diesel Particulate Filter Efficiency Below Threshold. P24A5 - EGR Cooler Bypass Bank 1 Control Stuck. P0191 - Fuel Rail Pressure Sensor Circuit Performance. P0461 - Fuel Level Sensor 1 Performance. P0401 - EGR System Performance. P20EE - NOx Catalyst Efficiency Below Threshold. P061A - Level 2 Torque Performance. P061B - Internal Control Module Torque Calculation Performance. P061E - Internal Control Module Brake Signal Performance. P062C - Etc Level 2 MPH Performance. P0106 - Manifold Absolute Pressure Sensor Performance (In extreme cold ambienttemperatures). P0116 - Engine Coolant Temperature Sensor Performance. P0420 - Catalyst System Efficiency Bank 1. P1507 - Crankcase Filter Restriction. P20E8 - (Diesel Exhaust Fluid) Reductant Pressure Too Low. P203F - (Diesel Exhaust Fluid) Reductant Level Too Low. P226C - Turbocharger Boost Control ?A? Slow Response (In extreme cold ambienttemperatures). P2579 - Turbocharger Speed Sensor Circuit. U0101 - Lost Communication with TCM. U02A3 - Lost of Communication with PM Sensor. U3017 - Control Module Timer/Clock Performan
S1625000007 Rev.2021-03-15. Service bulletin. EXTERIOR LIGHTING; EQUIPMENT; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM). Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Code (DTC) P207F ? Reductant Quality Performance Set.
18-019-20 REV. A2020-10-26. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM). Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following DTCs have been set:P1D73-00 - AGS Performance. P0626 - Generator Field Control Circuit High. P218F - Reductant No Flow Detected. P2002 - Diesel Particulate Filter Efficiency Below Threshold. P24A5 - EGR Cooler Bypass Bank 1 Control Stuck. P0191 - Fuel Rail Pressure Sensor Circuit Performance. P0461 - Fuel Level Sensor 1 Performance. P0401 - EGR System Performance. P20EE - NOx Catalyst Efficiency Below Threshold. P061A - Level 2 Torque Performance. P061B - Internal Control Module Torque Calculation Performance. P061E - Internal Control Module Brake Signal Performance. P062C - Etc Level 2 MPH Performance. P0106 - Manifold Absolute Pressure Sensor Performance (In extreme cold ambient temperatures). P0116 - Engine Coolant Temperature Sensor Performance. P0420 - Catalyst System Efficiency Bank 1. P1507 - Crankcase Filter Restriction. P20E8 - (Diesel Exhaust Fluid) Reductant Pressure Too Low. P203F - (Diesel Exhaust Fluid) Reductant Level Too Low. P226C - Turbocharger Boost Control ?A? Slow Response (In extreme cold ambient temperatures). P2579 - Turbocharger Speed Sensor Circuit. U0101 - Lost Communication with TCM. U02A3 - Lost of Communication with PM Sensor. U3017 - Control Module Timer/Clock Performance. The customer may also notice one or more of the following:Oil life monitor resets after PCM flash. Diesel Exhaust Fluid (DEF) level gauge inaccurate. Message ?Regen in progress will take up to 70 Minutes? remains in Electronic Vehicle Information Center (EVIC) when aborting manual regeneration process. Excessive DEF consumption. Poor idle at times when engaging cab heat feature.
S20210000032020-06-22. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION; VEHICLE SPEED CONTROL; ENGINE. Check Engine Light Is On, Vehicle Speed May Be Limited, Shifting May Be Erratic
18-019-202020-05-26. Service bulletin. ELECTRICAL SYSTEM; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM). Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following DTCs have been set:P0626 - Generator Field Control Circuit High. P218F - Reductant No Flow Detected. P2002 - Diesel Particulate Filter Efficiency Below Threshold. P24A5 - EGR Cooler Bypass Bank 1 Control Stuck. P0191 - Fuel Rail Pressure Sensor Circuit Performance. P0461 - Fuel Level Sensor 1 Performance. P0401 - EGR System Performance. P20EE - NOx Catalyst Efficiency Below Threshold. P061A - Level 2 Torque Performance. P061B - Internal Control Module Torque Calculation Performance. P061E - Internal Control Module Brake Signal Performance. P062C - Etc Level 2 MPH Performance. P0106 - Manifold Absolute Pressure Sensor Performance (In extreme cold ambient temperatures). P0116 - Engine Coolant Temperature Sensor Performance. P0420 - Catalyst System Efficiency Bank 1. P1507 - Crankcase Filter Restriction. P20E8 - (Diesel Exhaust Fluid) Reductant Pressure Too Low. P203F - (Diesel Exhaust Fluid) Reductant Level Too Low. P226C - Turbocharger Boost Control ?A? Slow Response (In extreme cold ambient temperatures). P2579 - Turbocharger Speed Sensor Circuit. U0101 - Lost Communication with TCM. U02A3 - Lost of Communication with PM Sensor. U3017 - Control Module Timer/Clock Performance. The customer may also notice one or more of the following:Oil life monitor resets after PCM flash. Diesel Exhaust Fluid (DEF) level gauge inaccurate. Message ?Regen in progress will take up to 70 Minutes? remains in Electronic Vehicle Information Center (EVIC) when aborting manual regeneration process. Excessive DEF consumption. Poor idle at times when engaging cab heat feature. In addition, the following enhancements are included:wiTECH Fuel System R
18-019-202020-05-18. Service bulletin. POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); EQUIPMENT ADAPTIVE/MOBILITY. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following DTCs have been set:P0626 - Generator Field Control Circuit High. P218F - Reductant No Flow Detected. P2002 - Diesel Particulate Filter Efficiency Below Threshold. P24A5 - EGR Cooler Bypass Bank 1 Control Stuck. P0191 - Fuel Rail Pressure Sensor Circuit Performance. P0461 - Fuel Level Sensor 1 Performance. P0401 - EGR System Performance. P20EE - NOx Catalyst Efficiency Below Threshold. P061A - Level 2 Torque Performance. P061B - Internal Control Module Torque Calculation Performance. P061E - Internal Control Module Brake Signal Performance. P062C - Etc Level 2 MPH Performance. P0106 - Manifold Absolute Pressure Sensor Performance (In extreme cold ambient temperatures). P0116 - Engine Coolant Temperature Sensor Performance. P0420 - Catalyst System Efficiency Bank 1. P1507 - Crankcase Filter Restriction. P20E8 - (Diesel Exhaust Fluid) Reductant Pressure Too Low. P203F - (Diesel Exhaust Fluid) Reductant Level Too Low. P226C - Turbocharger Boost Control ?A? Slow Response (In extreme cold ambient temperatures). P2579 - Turbocharger Speed Sensor Circuit. U0101 - Lost Communication with TCM. U02A3 - Lost of Communication with PM Sensor. U3017 - Control Module Timer/Clock Performance. The customer may also notice one or more of the following:Oil life monitor resets after PCM flash. Diesel Exhaust Fluid (DEF) level gauge inaccurate. Message ?Regen in progress will take up to 70 Minutes? remains in Electronic Vehicle Information Center (EVIC) when aborting manual regeneration process. Excessive DEF consumption. Poor idle at times when engaging cab heat feature. In addition, the following enhancements are included:wiTECH Fuel System R
18-019-202020-04-27. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); POWER TRAIN. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following DTCs have been set:P0626 - Generator Field Control Circuit High. P218F - Reductant No Flow Detected. P2002 - Diesel Particulate Filter Efficiency Below Threshold. P24A5 - EGR Cooler Bypass Bank 1 Control Stuck. P0191 - Fuel Rail Pressure Sensor Circuit Performance. P0461 - Fuel Level Sensor 1 Performance. P0401 - EGR System Performance. P20EE - NOx Catalyst Efficiency Below Threshold. P061A - Level 2 Torque Performance. P061B - Internal Control Module Torque Calculation Performance. P061E - Internal Control Module Brake Signal Performance. P062C - Etc Level 2 MPH Performance. P0106 - Manifold Absolute Pressure Sensor Performance (In extreme cold ambient temperatures). P0116 - Engine Coolant Temperature Sensor Performance. P0420 - Catalyst System Efficiency Bank 1. P1507 - Crankcase Filter Restriction. P20E8 - (Diesel Exhaust Fluid) Reductant Pressure Too Low. P203F - (Diesel Exhaust Fluid) Reductant Level Too Low. P226C - Turbocharger Boost Control ?A? Slow Response (In extreme cold ambient temperatures). P2579 - Turbocharger Speed Sensor Circuit. U0101 - Lost Communication with TCM. U02A3 - Lost of Communication with PM Sensor. U3017 - Control Module Timer/Clock Performance. The customer may also notice one or more of the following:Oil life monitor resets after PCM flash. Diesel Exhaust Fluid (DEF) level gauge inaccurate. Message ?Regen in progress will take up to 70 Minutes? remains in Electronic Vehicle Information Center (EVIC) when aborting manual regeneration process. Excessive DEF consumption. Poor idle at times when engaging cab heat feature. In addition, the following enhancements are included:wiTECH Fuel System R

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.