WenmarOpen by Wenmar Pro

Service bulletins for the 2016 Ram 4500

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

384 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Only bulletins with component: Electrical system are shown. Show all

Bulletins, newest first
90044702022-09-26. Service bulletin. TRAILER HITCHES; ELECTRICAL SYSTEM:WIRING. CONNECTOR/WIRING, Trailer Tow If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 15 minutes, proceed with repair. Please send pictures of the failed part to FCA Redacted Content
S21080001442022-09-26. Service bulletin. ELECTRICAL SYSTEM:STARTER ASSEMBLY. No Start, No Crank
90043862022-09-26. Service bulletin. ELECTRICAL SYSTEM:WIRING. WIRING, Body Before replacing this harness, please contact FCA Redacted Content to see if a repair kit is available for your application. If no response in 15 minutes, proceed with repair. Please email pictures of harness defects to FCA Redacted Content
S20080001132022-09-26. Service bulletin. ELECTRICAL SYSTEM. No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle, Intermittent Key Not Detected Message
S16080002262022-09-26. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. Battery Tester Warranty Code Procedures, Midtronics Charger Update Process
S160800022612022-09-26. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. Battery Tester Warranty Code Procedures, Medtronic Update Process
21017192022-09-15. Service bulletin. FUEL SYSTEM, GASOLINE; AIR BAGS; POWER TRAIN; ELECTRICAL SYSTEM; FUEL SYSTEM, DIESEL; EXTERIOR LIGHTING; BACK OVER PREVENTION. Flash: Transmission Control Module (TCM) Updates This bulletin involves reprogramming the TCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the followingDTC has been set:U1111-00 - Lost Odometer Message(DD, DF, and DP with Diesel Engine Only). In addition, the customer may notice one or more of the following conditions: The customer may notice a harsh 2-3 and/or 3-4 shift(2017 MY D2 with ETK 6.7L Diesel and DF2 Transmission Only). 1-2 hard shift. 3-4 flare issue fix. Trans quick learn fix(Gas Engine Only). Transmission oil temperature light illumination during high engine and tow loads. Less than desired towing performance while using cruise control. Harsh engagement while shifting from neutral to drive, neutral to reverse,or park to reverse with vehicle still in motion (rolling garage shift). Engine flare during 2-1 tip in downshift. Less than desired shift quality during 6-5 and 5-4 coasting downshifts. Delayed downshifts in Tow/Haul mode while driving down grades. Less than desired transmission shift performance when transitioning froma low traction to high traction surfaces i.e. ice covered road to clear pavement. Less than desired shift points during light pedal and Wide Open Throttle(WOT) operation or while in Tow/Haul and engine brake modes. 1-2 upshift shudder correction(Diesel engine and DF2 Transmission Only). A harsh 1-2 upshift(DF2 Transmission Only). Excessive gear shifting(DF2 Transmission Only). Harsh 2-1 downshift(DF2 Transmission Only). Delayed engagement when shifting from neutral to drive, neutral to reverse,or park to reverse (garage shifts)(DF2 Transmission Only). Audible squawk noise on 4-3 downshift(DF2 Transmission Only). Poor vehicle acceleration in first gear with vehicle fully loaded(DF2 Transmission Only). MIL illumination with no defect found forDTC P253D - PTO Sense Circuit High(DF2 Transmission Only).
08111192022-09-15. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT. RA3 and RA4 GPS Radio Update This bulletin involves updating the radio software. 18.01.35 (BU Vehicles)
D19252022-09-15. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. RRT 19-090 (Service Bulletin 08-111-19) 2013-2018 Multiple Vehicles RA3/RA4 Radio GPS Certification Error
25-003-17 REV. A2022-09-15. Service bulletin. ELECTRICAL SYSTEM. Flash: Dosing Control Unit (DCU) Diagnostic and System Improvements This bulletin involves reprogramming the DCU with the latest available software and if necessary replacing the unit. Some customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation, a technician may find the following Diagnostic Trouble Codes (DTCs):P207F - Reductant Quality Performance. P202C - Reductant Tank Heater Control Circuit High. P203B - Reductant Level Sensor 1 Circuit Performance.
08-008-17 REV. A2022-09-15. Service bulletin. ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM. Flash: BCM Diagnostic and System Improvements This bulletin involves reprogramming the Body Control Module (BCM) with the latest available software. The customer may describe the headlamps flicker while operating at night. This condition may be more prevalent after the bulb(s) have been replaced with an aftermarket bulb.
08-057-162022-08-22. Service bulletin. ELECTRICAL SYSTEM. RA3 RA4 Radio Enhancements This bulletin involves inspecting and, if required, updating the radio software. A small number of customers may experience one or more of the following: · Navigation failed message is displayed. · Clock not automatically updating to local time. · Poor or no connection to cellular network. · HVAC temperature out of sync with radio display (KL vehicles). · Display goes blank/black. · Radio locks up. · Some Uconnect App remote commands do not execute with the vehicle.
Z5091195A2022-08-22. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM; EQUIPMENT:ELECTRICAL. RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). The Telematics Module (and associated components) is the system responsible for these features. A power cycle may be required for the hands-free module for proper diagnosis.~ Please reference; 8T - Navigation/Telecommunication Diagnosis and Testing (DIAGNOSIS AND TESTING - HANDS FREE PHONE)
68066351A2022-08-22. Service bulletin. ELECTRICAL SYSTEM. Keyfob 2016 Vehicle Keyfobs with Passive Entry Keyless Go Feature - Engineering is investigating a keyfob unable to program or no function or low keyfob coin battery condition.~ Prior to replacing keyfob on MY16 vehicles, please contact Raja Charabuddi on cell (248) 202-7313. If no response within 15 minutes, proceed with repair.
05013152022-08-22. Service bulletin. PARKING BRAKE:ELECTRICAL:CONTROL MODULE:SOFTWARE; SEAT BELTS; ELECTRICAL SYSTEM. Anti Lock Brake (ABS) Module System Enhancements.
90030592022-08-08. Service bulletin. BACK OVER PREVENTION; ELECTRICAL SYSTEM. Park Assist Sensor 1) Active or Stored DTC of Signal Shape / Waveform Failure fault: B128E-25, B128F-25, B1290-25, B1291-25, B1292-25, B1293-25, B1295-25, B1296-25, B1297-25, and/or B1298-25, check for snow/mud/ice/obstruction and clean the Sensors, both front and back (behind bumper) of sensor. The snow/mud/ice can be behind the bumper, sensor retainer and/or the sensor which may cause customers to think they have an issue since they cleaned the front of the sensor/bumper, but not behind where dirt/mud/ice snow can accumulate. Once the Bumper and Sensors are completely cleaned and clear of snow, mud, ice, and/or obstruction, the sensors must activate in order for the faults to go STORED. After cleaning the Bumper and Sensors, turn off the engine, wait 10 seconds, turn on the engine and then place the vehicle in REVERSE so that the sensors activate. The faults will go STORED. 2) Active or Stored DTC code of Short to Ground fault: B128E-11, B128F-11, B1290-11, B1291-11, B1292-11, B1293-11, B1294-11, B1295-11, B1296-11, and/or B1298-11, or if you have an active or stored DTC code of Performance or Incorrect Operation fault: B128E-92, B128F-92, B1290-92, B1291-92, B1293-92, B1294-92, B1295-92, B1296-92, B1297-92, and/or B1298-92, then check the wiring behind the sensor. Specifically, ensure that the connector behind the park assist sensor is fully mounted. Ensure also, there is no dirt, corrosion, or damage in this connector behind the park assist sensor as this will also cause a Short to Ground fault. With potential wiring issues addressed, the sensors must activate in order for the faults to go STORED. After all sensors are properly connected (you will likely hear a click once the connector is fully seated on the sensor), turn off the engine, wait 10 seconds, turn on the engine and then place the vehicle in REVERSE so that the sensors activate. The faults will go STORED.
18-092-172022-08-08. Service bulletin. SERVICE BRAKES, HYDRAULIC; BACK OVER PREVENTION; ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE; ELECTRICAL SYSTEM; POWER TRAIN; EXTERIOR LIGHTING; ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM); FUEL SYSTEM, GASOLINE. Flash: 6.7L Diagnostic and System Improvements This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. The following Diagnostic Trouble Codes (DTCs) have been changed from a one trip fault to a two trip fault:P2280 - Air Flow Restriction / Leak Between Air Cleaner and MAF. P203C - (Diesel Exhaust Fluid) Reductant Level Sensor Circuit Low. P208D - (Diesel Exhaust Fluid) Reductant Pump Control Circuit High. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation a technician may find the following DTCs set in the PCM memory:P218F - Reductant No Flow Detected(automatic transmission only). P202E - (Diesel Exhaust Fluid) Reductant Injector Performance(automatic transmission only). U0001-00 - CAN C BUS(automatic transmission only). P1C55 - NOx Sensor Intermittent - Bank 1 Sensor 1(automatic transmission only). P24A5 - EGR Cooler Bypass Bank 1 Control Stuck(automatic transmission only). P207F - Reductant Quality Performance. P218F - Reductant No Flow Detected. U110E - Lost Ambient Temperature Message. The following improvements/enhancements are also included in this software release:Fuel pressure override test improvement for wiTECH(automatic transmission only). AC pressure sensor error threshold change(automatic transmission only). No crank, No start fix(automatic transmission only). Ambient Air Temperature Improvements. Stationary de-soot with WiTECH fix.
90035852022-08-08. Service bulletin. ELECTRICAL SYSTEM. Intake Grid Heater, Grid Heater Relay 2012 - 2016 6.7L Cummins engines with Intake Heater issues or DTC P2609 and P0542, please replace the Intake Heater Grid and Relay as a set. 68210071A$ (heater grid) and 05187880A$ (relay). Inspect electrical cable between the heater grid and relay for signs of possible overheating. Replace cable as necessary.
18-092-172022-07-25. Service bulletin. ENGINE AND ENGINE COOLING; POWER TRAIN; POWER TRAIN:MANUAL TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); ELECTRICAL SYSTEM; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); EQUIPMENT. Flash: 6.7L Diagnostic and System Improvements This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. The following Diagnostic Trouble Codes (DTCs) have been changed from a one trip fault to a two trip fault:P2280 - Air Flow Restriction / Leak Between Air Cleaner and MAF. P203C - (Diesel Exhaust Fluid) Reductant Level Sensor Circuit Low. P208D - (Diesel Exhaust Fluid) Reductant Pump Control Circuit High. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation a technician may find the following DTCs set in the PCM memory:P218F - Reductant No Flow Detected(automatic transmission only). P202E - (Diesel Exhaust Fluid) Reductant Injector Performance(automatic transmission only). U0001-00 - CAN C BUS(automatic transmission only). P1C55 - NOx Sensor Intermittent - Bank 1 Sensor 1(automatic transmission only). P24A5 - EGR Cooler Bypass Bank 1 Control Stuck(automatic transmission only). P207F - Reductant Quality Performance. P218F - Reductant No Flow Detected. U110E - Lost Ambient Temperature Message. The following improvements/enhancements are also included in this software release:Fuel pressure override test improvement for wiTECH(automatic transmission only). AC pressure sensor error threshold change(automatic transmission only). No crank, No start fix(automatic transmission only). Ambient Air Temperature Improvements. Stationary de-soot with WiTECH fix.
90035852022-07-25. Service bulletin. VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE; ELECTRICAL SYSTEM. Intake Grid Heater, Grid Heater Relay 2012 - 2016 6.7L Cummins engines with Intake Heater issues or DTC P2609 and P0542, please replace the Intake Heater Grid and Relay as a set. 68210071A$ (heater grid) and 05187880A$ (relay). Inspect electrical cable between the heater grid and relay for signs of possible overheating. Replace cable as necessary.
90044702022-06-27. Service bulletin. ELECTRICAL SYSTEM:WIRING; TRAILER HITCHES. CONNECTOR/WIRING, Trailer Tow If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 15 minutes, proceed with repair. Please send pictures of the failed part to FCA Redacted Content
68054772A2021-05-03. Service bulletin. ELECTRICAL SYSTEM. Cable assembly. Power sliding backlite.
S1908000028 Rev.2020-12-28. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT. (Rev. A) Power Inverter Load Ratings
S1908000028 Rev.2020-12-21. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY. (Rev. A) Power Inverter Load Ratings
08-094-202020-11-30. Service bulletin. ELECTRICAL SYSTEM; POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE); EQUIPMENT. Flash: Drivetrain Control Module (DTCM) Update This bulletin involves reprogramming the DTCM with the latest available software. The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Code (DTC) has been set::If the customer has any concerns with the transfer case or if the tech performs any repairs on the transfer case, the software must be updated.C140E - Transfer Case Motor Blocked. If DTC C140E is present, follow normal diagnostic procedures before updating the DTCM.In addition the customer may describe the following:The ?Service 4WD? message/fault is displayed in the Instrument Panel Cluster (IPC). Transfer case shift fork tabs broken during range shift. Noisy (clunking/ratcheting) transfer case range shifts. Failure to complete transfer case range shifts. The following software enhancement is available:This update will help reduce premature transfer case failure.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.