Service bulletins for the 2023 Kia K5
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
68 on file from NHTSA, as of 2026-10-19.
By type
By component
By trouble code
By topic
Only bulletins with component: Fuel system are shown. Show all
| SC288_TSB_R6_CLSD | 2026-01-28. Emissions. ELECTRICAL SYSTEM; FUEL/PROPULSION SYSTEM. TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: FUEL TANK AND/OR PCSV CHECK VALVE INSPECTION/REPLACEMENT + ECU SW UPGRADE (SC288/SC288A) CLOSED & SUPERSEDED - This bulletin is now closed and superseded by SC356. This bulletin provided information to inspect the fuel evaporative system and, if necessary, replace the fuel tank and/or the Purge Control Solenoid Valve (PCSV) check valve on certain 2021-2024MY K5 (DL3a) vehicles equipped with a Gamma II 1.6L T-GDI engine, produced from March 27, 2020 through January 23, 2024. This bulletin also provides information to upgrade the ECU software logic. The subject vehicles may experience fuel tank swelling due to an issue with the PCSV check valve, which results in pressurized air to flow into the fuel tank. This may cause the Check Engine Light to illuminate, and in some cases, the engine to run rough, and/or an inability to refuel. These conditions may cause the vehicle to release air pollutant which exceed Federal and California standards. |
|---|---|
| SC288_OWNR_301 | 2025-10-17. Emissions. ELECTRICAL SYSTEM; FUEL/PROPULSION SYSTEM. VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER RENOTIFICATION (SC288 FLIGHT 301) - This document is the owner renotification advising that Kia is conducting a Voluntary Emissions Service Campaign on certain 2021-2024 MY K5 vehicles equipped with 1.6L Turbo Gas Direct Injection (GDI) engines to improve the logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations. Also, the subject vehicles will be inspected and, if necessary, the fuel tank and/or the Purge Control Solenoid Valve (PCSV) check valve will be replaced with a new one. |
| SC288A_OWNR | 2025-07-23. Emissions. FUEL/PROPULSION SYSTEM; ELECTRICAL SYSTEM. VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION (SC288A) - This document is the owner notification advising that Kia is conducting a Voluntary Emissions Service Campaign on certain 2021-2024 MY K5 vehicles equipped with 1.6L Turbo Gas Direct Injection (GDI) engines to improve the logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations. Also, the subject vehicles will be inspected and, if necessary, the fuel tank and/or the Purge Control Solenoid Valve (PCSV) check valve will be replaced with a new one. |
| TSB_FUE069_CLSD | 2025-07-01. Service bulletin. FUEL/PROPULSION SYSTEM. TECHNICAL SERVICE BULLETIN: SERVICE ACTION: PARTS COLLECTION SERVICE ACTION: PCSV REPLACEMENT (SA612) CLOSED - This bulletin is now closed. This bulletin provided information to replace Purge Control Solenoid Valve (PCSV) on certain 2021-2024MY K5 (DL3a) vehicles equipped with a Gamma II 1.6L T-GDI engine, produced from March 27, 2020 through October 11, 2023. This is a special, limited-time parts collection program for research purposes. Dealers are to ship the removed PCSV assembly to KUS via the Mandatory Parts Request (MPR). |
| SC288_OWNR_103 | 2025-06-24. Emissions. FUEL/PROPULSION SYSTEM; ELECTRICAL SYSTEM. VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION (SC288) - This document is the owner notification advising that Kia is conducting a Voluntary Emissions Service Campaign on certain 2021-2024 MY K5 vehicles equipped with 1.6L Turbo Gas Direct Injection (GDI) engines to improve the logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations. Also, the subject vehicles will be inspected and, if necessary, the fuel tank and/or the Purge Control Solenoid Valve (PCSV) check valve will be replaced with a new one. |
| SC288_TSB_R6 | 2025-06-19. Emissions. ELECTRICAL SYSTEM; FUEL/PROPULSION SYSTEM. VOLUNTARY EMISSIONS SERVICE CAMPAIGN: FUEL TANK AND/OR PCSV CHECK VALVE INSPECTION/ REPLACEMENT + ECU SW UPGRADE (SC288/SC288A) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to inspect the fuel evaporative system and, if necessary, replace the fuel tank and/or the Purge Control Solenoid Valve (PCSV) check valve on certain 2021-2024MY K5 (DL3a) vehicles equipped with a Gamma II 1.6L T-GDI engine, produced from March 27, 2020 through January 23, 2024. This bulletin also provides information to upgrade the ECU software logic. This bulletin provides information to inspect the fuel evaporative system and, if necessary, replace the fuel tank and/or the Purge Control Solenoid Valve (PCSV) check valve on certain 2021-2024MY K5 (DL3a) vehicles equipped with a Gamma II 1.6L T-GDI engine, produced from March 27, 2020 through January 23, 2024. This bulletin also provides information to upgrade the ECU software logic. |
| TSB_FUE069 | 2025-05-21. Service bulletin. FUEL/PROPULSION SYSTEM. TECHNICAL SERVICE BULLETIN: TECHNICAL SERVICE BULLETIN: PARTS COLLECTION SERVICE ACTION: PCSV REPLACEMENT (SA612) - This bulletin provides information to replace Purge Control Solenoid Valve (PCSV) on certain 2021-2024MY K5 (DL3a) vehicles equipped with a Gamma II 1.6L T-GDI engine, produced from March 27, 2020 through October 11, 2023. This is a special limited time parts collection program for research purposes. Dealers are to ship the removed PCSV assembly to KUS via the Mandatory Parts Request (MPR). |
| SC288_TSB_R5 | 2025-03-26. Service bulletin. FUEL/PROPULSION SYSTEM. TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN FUEL TANK AND/OR PCSV CHECK VALVE INSPECTION/REPLACEMENT + ECU SW UPGRADE (SC288) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to inspect the fuel evaporative system and, if necessary, replace the fuel tank and/or the Purge Control Solenoid Valve (PCSV) check valve on certain 2021-2024MY K5 (DL3a) vehicles equipped with a Gamma II 1.6L T-GDI engine, produced from March 27, 2020 through October 17, 2023. This bulletin also provides information to upgrade the ECU software logic. The subject vehicles may experience fuel tank swelling due to an issue with the PCSV check valve, which results in pressurized air to flow into the fuel tank. This may cause the Check Engine Light to illuminate, and in some cases, the engine to run rough, and/or an inability to refuel. These conditions may cause the vehicle to release air pollutant which exceed Federal and California standards. |
| SC288_TSB_R4 | 2024-10-30. Service bulletin. FUEL/PROPULSION SYSTEM. TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: FUEL TANK AND/OR PCSV CHECK VALVE INSPECTION/REPLACEMENT + ECU SW UPGRADE (SC288) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to inspect the fuel evaporative system and, if necessary, replace the fuel tank and/or the Purge Control Solenoid Valve (PCSV) check valve on certain 2021-2024MY K5 (DL3a) vehicles equipped with a Gamma II 1.6L T-GDI engine, produced from March 27, 2020 through October 17, 2023. This bulletin also provides information to upgrade the ECU software logic. The subject vehicles may experience fuel tank swelling due to an issue with the PCSV check valve, which results in pressurized air to flow into the fuel tank. This may cause the Check Engine Light to illuminate, and in some cases, the engine to run rough, and/or an inability to refuel. These conditions may cause the vehicle to release air pollutant which exceed Federal and California standards. |
| SC288_TSB_R3 | 2024-10-18. Emissions. FUEL/PROPULSION SYSTEM. VOLUNTARY EMISSIONS SERVICE CAMPAIGN: FUEL TANK AND/OR PCSV CHECK VALVE INSPECTION/REPLACEMENT + ECU SW UPGRADE (SC288) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to inspect the fuel evaporative system and, if necessary, replace the fuel tank and/or the Purge Control Solenoid Valve (PCSV) check valve on certain 2021-2024MY K5 (DL3a) vehicles equipped with a Gamma II 1.6L T-GDI engine, produced from March 27, 2020 through October 17, 2023. This bulletin also provides information to upgrade the ECU software logic. The subject vehicles may experience fuel tank swelling due to an issue with the PCSV check valve, which results in pressurized air to flow into the fuel tank. This may cause the Check Engine Light to illuminate, and in some cases, the engine to run rough, and/or an inability to refuel. These conditions may cause the vehicle to release air pollutant which exceed Federal and California standards. |
| SC288_TSB_R2 | 2024-07-31. Emissions. FUEL/PROPULSION SYSTEM; ELECTRICAL SYSTEM. TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: FUEL TANK AND/OR PCSV CHECK VALVE INSPECTION/REPLACEMENT + ECU SW UPGRADE (SC288) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to inspect the fuel evaporative system and, if necessary, replace the fuel tank and/or the Purge Control Solenoid Valve (PCSV) check valve on certain 2021-2024MY K5 (DL3a) vehicles equipped with a Gamma II 1.6L T-GDI engine, produced from March 27, 2020 through October 17, 2023. This bulletin also provides information to upgrade the ECU software logic. |
| SC288_OWNR_F201 | 2024-07-11. Service campaign. ELECTRICAL SYSTEM; FUEL/PROPULSION SYSTEM. VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER RENOTIFICATION (SC288) - This document is the owner renotification advising that Kia is conducting a Voluntary Emissions Service Campaign on certain 2021-2024 MY K5 vehicles equipped with 1.6L Turbo Gas Direct Injection (GDI) engines to improve the logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations. Also, the subject vehicles will be inspected and, if necessary, the fuel tank and/or the Purge Control Solenoid Valve (PCSV) check valve will be replaced with a new one. |
| TSB_SC288_R1 | 2024-05-23. Emissions. FUEL/PROPULSION SYSTEM. TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: FUEL TANK AND/OR PCSV CHECK VALVE INSPECTION/REPLACEMENT + ECU SW UPGRADE (SC288) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to inspect the fuel evaporative system and, if necessary, replace the fuel tank and/or the Purge Control Solenoid Valve (PCSV) check valve on certain 2021-2024MY K5 (DL3a) vehicles equipped with a Gamma II 1.6L T-GDI engine, produced from March 27, 2020 through October 17, 2023. This bulletin also provides information to upgrade the ECU software logic. |
| SC288_TSB | 2024-05-06. Service bulletin. ENGINE AND ENGINE COOLING; FUEL SYSTEM, GASOLINE; ELECTRICAL SYSTEM. TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: FUEL TANK AND/OR PCSV CHECK VALVE INSPECTION/REPLACEMENT + ECU SW UPGRADE (SC288) - This bulletin provides information to inspect the fuel evaporative system and, if necessary, replace the fuel tank and/or the Purge Control Solenoid Valve (PCSV) check valve on certain 2021-2024MY K5 (DL3a) vehicles equipped with a Gamma II 1.6L T-GDI engine, produced from March 27, 2020 through October 17, 2023. This bulletin also provides information to upgrade the ECU software logic. |
| SC288_STKR | 2024-05-06. Service bulletin. ENGINE AND ENGINE COOLING; ELECTRICAL SYSTEM; FUEL SYSTEM, GASOLINE. SC288_STKR: VOLUNTARY EMISSIONS SERVICE CAMPAIGN COMPLETION STICKER |
| SC288_QA | 2024-05-06. Service bulletin. ELECTRICAL SYSTEM; FUEL SYSTEM, GASOLINE; ENGINE AND ENGINE COOLING. VOLUNTARY EMISSIONS SERVICE CAMPAIGN: QUESTION AND ANSWER (SC288) - This document is the Question and Answer Guide containing the most frequently asked questions regarding the Voluntary Emissions Service Campaign SC288. |
| SC288_POC | 2024-05-06. Service bulletin. FUEL SYSTEM, GASOLINE; ENGINE AND ENGINE COOLING; ELECTRICAL SYSTEM. SC288_POC: PROOF OF CORRECTION CARD |
| SC288_OWNR | 2024-05-06. Service bulletin. FUEL SYSTEM, GASOLINE; ELECTRICAL SYSTEM; ENGINE AND ENGINE COOLING. VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION (SC288) - This document is the owner notification advising that Kia is conducting a Voluntary Emissions Service Campaign on certain 2021-2024 MY K5 vehicles equipped with 1.6L Turbo Gas Direct Injection (GDI) engines to improve the logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations. Also, the subject vehicles will be inspected and, if necessary, the fuel tank and/or the Purge Control Solenoid Valve (PCSV) check valve will be replaced with a new one. |
| SC288_DPSM | 2024-05-06. Service bulletin. ELECTRICAL SYSTEM; FUEL SYSTEM, GASOLINE; ENGINE AND ENGINE COOLING. VOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PARTS AND SERVICE MANAGER MEMO (SC288) - This document is the announcement to the dealer Parts and Service Managers that Kia is conducting a Voluntary Emissions Service Campaign on certain 2021-2024 MY K5 vehicles equipped with 1.6L Turbo Gas Direct Injection (GDI) engines manufactured from March 27, 2020 through October 17, 2023 to improve the logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations. Also, the subject vehicles will be inspected and, if necessary, the fuel tank and/or the Purge Control Solenoid Valve (PCSV) check valve will be replaced with a new one. |
| SC288_DP | 2024-05-06. Service bulletin. ENGINE AND ENGINE COOLING; FUEL SYSTEM, GASOLINE; ELECTRICAL SYSTEM. PRODUCT IMPROVEMENT CAMPAIGN: DEALER PRINCIPAL MEMO (SC288) - This document is the announcement to the dealer principals that Kia is conducting a Voluntary Emissions Service Campaign on certain 2021-2024 MY K5 vehicles equipped with 1.6L Turbo Gas Direct Injection (GDI) engines manufactured from March 27, 2020 through October 17, 2023 to improve the logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations. Also, the subject vehicles will be inspected and, if necessary, the fuel tank and/or the Purge Control Solenoid Valve (PCSV) check valve will be replaced with a new one. |
| TSB_ENG239_R1 | 2023-04-28. Service bulletin. ELECTRICAL SYSTEM; FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY. TECHNICAL SERVICE BULLETIN: DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC23) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to extracting "in use performance tracking" emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The California Air Resources Board (CARB) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting. To facilitate collection of this data at the dealer level, KDS screenshots will allow the capture of relevant parameters. |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.