Service bulletins for the 2016 Jeep Wrangler
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
195 on file from NHTSA, as of 2026-10-19.
By type
By component
By trouble code
| 9003699 | 2018-06-11. Service bulletin. SEATS. Heated Seat Elements; Cushion and Back DEALERCONNECT HEATED ELEMENT RESISTANCE INFO OUT IS OF SPEC. Prior to ordering any of the parts (55057300A$, 55057293A$, 55057301A$, 55057294A$) Please contact Micah Straub at cell phone# 248-613-2478 for further instructions. Leave a voice mail and your call will be returned promptly. 5.1 to 7.8 is the correct resistance value although ambient temperature will affect this value. Please call for detailed information. If no return call in 15 minutes, proceed with repair. |
|---|---|
| 9003696 | 2018-06-11. Service bulletin. STRUCTURE:BODY:DOOR. Door Hinge Assembly Side door hinge noisy. Only replace the door hinge with the integral check device. Do not replace the simple hinge if it is not damaged it is not the source of the noise. Replacing it unnecessary and is an over-repair. |
| 9003694 | 2018-06-11. Service bulletin. ENGINE AND ENGINE COOLING. Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 bob.jackson@fcagroup.com, or Joe Lovell (734) 309-6467 joe.lovell@fcagroup.com before proceeding. If unable to reach after 15 minutes record the following information and proceed with oil pump replacement and hold part for return to FCA via Fastrack system |
| 9003681 | 2018-06-11. Service bulletin. SEAT BELTS. Restraints Information Sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use. |
| 9003688 | 2018-06-11. Service bulletin. STRUCTURE. Header Weatherstrip, Center Targa Top Seal, Right Door Mounted Weatherstrip Water leak from the Freedom Panels at the rearview mirror/drops down on the instrument panel/radio area OR Water leak at the right front A pillar/on the passenger's side floor, please contact Kayla Branton at cell (248) 224-8272. If no response in 15 minutes, please proceed with repair |
| 9003687 | 2018-06-11. Service bulletin. SEAT BELTS. Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use. |
| 68277402A | 2018-06-11. Service bulletin. VEHICLE SPEED CONTROL:CRUISE CONTROL. Adaptive Cruise Control Sensor 1) If you are replacing this part due to the cluster displaying Clean Radar Sensor in Front of Vehicle or DTC C1266 ACC Sensor Blinded, please verify that there is no blockage in front of the sensor. Blockage can occur from mud, ice, snow, front end damage, bracket damage, the sensor not attached to the bracket properly or an aftermarket fascia installed. This fault can occur intermittently in muddy or icy/snowy conditions and is considered normal operation. Under some circumstances, a misaligned sensor can also cause the C1266 DTC, please complete an alignment procedure. No replacement is required.~ 2) If you are replacing this part due to the cluster displaying ?ACC/FCW Unavailable Service Required?, please check the DTC fault codes. This will indicate which module needs to be serviced (TCM, PCM, ESP/ABS, etc). This fault is not due to the ACC Sensor. No sensor replacement is required.~ 3) If you have fault code DTC C125E ACC Sensor Adjustment Required, please verify that the radar sensor is fully seated in the clips and there is no damage (if clips are damaged on a 2013 or earlier vehicle, order P/N 68085813A$, otherwise please replace the module), please verify there is no blockage to the sensor due to mud, ice, snow, front end damage, bracket damage or the sensor not attached to the bracket properly. Perform the Vertical Alignment and the Electronic Horizontal Alignments procedure as stated in the service manual. Please note, if the horizontal alignment procedure will not complete, check the vertical alignment and confirm that the sensor is seated properly. Rerun the horizontal alignment procedure. No sensor replacement is required. **Hints for running Horizontal Alignment procedure: A) Verify speed is between 45 and 75 mph, B) verify the road is relatively straight with signs, poles, guard rails, etc C) Do not tail a vehicle too closely this inhibits the learning procedure |
| RL305553A | 2018-06-11. Service bulletin. POWER TRAIN. 9-spd Transmission: FOR NAFTA Market Only: If you are ordering this transmission please follow all wiTECH pop ups and Warranty Payment Guidelines. If this vehicle contains 1 of the 30 Diagnostic Codes in the 9 Speed Tutorial located on the Service Home Page then please follow the repair steps and submit a Topology report as well as a Vehicle Scan Report with the Warranty Claim.~ |
| 68065575A | 2018-06-11. Service bulletin. FUEL SYSTEM, GASOLINE. Fuel Pump: JK ONLY: If a customer has a P0461 fault code (Fuel level sensor 1 performance) please take a picture of the fuel module orientation / alignment to the fuel tank flange as it is received. Send the picture to Bob.Bruni@fcagroup.com. Upon module removal inspect and determine if the float travel has been hampered by contact with the tank walls or internal line. Engineering is trying to determine if misoriented module will illuminate a P0461 FC. Please include the VIN with the picture.~ |
| 05184546A | 2018-06-11. Service bulletin. ENGINE AND ENGINE COOLING. 3.6L Oil Pan Drain Plug and Pan: When an oil pan leak is detected and the oil drain plug is loose please on JK/KL models call one of the following people. If your call in not answered within 15 minutes please proceed with the repair. First: Joe Lovell Cell (734) 309-6467 - joe.lovell@fcagroup.com Second: Scott Kucharek Cell (248) 260-0725 - scott.kucharek@fcagroup.com Third: Jermanjit Dhillon Cell (248) 260-0725 - jermanjit.dhillon@fcagroup.com |
| 23-029-17 | 2018-06-04. Service bulletin. SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER. Dimpled Driver Side Front Leather Heated Seat This bulletin involves inspecting and installing heater element patches and replacing seat cushion cover, on the driver?s front seat.The customer may describe, the driver?s front leather seat has dimples in the seat bottom. The dimples are caused by openings in the heated seat element, seeFig. 1.Dimple Location On Leather Seats1 - Dimples |
| 23-028-17 | 2018-06-04. Service bulletin. SEATS. Squeaking Noise Below The Front Seat While Turning and Going Over Bumps This bulletin involves replacing the bolt and bushing on driver and passenger side seat slide mechanism to resolve a squeaking issue (Two door models only). The customer may describe a squeak heard under the front passenger or driver side seat, while turning or driving over bumps. |
| S80 | 2018-06-04. Service bulletin. POWER TRAIN:AXLE ASSEMBLY. Customer Satisfaction Notification S80 Aftermarket Dana 60 Front Axle The aftermarket front axle steering knuckles have been machined with an incorrect taper during the manufacturing process on about 250 of the above vehicles, with approximately 80 of the axles sold by Mopar aftermarket. This condition can result in premature axle knuckle wear. The aftermarket front axle knuckles must be replaced with new axle knuckles for the left side and right side. |
| 9003357 | 2018-06-04. Service bulletin. ENGINE AND ENGINE COOLING. Pentastar Oil Filter Adapter All vehicles equipped with a 3.2L or 3.6L engine; If replacing the Oil Filter Adapter (OFA) due to a leak detected between OFA and block, an O-ring kit (68191356AA) is now available to repair OFA/Block Interface leaks. Using dye will assist in determining source of leak. Ensure OFA Cap Oring is seated in the proper groove in the cap and not damaged or cut. Engineering is seeking information regarding OFA leaks. Questions/info can be directed to: Bob Jackson Cell (248) 944-0466 - bob.jackson@fcagroup.com Ron Dallison Cell (248-292-9510) ron.dallison@fcagroup.com Joe Lovell Cell (734) 309-6467 - joe.lovell@fcagroup.com If a response is not received within 15 mins, then proceed with the necessary repair. |
| 9003413 | 2018-06-04. Service bulletin. VEHICLE SPEED CONTROL:ACCELERATOR PEDAL. Accelerator Pedal Before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. Make sure to check wiring and connectors. P2122 and P2127 will set if accelerator pedal connector is disconnected during diagnosis. Make sure codes are active before replacing pedal. DTC P2299 is usually caused by a two footed driver and accelerator pedal should not be replaced for this fault. |
| 9003109 | 2018-06-04. Service bulletin. VISIBILITY:WINDSHIELD WIPER/WASHER. Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the bottle anti-rotation features that surround the SENSOR. Check to determine if the issue has been resolved. Continue with repair if necessary. Please contact Chris Koch at cell (248) 248-622-6417 if you have questions or need additional information. |
| 23-025-16 | 2018-05-21. Service bulletin. STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS. Discolored Door Hinge Nuts This bulletin involves replacing all the lower nuts on the side upper and lower door hinges. The customer may describe discoloring or rust from the lower nut securing the doors to the hinges. |
| 05091960A$ | 2018-03-13. Service bulletin. ELECTRICAL SYSTEM. Hands Free Module - CTM ? Peiker Before replacing the Hands Free Module (HFM), please contact Gaurav Saxena at cell (248) 260-0583 or Tim Kraft at cell (248) 766-5826 ~ IMPORTANT - do not reset the HFM, clear codes or perform a battery reset before calling. Engineering is currently root causing this issue and your assistance is greatly appreciated. Seeking vehicles with HFM in a locked state, inoperative, or offline. If unable to reach this person within 15 minutes, then proceed with the necessary repair. |
| 9002519 | 2018-02-21. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. 82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~ |
| RL108213A$ | 2017-11-03. Service bulletin. ENGINE AND ENGINE COOLING. NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~ |
| 9002718 | 2017-11-03. Service bulletin. ELECTRICAL SYSTEM; ELECTRICAL SYSTEM:SOFTWARE. Hands Free Module - Convergence Telematics Module (CTM) Before replacing the Hands Free Module (HFM), please contact Gaurav Saxena at cell (248) 260-0583 or Tim Kraft at cell (248) 766-5826 ~ IMPORTANT - do not reset the HFM, clear codes or perform a battery reset before calling. Engineering is currently root causing this issue and your assistance is greatly appreciated. Seeking vehicles with HFM in a locked state, inoperative, or offline. If unable to reach this person within 15 minutes, then proceed with the necessary repair. |
| 9003231 | 2017-11-03. Service bulletin. ELECTRICAL SYSTEM. RHB/RBZ Radio For JK, MK, and RT ONLY: RHB/RBZ radio that supports Bluetooth and Hands- Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). The Telematics Module (and associated components) is the system responsible for these features. Please reference; 8T - Navigation/Telecommunication Diagnosis and Testing (DIAGNOSIS AND TESTING - HANDS FREE PHONE |
| 9003639 | 2017-11-03. Service bulletin. FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES. Fuel Tank Pressure Sensor and Purge Valve Canister Before replacing this part due to fault code P0441, please call David Thomas at cell (248) 613-6908. Engineering may want to visit dealers in the metro Detroit area with this condition. If you don't receive response within 15 minutes, please continue with normal repair procedure. |
| 9002831 | 2017-11-03. Service bulletin. EQUIPMENT ADAPTIVE/MOBILITY. Water Pump For JK Bodies ONLY: If replacing the water pump for a chirp, squeal or NVH, please contact either: Nick Morand cell: (248) 410-5078 nick.morand@fcagroup.com Joe Lovell cell: (734) 309-6467 joe.lovell@fcagroup.com Engineering is seeking audio recordings of the concern in an effort to root cause and make necessary improvements to future pumps. Please email any audio recording or documentation of when/where/how the pump makes noise to the above emails. If the dealer is located in the Detroit Metro Area, Engineering may send a representative to review with technician. Any information is appreciated. If a response is not received within 15 mins , then proceed with the necessary repair. For JK and DS: Before replacing water pumps for noise issues the heat shield on the catalytic converter needs to be checked to make sure it is not the source of the noise. Check while the engine is fully warmed up. If the heat shield is found to be the source of the noise tighten the bolts and, or add shims/washers as needed. |
| 10-002-16 | 2017-11-03. Service bulletin. AIR BAGS. Non-desiccated Passenger Frontal Airbag This bulletin involves providing to purchasers of affected un-sold vehicles, prior to purchase, the attached "Important Notice" document and retain a signed copy. No customer symptoms or conditions are associated with this RRT. If a customer?s VIN is listed in VIP or your RRT VIN list, RRT applies only to those unsold Vins listed. |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.