Recalls that may apply to the 2002 International 9200i
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
By component
| 23V353000 | 2023-05-18. EXTERIOR LIGHTING:BACK UP LIGHTS. Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 International 4400, 2017-2024 International LT, 2018-2024 International RH, 2019-2021 International LS, 2019-2024 International MV vehicles. The back-up lights offer low visibility when the vehicle is in reverse and bobtail mode. Also, the vehicles have not been equipped with additional unobstructed back-up lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment." |
|---|---|
| 04V307000 | 2004-06-30. ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD. ON CERTAIN HEAVY DUTY TRUCKS, THE ENGINE ELECTRICAL HARNESS CAN CHAFE AGAINST SHARP EDGES ON THE ENGINE. Built 2002-06-02 to 2004-01-13. |
| 04V100000 | 2004-02-27. EQUIPMENT:RECREATIONAL VEHICLE/TRAILER. ON CERTAIN CONVENTIONAL TRUCKS EQUIPPED WITH PRO-SLEEPER BERTHS, WATER INTRUSION CAN BE FOUND IN THE BUNK CONTROL PANEL AREA AND POOL IN THE TOPS OF THE DOME LIGHT, TV/VCR, AND OR REFRIGERATOR POWER SWITCHES. Built 1994-04-01 to 2002-06-16. |
| 03V220000 | 2003-06-18. TRAILER HITCHES:FIFTH WHEEL ASSEMBLY. ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH JOST INTERNATIONAL JSK 37U SERIES FIFTH WHEELS, A FATIGUE CRACK CAN DEVELOP IN THE BRACKET PIN WELD UNDER CERTAIN LOADING CONDITIONS. Built 2001-02-01 to 2003-02-28. |
| 2023293 | 2023-05-18. Lights And Instruments. Issue: On certain trucks, the backup lamps could be blocked and may not be visible. As a result, the trucks don't meet the requirements of the Canadian regulations. Note: This recall only affects trucks equipped with a pintle hook lowering bracket and feature code 01WPN, 01 WPS, or 01VAL. Safety Risk: Backup lamps that aren't visible could cause a person not to recognize that the vehicle is backing and increase the risk of a crash. Corrective Actions: Navistar will notify owners by mail and instruct you to take your truck to a dealership to install new tail stop/turn signal lamps with integrated backup lamps. |
|---|---|
| 2007016 | 2007-01-22. Electrical. On certain trucks, the positive battery cables, that supply power from the batteries to the starter, may rub against an electrical ground cable between the engine and the starter, and electrical ground cable between the frame rail and the starter, or the frame rail itself. This rubbing may cause an electrical short and/or fire, which can result in property damage, personal injury, or death. Correction: Dealers will re-route the battery cables using new bracketry. |
| 2004209 | 2004-06-24. Electrical. On certain vehicles, the engine electrical harness can chafe against sharp edges on the engine. There are a number of different failures that could occur as many functions of the vehicle are processed through this harness. The modes of failure that could occur without warning, that may affect highway safety are: sudden acceleration, activation of engine compression brake, alternator overload and possible fire, engine speed dropping to idle, and loss of engine Electronic Control Module (ECM) power resulting in engine shutdown. Correction: Dealers will inspect, repair and relocate the engine harness. |
| 2004074 | 2004-02-26. Electrical. On certain vehicles, water intrusion into the sleeper berth's bunk control panel area may pool in the tops of the dome light, TV/VCR, and/or refrigerator power switches. The LED circuit boards in these switches may begin to heat up and possibly produce a flame or fire, without warning, that could cause property damage, personal injury, or death. Correction: Dealer will install a water shield over the back of the entire bunk control panel. |
| 2004049 | 2004-02-05. Other. On certain vehicles, a defect in the front wheel hub bearings will result in premature spalling which will lead to eventual breakdown of the bearing. An early breakdown of the wheel hub bearing system, when undetected, can possibly cause a wheel fire, wheel separation, loss of vehicle control, or vehicle fire. Correction: Dealer will inspect the front axle hubs, and replace if necessary. This is an expansion of Recall 03-134. |
| 2003134 | 2003-05-20. Other. On certain vehicles, a defect in the front wheel hub bearings will result in premature spalling which will lead to eventual breakdown of the bearing. An early breakdown of the wheel hub bearing system, when undetected, can possibly cause a wheel fire, wheel separation, loss of vehicle control, or vehicle fire. Correction: Dealer will replace front axle hubs. |
| 2003052 | 2003-02-28. Electrical. On certain vehicles, the cable from the starter to the battery stud on the alternator may break off at the alternator end, due to vibration in the cable, if the wire harness is not routed and clipped correctly. If the terminal breaks off, the cab will lose all power, resulting in complete electrical failure and engine shutdown, which may result in an accident and potentially cause property damage, personal injury, or death. Correction: Dealer will reroute and rewire the wiring harness to the alternator. |
A campaign lists a year, a make and a model, and often only some of the vehicles built. A list with nothing on it is not a clearance either. The lookups below check one VIN.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.