Recalls that may apply to the 2004 International 4400
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
By component
| 23V353000 | 2023-05-18. EXTERIOR LIGHTING:BACK UP LIGHTS. Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 International 4400, 2017-2024 International LT, 2018-2024 International RH, 2019-2021 International LS, 2019-2024 International MV vehicles. The back-up lights offer low visibility when the vehicle is in reverse and bobtail mode. Also, the vehicles have not been equipped with additional unobstructed back-up lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment." |
|---|---|
| 04V569000 | 2004-12-03. STRUCTURE. ON CERTAIN TRUCKS, THE BOLTS THAT MOUNT THE FRONT OF THE CAB TO THE MOUNTING BRACKETS WERE NOT PROPERLY TORQUED AT THE MANUFACTURING PLANT. Built 2004-01-16 to 2004-11-01. |
| 04V414000 | 2004-08-25. EQUIPMENT:OTHER:LABELS. CERTAIN TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS," AND WITH PART 567, 'CERTIFICATION.' THE "COMPLETE VEHICLE" LABEL WITH THE GROSS VEHICLE WEIGHT RATING (GVWR), GROSS AXLE WEIGHT RATING (GAWR), RECOMMENDED TIRE SIZE AND TIRE PRESSURE WAS NOT INSTALLED ON THE VEHICLE. Built 2004-05-24 to 2004-07-26. |
| 2023293 | 2023-05-18. Lights And Instruments. Issue: On certain trucks, the backup lamps could be blocked and may not be visible. As a result, the trucks don't meet the requirements of the Canadian regulations. Note: This recall only affects trucks equipped with a pintle hook lowering bracket and feature code 01WPN, 01 WPS, or 01VAL. Safety Risk: Backup lamps that aren't visible could cause a person not to recognize that the vehicle is backing and increase the risk of a crash. Corrective Actions: Navistar will notify owners by mail and instruct you to take your truck to a dealership to install new tail stop/turn signal lamps with integrated backup lamps. |
|---|---|
| 2004413 | 2004-11-24. Structure. On certain vehicles, the sixteen (16) bolts that mount the front of the cab to two (2) cast mounting brackets were not properly torqued. Without proper assembly torque, these bolts can loosen during normal vehicle use and fall out. This may lead to the cab separating from the vehicle's chassis during a crash that may result in properly damage, personal injury or death. Correction: Dealers will replace and torque all sixteen (16) bolts. |
| 2004383 | 2004-10-26. Suspension. On certain vehicles equipped with an IROS air suspension system, four fasteners that connect the main support members to the hanger bracket of the rear suspension may not have been torqued properly during assembly. With less than the specified clamp load, the bolts could fatigue and fail. A failure of these bolts could result in separation of the main support from the hanger bracket resulting in a sudden loss of control of the vehicle. This could cause a vehicle crash without warning, possibly resulting in property damage, personal injury or death. Correction: Dealers will replace all four bolts. |
| 2004356 | 2004-09-28. Lights And Instruments. On certain vehicles, the left turn signal light and the indicator lights on the instrument panel may not illuminate during hazard operation. An incorrectly manufactured switch contact causes intermittent contact in the turn signal stalk assembly. This results in intermittent left turn signal and indicator light operation when the hazard switch is activated. Intermittent light operation reduces the ability to warn other motorists of the driver's intentions. This could cause a vehicle crash without warning that may result in property damage, personal injury, or death. Correction: Dealers will replace the turn signal stalk assembly. |
| 2004305 | 2004-08-24. Label. Certain vehicles do not comply with the requirements of CMVSS 120. The compliance label, which indicates the vehicle's Gross Axle Weight Rating (GAWR), tire and wheel size and tire pressure ratings, was omitted. Correction: Owners will be provided with labels and installation instructions. |
| 2004142 | 2004-04-22. Seats And Restraints. On certain vehicles, the seat belt tongue could become disengaged from the latch without warning in a vehicle crash or during episodes of high seat belt loading. Correction: Dealer will inspect the seat belt assemblies and replace as required. |
A campaign lists a year, a make and a model, and often only some of the vehicles built. A list with nothing on it is not a clearance either. The lookups below check one VIN.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.