WenmarOpen by Wenmar Pro

Service bulletins for the 2014 Freightliner Cascadia

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

904 on file from NHTSA, as of 2026-10-19.

By type

By component

Only bulletins with component: Equipment and accessories are shown. Show all

Bulletins, newest first
TechTalk80482021-06-02. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM; EXTERIOR LIGHTING. Tech Talk continued discussion on Trailer ABS light on even when truck off.
TSN 01-07c2021-05-13. Service bulletin. EQUIPMENT ADAPTIVE/MOBILITY. Beyond routing and wiring concerns, the PCC system as previously implemented suffers from two timing / reporting issues. One stems from the long boot-up time of the PCC module as compared to the CPC (a.k.a. the 6N4C timer issue), and the other stems from the potential of some PCC modules to lock-up (a.k.a. the NAND flash issue). The timer concern is considered to primarily affect EPA10 units (OBD13 already had a longer timer) and most can be resolved by simply refreshing the CPC software (even if an update is not available). The module lock-up software solution is currently being validated, so the PDC stock is not clean yet. However, lock-up is anticipated to only be present in approximately 8% of PCC modules (based on testing), so (ahead of a campaign), here are instructions on how to reactivate a system, verify proper operation, and drive service actions.
TechTalk81212021-05-06. Service bulletin. ELECTRICAL SYSTEM; SERVICE BRAKES; EQUIPMENT. Tech Talk continuing discussion on ABS 11 SPN 807.
WI21-0082021-04-23. Service bulletin. EQUIPMENT. Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown. The updated times will be applied to repair orders opened on or after April 5, 2021.
DT12 Trans Chafe2021-04-08. Service bulletin. EQUIPMENT; EQUIPMENT ADAPTIVE/MOBILITY; POWER TRAIN. DTNA received a field notification on multiple units regarding diagnostic fault codes that were found to be causing issues to the After Treatment Control Module (ACM). These fault codes indicated that the ACM communication message was not received by the Motor Control Module (MCM) which in certain cases, led to a 25% engine de-rate situation. Further diagnosis revealed that the DT12 wiring harness was chafing and contacting the transmission TCU case. To reduce potential chafing areas, the proposed short-term containment was to route the wiring harness using additional tie straps. This communication applies to Freightliner and Western Star vehicles built with DT12 transmissions.
SB83-1552021-03-26. Service bulletin. EQUIPMENT. Updated Freightliner Service Bulletin for Espar Service Information. This bulletin replaces the version dated January 1, 2015. New Cascadia has been added to the model list.
TechTalk80482021-03-02. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT; EXTERIOR LIGHTING. Tech Talk continued discussion on Trailer ABS light on even when truck off.
SB54-3082021-02-26. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE; EQUIPMENT. Freightliner Service Bulletin for Programming Chassis Electronic Control Units (ECUs) With DiagnosticLink.
TechTalk80482021-02-02. Service bulletin. EQUIPMENT; EXTERIOR LIGHTING; ELECTRICAL SYSTEM. Tech Talk discussion on Trailer ABS light on even when truck off.
WI21-0012021-01-26. Service bulletin. ENGINE AND ENGINE COOLING; EQUIPMENT. Warranty Information Letter for Detroit New Service Replacement Engine SRT Update. While validating Standard Repair Times (SRTs) for Detroit's new Gen 5 engine series, DTNA discovered an error in a pre-Gen 5 SRT for the New Service Replacement Engine Program. As a result, DTNA re-studied the SRT and concluded that time for removing/re-installing multiple components (e.g., exhaust manifold/turbo, engine sensor harness, rocker arm assemblies, etc.) should not be included.
WP20-0182020-12-12. Service bulletin. STEERING; EQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT; POWER TRAIN. Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
18SP7442020-12-08. Service bulletin. EQUIPMENT ADAPTIVE/MOBILITY; ENGINE AND ENGINE COOLING; FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL. Special Publication letter for Two-Filter Fuel System KM59 GEN1 DD15 DD16 Severe Duty High Pressure Fuel Rail Feed Lines Service Kit.
TechTalk78782020-12-04. Service bulletin. ENGINE AND ENGINE COOLING; EQUIPMENT; SERVICE BRAKES. Tech Talk discussion on service brakes lock up when using engine brakes.
TechTalk46382020-12-04. Service bulletin. ENGINE AND ENGINE COOLING; EQUIPMENT. Tech Talk discussion on Intake manifold pressure too low.
TechTalk78662020-12-03. Service bulletin. EQUIPMENT; ENGINE AND ENGINE COOLING. Tech Talk discussion on ICU displays No Trans day after CPC was replaced.
SB54-2782020-10-28. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter. This bulletin replaces the version dated 5/31/2017. Information is added about the BCT-460DTNA PowerNet Assessment Tool. When troubleshooting Powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeter® is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
SB35-0362020-10-12. Service bulletin. EQUIPMENT; POWER TRAIN. Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
TechTalk64792020-09-30. Service bulletin. ENGINE AND ENGINE COOLING; EQUIPMENT. Tech Talk discussion on Cascadia DD15 fault code SPN 3597 FMI 4 and SPN 3463 FMI 16.
TechTalk47252020-09-30. Service bulletin. STEERING; EQUIPMENT. Tech Talk discussion about power steering fluid.
D20M92020-09-23. Service bulletin. ENGINE AND ENGINE COOLING; EQUIPMENT. Detroit Diesel Field Service Campaign for Engine Emission Label Replacement. Certain DETROIT heavy-duty engines installed in various applications will require reprogramming and engine emission label replacement.
20CSA-152020-09-02. Service bulletin. ELECTRICAL SYSTEM; ENGINE AND ENGINE COOLING; EQUIPMENT. Customer Service Announcement for Release of DiagnosticLink 8.12 Service Pack 2. On Thursday, September 3, 2020, Service Pack (SP) 2 for DiagnosticLink 8.12 Standard and Professional will be made available to download from the Detroit Diesel server.
SB26-0512020-08-29. Service bulletin. POWER TRAIN; EQUIPMENT. Updated Service Bulletin for DT12 Transmission Cooler Retrofit. This bulletin replaces the version dated 09/18/2019. The part number for the oil control valve has been updated in the parts table.
TS10330142020-07-31. Service bulletin. EQUIPMENT; EQUIPMENT ADAPTIVE/MOBILITY; FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP; ENGINE AND ENGINE COOLING. Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines. Occasionally we see trucks come in with fuel leaking from the high pressure fuel pump weep hole. This is NOT a defect in the pump and further diagnostics need to be performed to find the root cause.
SB31-0432020-07-31. Service bulletin. EQUIPMENT; SUSPENSION:REAR. Freightliner Service Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change. With the start of production on March 2, 2020, the fasteners used to assemble the non-Airliner rear suspension (bogie) crossmember have changed. The rear suspension bogie crossmember gussets to the C-channel will be assembled with 5/8 - 18 fasteners. This change includes a revision to a higher friction nut that requires an increase in tightening torque. The new higher friction nut can be identified by its green color.
WI20-0082020-04-28. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. Warranty Information Letter for Warranty Training Online. DTNA is pleased to announce the release of new Warranty-related training videos. The videos provide Warranty content in short instructional videos that are available on demand through the AftermarkeTV Video Channel icon on the Aftermarket Resource Center (ARC) home page.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.