WenmarOpen by Wenmar Pro

Service bulletins for the 1994 Ford F-250

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

166 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Bulletins, newest first
BC03219611011997-06-17. Service bulletin. SUSPENSION:FRONT. POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *TW
BC08839610041997-04-24. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE. VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT
BC08209610101997-04-24. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. REVISED EEC CALIBRATION HAS BEEN INCORPORATED IN PCM CALIBRATIONS FOR VEHICLES WHICH DISPLAY LACK OF POWER DUE TO TORQUE CONVERTER ENGAGEMENT SCHEDULING, CATALYTIC CONVERTER FAILURES, ROUGH IDLE OR HARD START ON HOT RESTART. *TT
BC06829610241997-04-24. Service bulletin. POWER TRAIN:DRIVELINE:DRIVESHAFT. VEHICLES MAY EXHIBIT A DRIVELINE VIBRATION OR NOISE WHILE DRIVING AT HIGHWAY SPEEDS ON STEADY CRUISE OR DECEL. *TT
BC06789610251997-04-24. Service bulletin. POWER TRAIN:MANUAL TRANSMISSION. INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT. *TT
952121996-04-25. Service bulletin. SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP. THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. IF PETROLEUM-BASED GREASE IS USED TO LUBRICATE ANY PART OF THE DISC BRAKE SYSTEM, IT COULD CAUSE RUBBER PARTS TO SWELL IF LUBRICANT CONTACTS THE RUBBER MATERIAL.
BC01319601021996-04-25. Service bulletin. POWER TRAIN:AXLE ASSEMBLY. 4X4 FRONT AXLES MUST USE HYPOID 4X4 GEAR OIL P/N F1TZ-19580-A & HIGH TEMP 4X4 FRONT AXLE & WHEEL BEARING GREASE WHEN SERVICING. IT IS NOT RECOMMENDED TO USE HEAVIER WEIGHT LUBES IN THESE FRONT AXLES.
9517141996-04-25. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. ENGINE- 'KNOCKING' NOISE - WHEN OPERATING ENGINE AT 200-2300 RPM - FD1460 ENGINE
9517131996-04-25. Service bulletin. ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR. GENERATOR-MOTORCRAFT 95AMP-FRONT BEARING CONCERN-FD1060/1460 ENGINES- VEHICLES BUILT BEFORE 7/3/95. *SD
9516161996-04-25. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. AIR CONDITIONING-LACK OF COOLING AT IDLE-A/C SYSTEM SHUTS OFF DUE TO HIGH SYSTEM PRESSURES-7.3L DI TURBO F-SERIES BUILT BEFORE 4/14/95 AND 7.3L DI TURBO ECONOLINES BUILT BEFORE 4/21/95. *SD
BC14329950901996-04-25. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. ENGINE MOAN AT APPROXIMATELY 1900 RPM DUE TO THE FLYWHEEL DAMPENING OF ENGINE PULSES. *TW
BC15229509061996-04-25. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. A/C SYSTEM SHUTTING OFF FROM HIGH SYSTEM PRESSURES OR LACK OF COOLING AT IDLE. *TW
BC13519509061996-04-25. Service bulletin. FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS. ROUGH IDLE OR MISS MAY BE DUE TO LOOSE INJECTOR HOLD DOWN BOLT. *TW
BC42251995-11-01. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE; ENGINE AND ENGINE COOLING:ENGINE; POWER TRAIN:AUTOMATIC TRANSMISSION; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM; ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD; VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM; STRUCTURE:BODY:BUMPERS; EQUIPMENT:APPLIANCE:AIR CONDITIONER; ENGINE AND ENGINE COOLING:COOLING SYSTEM; FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM. UNKNOWN
9511131995-11-01. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. DELAYED FORWARD ENGAGEMENT AND/OR HEAT STAINED FORWARD CLUTCH PLATES AFTER INSTALLING CENTER SUPPORT SERVICE. *TW
9511121995-11-01. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. REVISED DESIGN TRANSMISSION REAR CASE BUSHING. *TW
955221995-11-01. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. ACCESSORY DRIVE BELTS - ALL 7.3 IDI DIESELS COME OFF ACCESSORY DRIVE PULLEYS - VEHICLES BUILT AFTER 2/15/92. *TW
BC43219507051995-11-01. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. VEHICLES EXPERIENCING OCCASIONAL HARSH REVERSE ENGAGEMENT CONCERNS. *TW
9510151995-11-01. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. HYDROMOUNTED CAB - EVAPORATIVE EMISSION LINES RUBBING ON THE FENDER. *TW
9510101995-11-01. Service bulletin. VEHICLE SPEED CONTROL. LACK OF ACCELERATOR CONTROL WHEN MOVING OFF THE IDLE POSITION. *TW
951081995-11-01. Service bulletin. FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS. VEHICLES MAY BE HARD TO START AFTER THE FUEL INJECTORS HAVE BEEN REPLACED. *TW
951071995-11-01. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. VEHICLES MAY EXHIBIT A POOR IDLE QUALITY AND/OR LOW OUTPUT AFTER THE ENGINE RETURNS TO IDLE SPEED. *TW
959121995-11-01. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY. UNKNOWN
95981995-11-01. Service bulletin. SUSPENSION:FRONT. UNKNOWN
95971995-11-01. Service bulletin. SUSPENSION:FRONT. UNKNOWN

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.