Service bulletins for the 2000 Ford Excursion
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
217 on file from NHTSA, as of 2026-10-19.
By type
By component
By trouble code
| 8167 | 2000-06-07. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM. *TT |
|---|---|
| 8121 | 2000-06-07. Service bulletin. POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE). SUBJECT REGARDING TRANSFER CASE SHIFT RELAY LOCATION. *TT |
| 8120 | 2000-06-07. Service bulletin. POWER TRAIN:AXLE ASSEMBLY. SOME VEHICLES EQUIPPED WITH ELECTRONIC SHIFT ON THE FLY TRANSFER CASE MAY EXHIBIT ONE OR MORE OF THE FOLLOWING CONDITIONS: FRONT HUBS WILL NOT UNLOCK / LOCK WITH MODE SWITCH, NOISE FROM THE FRONT AXLE WHILE DRIVING IN 2 WHEEL DRIVE MODE, AIR CONDITIONING SWITCHING TO DEFROST WHEN SHIFTING INTO OR OUT OF 4 WHEEL DRIVE MODE. *TT |
| 0022 | 2000-06-07. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES. VEHICLES MAY EXPERIENCE PARTICLE CONTAMINANTS, FROM PRIOR TRANSMISSIION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IF NOT PROPERLY FLUSHED. *MJS |
| 8098 | 2000-06-07. Service bulletin. VISIBILITY:REARVIEW MIRRORS/DEVICES. INFORMATION REGARDING OPERATION OF HEATED SIDE MIRRORS. *TT |
| 7888 | 2000-06-07. Service bulletin. VISIBILITY:WINDSHIELD WIPER/WASHER. THE VEHICLE MAY EXHIBIT A YELLOWISH STAIN ON THE DUTCH REAR DOORS UNDER THE WIPER ARM ASSEMBLY. THIS CONDITION COULD BE CAUSED BY A CHEMICAL REACTION BETWEEN THE WASHER FLUID AND 4 OF THE TUBES USED IN THE REAR WASHER SYSTEM. |
| 7887 | 2000-06-07. Service bulletin. VISIBILITY:WINDSHIELD WIPER/WASHER. THE VEHICLE MAY EXHIBIT A YELLOWISH STAIN ON THE REAR TAILGATE BELOW THE REAR WINDSHIELD WIPER. |
| 7884 | 2000-06-07. Service bulletin. ENGINE AND ENGINE COOLING:COOLING SYSTEM. THE VEHICLE EQUIPPED WITH 5.4L OR 6.8L GAS ENGINES MAY EXHIBIT AN OVERHEATING CONDITION DURING PREDELIVERY INSPECTION. THIS MAY BE CAUSED BY A LOW COOLANT LEVEL. |
| 7863 | 2000-06-07. Service bulletin. SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER. THE DRIVER'S SIDE REAR BRAKE CALIPER WILL BE RELOCATED BEHIND THE REAR AXLE. IN ADDITION, THESE VEHICLES WILL NO LONGER HAVE A CALIPER SHIELD ON THE DRIVERS SIDE OF THE REAR AXLE. |
| 7859 | 2000-06-07. Service bulletin. WHEELS:HUB. VEHICLE EQUIPED WITH EITHER MANUAL OR ELECTRONIC SHIFT 4X4 SYSTEM MAY EXHIBIT A VIBRATION OR A RATCHETING NOISE FROM THE FRONT OF THE VEHICLE. ANOTHER SYMPTOM MAY BE DESCRIBED AS FRONT HUBLOCKS NOT RELEASING. |
| 13566 | 2000-05-18. Service bulletin. UNKNOWN OR OTHER. THERE HAVE BEEN SOME INQUIRIES AS TO WHETHER CERTAIN VEHICLES CAN BE USED FOR SNOWPLOWING. THIS BULLETIN STATES THAT UNDER NO CIRCUMSTANCE SHOULD A SNOWPLOW BE ATTACHED TO CERTAIN VEHICLES. *TT |
| 13548 | 2000-05-18. Service bulletin. VEHICLE SPEED CONTROL:CRUISE CONTROL. INFORMATION ON THE IDLE KICKER FEATURE, WHICH UNDER CONDITIONS WILL AUTOMATICALLY ELEVATE THE IDLE SPEED AFTER 130 SECONDS OF IDLING AT COLD TEMPERATURES. *TT |
| 13476 | 2000-05-18. Service bulletin. SUSPENSION:FRONT. SOME VEHICLES MAY EXHIBIT A PULL TO THE LEFT WHILE BRAKING CONDITION. *TT |
| 13443 | 2000-05-16. Service bulletin. SUSPENSION:FRONT. EXPERIENCING A POPPING NOISE FROM THE FRONT SUSPENSION OR PASSENGER SIDE FLOOR PAN. *TT |
| 7546 | 2000-05-16. Service bulletin. UNKNOWN OR OTHER. INFORMATION REGARDING LOCATION OF DOOR KEYPAD CODE. *TT |
| 7543 | 2000-05-16. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. SOME VEHICLES EQUIPPED WITH THE 6.8L V-10 ENGINE AND CALIFORNIA EMISSIONS MAY EXHIBIT AN EXHAUST FLUTTER NOISE. THIS NOISE MAY ALSO BE DESCRIBED AS AN ENGINE MISS OR EXHAUST LEAK. *TT |
| 7488 | 2000-05-16. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. SOME CUSTOMERS MAY COMMENT ABOUT THE CLIMATE CONTROL SYSTEM DEFAULTING TO DEFROST MODE AND / OR NO AIR DISTRIBUTION CONTROL. *TT |
| 7456 | 2000-05-15. Service bulletin. SUSPENSION:FRONT. SOME VEHICLES MAY EXHIBIT A PULL TO THE LEFT CONDITION WHILE BRAKING. *TT |
| 7432 | 2000-05-15. Service bulletin. SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS. SOME VEHICLES MAY EXHIBIT BRAKE VIBRATION OR SHUDDER WHILE BRAKING. *TT |
| 7421 | 2000-05-15. Service bulletin. SUSPENSION. EXHIBITING A POPPING NOISE FROM THE FRONT SUSPENSION OR PASSENGER SIDE FLOOR PAN. *TT |
| 7342 | 2000-05-12. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. SOME VEHICLES WITH AUXILIARY AIR CONDITIONER MAY EXHIBIT POOR / NO AIR CONDITIONER COOLING. *TT |
| 13022 | 2000-05-12. Service bulletin. ELECTRICAL SYSTEM:IGNITION:MODULE. SOME VEHICLES BUILT BEFORE 11/1999 MAY EXHIBIT INCORRECTLY SET GENERIC ELECTRONIC MODULE (GEM) DIAGNOSTIC TROUBLE CODES (DTC). *TT |
| 13353 | 2000-04-05. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. SUBJECT REGARDING POOR / NO AIR CONDITIONER PERFORMANCE. *TT |
| 13247 | 2000-04-04. Service bulletin. VISIBILITY:GLASS, SIDE/REAR. EXHIBITING AN ADHESIVE FAILURE BETWEEN THE HINGE AND / OR REAR CLEVIS AND THE REAR QUARTER GLASS SURFACE. *TT |
| 7153 | 2000-03-29. Service bulletin. SUSPENSION. EXHIBITING A VIBRATION AT SPEEDS ABOVE 40 MPH. *TT |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.