WenmarOpen by Wenmar Pro

Service bulletins for the 2000 Dodge Intrepid

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

81 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

By topic

Only bulletins with component: Engine are shown. Show all

Bulletins, newest first
683328102022-10-17. Service bulletin. ENGINE AND ENGINE COOLING. Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar® Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 N·m [21 ft. lbs.].
R2118796A2021-05-03. Service bulletin. ENGINE AND ENGINE COOLING. Valve Body. These may cause over drive cycling.
2500102A2004-04-21. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL. MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION, DIAGNOSTIC TROUBLE CODE (DTC) P0442, P0455, OR P0456 - LEAK DETECTION PUMP (LDP), LEAK DETECTED. THIS BULLETIN SUPERSEDES 25-001-02 DATED FEB 11, 2002. *TT
09002042004-03-04. Service bulletin. ENGINE AND ENGINE COOLING. SHORT DURATION COLD ENGINE START-UP TICKING LIKE SOUND. THIS BULLETIN APPLIES TO VEHICLES BUILT PRIOR TO MARCH 31, 2003. *MN
09005032004-02-20. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. SHORT DURATION COLD ENGINE START-UP TICKING LIKE SOUND. *TT
09002032003-08-20. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. ENGINE STUMBLE AND/OR MISFIRE - MALFUNCTION INDICATOR LAMP ILLUMINATION. *TT
07002022002-03-27. Service bulletin. ENGINE AND ENGINE COOLING:COOLING SYSTEM. SUBJECT REGARDING LOW OR NO CABIN HEAD, ENGINE COOLING SYSTEM SYSTEM FILL PROCEDURE. *TT
18018012001-10-26. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. VEHICLES MAY EXPERIENCE INFREQUENT ERRATIC IDLE . *SLC
0702002000-09-29. Service bulletin. ENGINE AND ENGINE COOLING:COOLING SYSTEM. SOME VEHICLES MAY EXHIBIT ENGINE OVERHEATING AND / OR COOLANT BOTTLE FAILURES AFTER SERVICE HAS BEEN PERFORMED ON THE ENGINE COOLING SYSTEM. *TT
0701002000-05-08. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. A CONDITION MAY EXIST WHERE A LOW TONE GROWL SOUND CAN BE HEARD COMING FROM THE ENGINE FOLLOWING A COLD START WHILE IN DRIVE OR REVERSE WITH ENGINE RPM BETWEEN 1000 AND 1300 RPM. *TT
1801002000-04-12. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. SUBJECT REGARDING MISDIAGNOSED LEAK DETECTION PUMP SYSTEMS WITH DIAGNOSTIC TROUBLE CODES P1494, P0442 P0455, OR P0456. *TT
0814991999-08-17. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. CONDITIONS WITH VEHICLE START AND STALL OR VEHICLE NO-START. *TT

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.