WenmarOpen by Wenmar Pro

Service bulletins for the 2021 Chrysler Pacifica

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

700 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Bulletins, newest first
08-299-252025-09-17. Service bulletin. ELECTRICAL SYSTEM. High Voltage Battery Pack Replacement XT1 Warranty Extension Customers may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0EDD-00 - Hybrid/EV Battery Pack "B" Deterioration. ● P0BBE-00 - Hybrid Battery Pack Voltage Variation. ● P1C5E-00 - Battery State Of Health Failed. NOTE: Any warranty qualifying issues outside of these specific DTCs will continue to be covered per the HV battery standard warranty coverage This bulletin involves replacing the high voltage battery pack.
S25190000082025-09-04. Service bulletin. SUSPENSION. Noise From Front End While Steering Or Turning The Steering Wheel.
31-001-25 REV. A2025-08-21. Service bulletin. STRUCTURE:BODY. Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates.
31-001-252025-08-21. Service bulletin. STRUCTURE:BODY. Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates
21-025-25 REV. A2025-08-13. Service bulletin. POWER TRAIN. Internal Transmission Wiring Connector Short and Motor A Bearing Failure Warranty Extension XE1 Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0A3F - Drive Motor A Position Sensor 1 Circuit. ● P0A43 - Drive Motor A Position Sensor Circuit Intermittent. ● P0A45 - Drive Motor B Position Sensor 1 Circuit. ● P0C1A - Drive Motor B Torque Delivered Performance. Customers may also comment on the following: ● Vehicle is in limp mode. NOTE: Module flashes are also required for this Repair Procedure to be effective, the following modules are to be updated: ● Hybrid Control Processor (HCP). ● Auxiliary Hybrid Control Processor (AHCP) also known as the Power Inverter Module (PIM). This bulletin involves servicing the transmission.
S258A0000172025-08-06. Service bulletin. ELECTRICAL SYSTEM. Door speaker Inoperative or No Sound
S2509000001 REV.B2025-07-31. Service bulletin. ENGINE. Engine Rattle Noise
S2422000001 REV.D2025-07-31. Service bulletin. ELECTRICAL SYSTEM. Tire Pressure Monitor (TPM) Service Information. TPM Lamp On.
91006222025-07-09. Service bulletin. ENGINE. When replacing a camshaft and parts kit (P/N 68661146xx and/or 68661147xx), it is NOT necessary to order the roller-finger followers (rocker arms) separately, as these are included in the camshaft parts kit.
S2208000138 REV.B2025-07-09. Service bulletin. ELECTRICAL SYSTEM. Decreased Remote Start And RKE Range. Tire Pressure Sensors Values Are Not Displayed
91006162025-07-08. Service bulletin. ELECTRICAL SYSTEM. Telematics Box Module Verify Z part number availability. Order a Z part number for all Exchange Orders: Warranty, Mopar, customer pay and service contract. Order regular part number for New unsold units only.
S2408000072 REV.A2025-07-02. Service bulletin. STRUCTURE:BODY; ELECTRICAL SYSTEM. Power Sliding Door Inoperative or Intermittently Will Not Open or Close
91006142025-06-26. Service bulletin. ENGINE. ADJUSTER Valve Lash Customer's complaint may include a ticking noise coming from the engine. Technician's observations can refer to spongy or stuck hydraulic lash adjusters. Exhaust lash adjusters found with a "spongy" condition (compressible plunger) leading to the assumption of being defective/malfunctioning. EXHAUST lash adjusters are designed to be COMPRESSIBLE by hand. Intake lash adjusters found with a stiff or stuck condition (non-compressible plunger) leading to the assumption of being defective/malfunctioning. INTAKE lash adjusters are designed to be NON COMPRESSIBLE by hand. Do Not Replace EXHAUST lash adjusters when the following condition is present: should be compressible, but they will exert a reactionary spring force during compression and return to full expansion without a compression force. Do Not Replace INTAKE lash adjusters when the following condition is present: should feel very firm and difficult to compress. Once the correct functioning of the intake and exhaust lash adjusters is validated with the procedure above, refer to the Service Manual "HYDRAULIC LIFTER(S) NOISE DIAGNOSIS" procedure. After the corresponding service procedures from the Service Manual involving the Lash Adjusters have been conducted, refer to the detailed instructions in the Service Manual to diagnose and/or service any other component.
S25230000572025-06-26. Service bulletin. SEATS. 1st Row Armrest Not Holding Position, Being Broken, Being Too Low, Or Touching The Console.
02-002-252025-05-30. Service bulletin. SUSPENSION. "Shock And Strut Diagnosis And Replacement Guidelines Leaking, noisy, or weak shocks or struts. "
S25230000502025-05-28. Service bulletin. POWER TRAIN; ENGINE; UNKNOWN OR OTHER. Vibration From Engine Or Powertrain. Powertrain Mounting Neutralization Procedure. Discussion: Service information is in the process of being updated to include powertrain mount installation best practices. The new procedure will neutralize the mounts to lessen or remove unwanted mount tension that can lead to vibration complaints.
09-011-252025-05-20. Service bulletin. ENGINE. "Misfire Diagnostic Trouble Codes (DTCs), Rough Idle, Valvetrain Noise Customers may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0301 - Cylinder 1 Misfire. ● P0302 - Cylinder 2 Misfire. ● P0303 - Cylinder 3 Misfire. ● P0304 - Cylinder 4 Misfire. ● P0305 - Cylinder 5 Misfire. ● P0306 - Cylinder 6 Misfire. Customers may comment on one or more of the following: ● Rough idle. ● Valvetrain noise. "
9100498 Rev 32025-05-19. Service bulletin. ENGINE. 3.6L PSU Long Block Misfire DTC codes and/or rough idle and/or valvetrain noise. Refer to SOL # S2509000004. It is also important to confirm that the vehicle being repaired has the latest calibration/software update for oil pump operation mode (high pressure mode) during engine start up. RU, VF, WL & WD vehicles already include the latest oil pump mode in all 25MY and beyond. 24MY service releases are also available. JL & JT were updated as a running change in 24MY and beyond (08/15/24 & 08/19/24 respectively). 24MY service releases available. DT was updated starting 25MY and beyond. If the vehicle to be repaired is a 24MY vehicle with a service release available, please follow the released service procedures to update to the corresponding calibration/software.
S2323000002 REV.A2025-05-19. Service bulletin. ELECTRICAL SYSTEM. "Washer Light On And Will Not Turn Off After Adding Washer Solvent."
S2423000026 REV.A2025-05-19. Service bulletin. ELECTRICAL SYSTEM; STRUCTURE:BODY. Power Sliding Door Will Not Power Open And/Or Close Automatically.
S2408000114 REV.A2025-05-14. Service bulletin. FORWARD COLLISION AVOIDANCE: WARNINGS; FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL. " Instrument Panel Cluster (IPC) Displays Warning Lamps or Messages for Loss of Advanced Driver Assist System (ADAS)"
S258A0000132025-04-17. Service bulletin. ELECTRICAL SYSTEM. AM Radio Static, With No Active or Stored Radio Antenna Diagnostic Trouble Codes (DTC).
9100347 Rev 12025-04-16. Other. SEATS. "3rd row headrest If you have customer with issue involving the 3rd row headrest not staying up. It has been determined that the issue is with the trim carpet the headrest strap goes through, not the headrest mechanism. Please do not replace the headrest/headrest mechanism and instead refer to SOL S2423000025 for the proper rework procedure that should be done"
91005462025-04-16. Service bulletin. ELECTRICAL SYSTEM. "Display Verify Z part number availability. Order a Z part number for all Exchange Orders: warranty, Mopar, customer pay and service contract. Order regular part number for New unsold units only."
S25090000042025-04-03. Service bulletin. ENGINE. Misfire DTCs, Rough Idle, Valvetrain Noise

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.