WenmarOpen by Wenmar Pro

Service bulletins for the 2014 Chevrolet Express

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

1714 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

By topic

Only bulletins with component: Fuel pump are shown. Show all

Bulletins, newest first
PIP55962018-11-13. Service bulletin. FUEL SYSTEM, GASOLINE; FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS; FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP. This Preliminary information communicates that when removing the fuel line jumper hose care should be taken to be sure the line is reinstalled correctly to avoid a no/low fuel pressure situation.
14-06-04-0022018-05-21. Service bulletin. FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP; ELECTRICAL SYSTEM:STARTER ASSEMBLY. This informational bulletin provides information of customer concern of the vehicle has a no start condition, caused from upfitter modifications not properly preparing the ground, causing the LPG fuel pump to lose a ground connection.
173562018-05-21. Service bulletin. FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP. 17356 - Emission Recall. Vehicles may experience an inoperative fuel pump leading to a no start or stall without warning. The fuel pump is to be replaced with a new design fuel pump.
146342018-04-23. Service bulletin. FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP. 14634 - Special Coverage. Certain 2010-2014 model year Chevrolet Express and GMC Savana vehicles may have a condition in which the fuel pump becomes inoperative due to an open circuit and/or overheating of the fuel pump module battery terminal. Dealers are to replace the fuel pump on all vehicles, and on vehicles built prior to April 25, 2012, also replace the chassis harness terminals.
PIP4949E2017-08-15. Service bulletin. FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP; FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM; FUEL SYSTEM, OTHER:FUEL FILTER. This Preliminary Information communication provides information to the technician about vehicles that have a hard start or a no start. Technician may find Diagnostic Trouble Code DTCs P0087, P0088, P0191 or P128E. Technician will need to follow all Service Information diagnose for the Diagnostic Trouble Code. If the current Service Information diagnostic has led to Fuel Injection Pump replacement, Fuel Pressure Regulator 1 must be inspected for magnetic metal debris. If there is a questionable amount of magnetic debris found on Pressure Regulator 1 remove the Fuel Rail Pressure Sensor and/or Fuel Pressure Regulator 2 to inspect for magnetic metal debris. If technician will need to replace all of the parts listed under the latest version of PIP4949 found in the Service Forms section of Global Connect if debris is found. Clean and flush all fuel chassis lines, filter pipes, and other engine mounted fuel system pipes not replaced. Also the fuel filter housing must be cleaned with a new fuel filter installed. Then the fuel tank and fuel sender must be cleaned and flushed.
PIP5133C2017-08-15. Service bulletin. FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP; FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM. This Preliminary Information communication advises the technician that the 6.6L Duramax Diesel Engine Fuel Injection Pump Part numbers 12645102, 12658095 and 12661059 will be placed on a parts restriction through the General Motors Product Quality Center. Dealer will need to contact General Motors Product Quality Center for further assistance.
14-06-04-002A2017-08-15. Service bulletin. FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP. This informational bulletin provides information of customer concern of the vehicle has a no start condition, caused from upfitter modifications not properly preparing the ground, causing the LPG fuel pump to lose a ground connection.
PIP5507B2017-08-15. Service bulletin. FUEL SYSTEM, GASOLINE; FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP. This Preliminary information communicatesIn ambient temperatures 100F (37.7 C)degrees or higher, DTCs P2635 and/or P018B may set.The vehicle may also exhibit a hesitation or stalling condition.Excessively Hot and sustained ambient temperatures over 100F (37.7 C) degrees Mainly in TX, AZ, UT, NV, CA, NM (could be any state) causingVapor buildup in fuel feed line.Customers can be advised to utilize fuels with octane levels greater than 91, Refrain from extended idleing periods if possible, park vehicles in covered garage.Replacing the fuel pump will not repare this concern.
PIP5507A2017-08-15. Service bulletin. FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP. This Preliminary information communicatesIn ambient temperatures 100F (37.7 C)degrees or higher, DTCs P2635 and/or P018B may set.The vehicle may also exhibit a hesitation or stalling condition.Excessively Hot and sustained ambient temperatures over 100F (37.7 C) degrees Mainly in TX, AZ, UT, NV, CA, NM (could be any state) causingVapor buildup in fuel feed line.Customers can be advised to utilize fuels with octane levels greater than 91, Refrain from extended idleing periods if possible, park vehicles in covered garage.Replacing the fuel pump will not repare this concern.
PIP4949D2017-08-15. Service bulletin. FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL; FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP; FUEL SYSTEM, GASOLINE. This Preliminary Information communication provides information to the technician about vehicles that have a hard start or a no start. Technician may find Diagnostic Trouble Code DTCs P0087, P0088, P0191 or P128E. Technician will need to follow all Service Information diagnose for the Diagnostic Trouble Code. If the current Service Information diagnostic has led to Fuel Injection Pump replacement, Fuel Pressure Regulator 1 must be inspected for magnetic metal debris. If there is a questionable amount of magnetic debris found on Pressure Regulator 1 remove the Fuel Rail Pressure Sensor and/or Fuel Pressure Regulator 2 to inspect for magnetic metal debris. If technician will need to replace all of the parts listed under the latest version of PIP4949 found in the Service Forms section of Global Connect if debris is found. Clean and flush all fuel chassis lines, filter pipes, and other engine mounted fuel system pipes not replaced. Also the fuel filter housing must be cleaned with a new fuel filter installed. Then the fuel tank and fuel sender must be cleaned and flushed.
PIP4942B2017-08-15. Service bulletin. FUEL SYSTEM, GASOLINE; FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP; FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL. This Preliminary Information communication provides information to the technician about vehicles that may have a fuel leak or fuel odor. Technician may find Diagnostic Trouble Codes. If Diagnostic Trouble Codes are found technician should use published Service Information diagnostics first. If fuel leaks are found at the high pressure pump to fuel rail line fitting connections, technician should inspect the high pressure line fittings for misaligned lines and/or low torque of the line nuts. If leaks are found at the high pressure line fittings, technician will need to replace both lines.
14-06-04-0022016-05-19. Service bulletin. FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP; ENGINE. SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SC-146342015-06-17. Service bulletin. FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP; FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP. GMC/CHEVROLET: TSB CONTAINS AN OWNER NOTIFICATION LETTER. SELECT DOCUMENT SEARCH BUTTON BELOW. THE FUEL PUMP HAS AN OPEN CIRCUIT AND/OR OVERHEATING CONDITION, IN SOME VEHICLES, WHEREBY ITS INOPERATIVE BECAUSE OF FUEL PUMP MODULE BATTERY TERMINAL. MODEL 2010-14 EXPRESS, SAVANA. *PE UPDATED 10/7/15 *CN
PIP5133C2015-06-12. Service bulletin. FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP. GENERAL MOTORS: CHEVROLET EXPRESS 2010-2015 SILVERADO ,SAVANA SIERRA EQUIPPED WITH 6.6L DURAMAX DIESEL ENGINE RPO CODES LGH. DURAMAX FUEL INJECTION PUMP PART RESTRICTION. *LJ
14-06-04-002A2015-03-24. Service bulletin. FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP. GM: 2012-2015 CHEVROLET EXPRESS, SAVANA CUSTOMERS ARE EXPERIENCING VEHICLES NOT ABLE TO START UP DUE TO LPG FUEL PUMP INOPERATING. *LJ
PIP-4942-B2014-10-16. Service bulletin. FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP; FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS; FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL. GMC/CHEVROLET: AT BOTTOM OF FLYWHEEL HOUSING, A LEAK IS FOUND, CAUSING A FUEL ODOR, DUE TO HIGH PRESSURE PUMP TO HIGH PRESSURE LINE FITTING OR FUEL RAIL CONNECTION. 2010-2015 EXPRESS, SIERRA, SAVANA, SILVERADO. *PE
SB-14-06-04-0022014-03-18. Service bulletin. FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP. CHEVROLET/GMC: DUE TO AN INOPERATIVE LPG FUEL PUMP, AN INTERMITTENT CONDITION OF NO START IS CAUSED. MODEL 2012-2014, EXPRESS, SAVANNA. *PE

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.