Service bulletins for the 2007 Chevrolet Express
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
969 on file from NHTSA, as of 2026-10-19.
By type
By component
By trouble code
By topic
Only bulletins with component: Engine are shown. Show all
| PIP-5258 | 2017-04-11. Service bulletin. ENGINE. THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT MAY HAVE SERVICE ENGINE SOON AND A DIAGNOSTIC TROUBLE CODE P0011. IF THE TECHNICIAN HAS FOLLOWED SERVICE INFORMATION DIAGNOSTIC TROUBLE CODE FOR P0011AND THE ROOT CAUSE WAS NOT FOUND THE OIL PRESSURE AT THE OIL PRESSURE SENDER SHOULD BE CHECKED. ALSO THE NUMBER 2 CAM BEARING SHOULD BE INSPECTED. |
|---|---|
| 080604006K | 2016-11-29. Service bulletin. ENGINE. THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION FOR IDENTIFYING NON-GM ECM CALIBRATION USE AND POWER-UP HARDWARE DETECTION IN DURAMAX DIESEL ENGINES - PHOTOGRAPH TECH 2 CALIBRATION IDS, CALIBRATION VERIFICATION NUMBERS (CVNS) AND TRANSMISSION DATA SCREEN |
| PIP4786C | 2016-10-20. Service bulletin. ENGINE AND ENGINE COOLING. THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT MAY HAVE LOW OIL PRESSURE MESSAGE. TECHNICIAN MAY ALSO FIND A DIAGNOSTIC TROUBLE CODE P0521 IN THE ENGINE CONTROL MODULE. TECHNICIAN SHOULD FOLLOW ALL PUBLISHED SERVICE INFORMATION DIAGNOSIS. WHEN USING A SCAN TOOL IF THE OIL PRESSURE IS LOW BUT THE OIL PRESSURE AT THE OIL FILTER HOUSING IS CORRECT, TECHNICIAN SHOULD INSPECT THE VALVE LIFTER OIL FILTER FOR DEBRIS/SLUDGE THAT COULD BE RESTRICTING OIL FLOW TO THE OIL PRESSURE SENSOR. TECHNICIAN SHOULD REMOVE THE VALVE LIFTER OIL FILTER AND CLEAN IT. IF THE VALVE LIFTER OIL FILTER CANNOT BE CLEANED REPLACE IT. |
| PI1394A | 2016-10-19. Service bulletin. ENGINE. THIS INFORMATIONAL BULLETIN PROVIDES ADDITIONAL INFORMATION ON HOW TO INSTALL PISTONS AND SUGGEST WHAT TOOLS TO USE. |
| 030604017I | 2016-10-18. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:DIESEL. THIS INFORMATIONAL BULLETIN EXPLAINS THE USE OF DIESEL FUEL ADDITIVES IN AN ENGINE, ARE NOT REQUIRED UNLESS THE CUSTOMER DESIRES ADDITIVES TO PREVENT FUEL CONCERNS DEPENDING ON FUEL OR TEMPERATURE RELATED CONDITIONS. |
| 030603004R | 2016-10-18. Service bulletin. ENGINE; ELECTRICAL SYSTEM:12V/24V/48V BATTERY. THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION ON HOW TO TEST A BATTERY AND WHAT IS NEEDED TO WARRANTY A BATTERY. |
| 000601026I | 2016-10-18. Service bulletin. ENGINE. THIS INFORMATIONAL BULLETINS PROVIDES INFORMATION ON THE INTAKE MANIFOLD INSPECTION/REPLACEMENT AFTER SERVERE INTERNAL ENGINE DAMAGE. |
| 000601012F | 2016-10-18. Service bulletin. ENGINE. THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION TO GM DEALERS ON THE CORRECT CLEANING METHODS WHEN CLEANING ENGINE GASKET SEALING SURFACES. |
| SB-07-06-01-016C | 2016-08-09. Service bulletin. ENGINE. THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION INTERNAL ENGINE NOISE OR DAMAGE AFTER OIL FILTER REPLACEMENT |
| 10-06-05-002A | 2016-05-19. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. SUMMARY TO BE PROVIDED ON A FUTURE DATE. |
| PIP-5276-E | 2016-02-01. Service bulletin. ENGINE; ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL. CADILLAC/CHEVROLET/GMC: ON SOME VEHICLES AND/OR TRUCKS, INSTRUMENT CLUSTER WILL ILLUMINATE, AFTER AN OIL CHANGE, INDICATING LOW OIL PRESSURE AND/OR SES LAMP WILL ILLUMINATE. MODEL 2007-13 CANYON, SIERRA, SAVANA, YUKON, CTS-V, ESCALADE, AVALANCHE, CAMARO SS, COLORADO, CORVETTE, EXPRESS, SILVERADO, SUBURBAN, TAHOE. *PE |
| UIB-117 | 2015-08-22. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. GENERAL MOTORS: AN OPTIONAL ENGINE BLOCK HEATER PLUG IN FOR ONBOARD AC POWER AND WITH CONTINUOUS USAGE WILL RESULT IN SHORTING OF WIRES, OVER HEATING SYSTEM, ELECTRICAL FAILURE AND COMPARTMENT ENGINE FIRES. MODEL 2003-15 EXPRESS CUT AWAY VANS, SILVERADO CHASSIS CAB, SAVANA CUT AWAY VANS, SIERRA CHASSIS CAB. *PE |
| SB-080604003-C | 2014-11-08. Service bulletin. ENGINE; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE). GMC/CHEVROLET: ENGINES, WITH EGR SYSTEM, HAS LEAKAGE FROM EGR COOLER ENGINE COOLANT INTO THE COMBUSTION CHAMBER. MODEL 2002-15 SILVERADO, SIERRA, 2004-09 KODIAK C4500-C5500, TOPKICK C4500-C5500, 2006-15 EXPRESS, SAVANA. *PE |
| PI-0474 | 2011-06-27. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:DIESEL. GM: AN 'ENGINE POWER IS REDUCED' MESSAGE APPEARS AND THERE IS A STORED TROUBLE CODE. THIS IS CAUSED BY WEAR OF THE INTERNAL FUEL INJECTOR. *RM |
| PIP-4888 | 2011-06-24. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER. GM: INFORMATION ON INSPECTING AND REPLACING TURBOS. *RM |
| PIP-4138K | 2011-06-08. Service bulletin. ENGINE AND ENGINE COOLING. GM: THE SERVICE ENGINE SOON LIGHT IS ON, THERE IS ALSO A MISFIRE OR ENGINE NOISE. THERE ARE MULTIPLE POSSIBLE CAUSES. *RM |
| 09-06-93-003B | 2011-05-25. Service bulletin. ENGINE AND ENGINE COOLING. GM: CHECK ENGINE LIGHT IS ON WITH NUMEROUS POSSIBLE FAULT CODES. THERE MAY BE A SHORT IN A TURBOCHARGER SENSOR. *RM |
| PIP-4857 | 2011-05-25. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER; FUEL SYSTEM, DIESEL. GM: THERE MAY BE REDUCED POWER AND AN INTERNAL TROUBLE CODE IN HIGH TEMPERATURES OR WHEN NEAR THE TOWING LIMIT. *RM |
| PIP-4851 | 2011-05-24. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. GM: THERE IS AN INTERMITTENT ENGINE LIGHT ON DUE TO FIVE POSSIBLE INTERNAL TROUBLE CODES. THERE MAY ALSO BE AN EXTENDED CRANK AFTER FILLING THE FUEL TANK. *RM UPDATED 5/31/11. *PE UPDATED ON 06/16/2011. *KB UPDATED A SECOND TIME ON 06/16/2011. *KB |
| PIP-4492P | 2011-03-16. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV). BUICK/CADILLAC/CHEVROLET/GMC/HUMMER/PONTIAC/SAAB: OIL CONSUMPTION AND/OR EXHAUST SMOKE-POSSIBLE PCV BAFFLE OR LIFTER CONCERN. UPON INSPECTION, OBVIOUS OIL WILL BE FOUND IN THE INTAKE MANIFOLD AND/OR PCV VACUUM TUBE. *PE UPDATED 3/21/11. *PE UPDATED 5/9/11. *PE UPDATED 5/25/11. *PE UPDATED 06/16/2011. *KB UPDATED A SECOND TIME ON 06/16/2011. *KB UPDATED 6/27/11. *PE |
| PIT-5028 | 2011-03-14. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. PONTIAC/SATURN/BUICK/GMC/CHEVROLET/CADILLAC/HUMMER: VEHICLE START AND STALLS AFTER THEFT DETERRENT MODULE REPLACEMENT. MODEL YEARS 2006-2011. DOES NOT APPLY TO VEHICLES WITH KEYLESS ACCESS SYSTEM. *PE |
| PIP-4660 | 2010-06-08. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:DIESEL. GMC/CHEVROLET: ENGINE COOLANT SENSOR DTCS P011A, P2184, AND P2185. DEALER MAY ENCOUNTER CONCERN OF SES LIGHT ON OR DTCS P011A, P2184 AND P2185. DIESEL ENGINES HAVE 2 ECT (ENGINE COOLANT TEMPERATURE) SENSORS. *PE |
| SB- 09285 | 2010-03-05. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. GMC CHEVROLET SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SERVICE ENGINE SOON LIGHT ILLUMINATED-EXHAUST GAS RECIRCULATION (EGR) COOLER PLUGGING PREVENTION. *PE |
| PIP-4636 | 2009-11-24. Service bulletin. ELECTRICAL SYSTEM:WIRING; ENGINE AND ENGINE COOLING:ENGINE:DIESEL. CHEVROLET/GMC: TURBO VANE POSITION SENSOR WIRE CHAFE; REDUCED POWER AND/OR THE SES/MIL LIGHT ON. INITIAL DIAGNOSIS MAY REVEAL ONE OR A COMBINATION OF TURBO DTCS P003A, P0234, P0401, P0402, P0652, P0698, P0699, P2563. IF ONE OR COMBINATION OF DTCS HAVE BEEN FOUND, INSPECT FOR A WIRE CHAFE ON THE VPS (VANE POSITION SENSOR). *PE |
| PIP-4629 | 2009-08-19. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:DIESEL; ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER. CHEVROLET/GMC: DIESEL ENGINE TURBO DTC P2563 OR P003A. MAY ENCOUNTER A CONCERN OF SES LIGHT, REDUCED POWER, LOW POWER. *PE |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.