WenmarOpen by Wenmar Pro

Service bulletins for the 2009 Chevrolet Aveo

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

916 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

By topic

Bulletins, newest first
PI-0524-A2012-03-12. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. PONTIAC/CHEVROLET: SOME MODEL YEAR VEHICLES MAY EXPERIENCE, AFTER A COLD START, A NON INCREASE IN ENGINE POWER, INTERMITTENTLY, WHEN ACCELERATING TO HIGHWAY SPEEDS. *PE
PIC-5247A2011-06-27. Service bulletin. SUSPENSION:FRONT:CONTROL ARM. GM: THERE IS A POP, RATTLE, OR SNAP IN THE FRONT OF THE VEHICLE WHEN GOING OVER BUMPS AT A LOW SPEED. 2008-2011 AVEO/G3. *RM
PI-0011A2011-06-15. Service bulletin. LATCHES/LOCKS/LINKAGES:DOORS:LATCH. GM: THE FRONT OR REAR DOOR MAY NOT OPEN FROM THE INSIDE OR OUTSIDE HANDLE, THE DOOR WILL NOT UNLOCK WITH ANY METHOD. THE PROBABLY CAUSE AN INCORRECT INSTALLATION OF A HANDLE COMPONENT. *RM UPDATED ON 7/26/2013. ALL 2014 AND PRIOR GM PASSENGER CARS AND TRUCKS. *KB
10-00-89-017C2011-06-14. Service bulletin. UNKNOWN OR OTHER. GM: INFORMATION ON FIXING MULTIPLE SITUATIONS RIGHT THE FIRST TIME. *RM
09-09-40-001A2011-06-14. Service bulletin. SEAT BELTS:FRONT:WARNING LIGHT/DEVICES; SEAT BELTS. GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. *RM UPDATED 4/3/12. *PE
SB-10-06-04-0162011-06-13. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. GM: THERE MAY BE A LACK OF POWER OR A RATTLE NOISE FROM THE ENGINE WITH STORED TROUBLE CODES. *RM
05-09-40-002E2011-05-11. Service bulletin. SEAT BELTS:FRONT:WEBBING; SEAT BELTS:FRONT:RETRACTOR. GM: SERVICE BULLETIN EXPLAINING WHEN THE SAFETY BELTS ARE SUPPOSED TO LOCK. *RM UPDATED 12/6/11. *PE
SB-10-06-04-0112011-03-05. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. CHEVROLET: INTERMITTENT OR CONTINUOUS HIGH ENGINE RPM WHEN IDLING AT NORMAL OR WARMER OPERATING TEMPERATURES (INSTALL REPLACEMENT THROTTLE POSITION SENSOR (TPS) ELECTRICAL HARNESS CONNECTOR KIT). *PE
SB-10-01-37-001A2010-11-10. Service bulletin. VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR. CHEVROLET: HVAC BLOWER MOTOR INOPERATIVE; BLOWER MOTOR OPERATES ON HIGH SPEED ONLY (REPLACE BLOWER MOTOR AND RESISTOR). THIS CONDITION MAY BE CAUSED BY AN OPEN RESISTOR. *PE
SB-10-01-34-0012010-11-08. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. CHEVROLET: HVAC BLOWER MOTOR INOPERATIVE, BLOWER MOTOR OPERATES ON HIGH SPEED ONLY (REPLACE BLOWER MOTOR AND RESISTER). THIS CONDITION MAY BE CAUSED BY AN OPEN RESISTOR. THE BLOWER MOTOR OPERATES CORRECTLY AFTER REPLACING THE RESISTER, BUT THE RESISTOR MAY FAIL AGAIN DUE TO A FAULTY BLOWER MOTOR. *PE
SB-09-06-04-016A2010-11-08. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE; ELECTRICAL SYSTEM:WIRING. CHEVROLET: ENGINEERING INFORMATION CLOSED/RESULTS PROVIDED-MIL/CHECK ENGINE LIGHT ON, REDUCED POWER MODE, DTCS P2101, P2135 SET. THE CAUSE OF THIS CONDITION MAY BE DUE TO POOR TERMINAL CRIMPS IN THE ENGINE WIRING HARNESS. *PE
SB-09-03-08-0072009-11-05. Service bulletin. SUSPENSION; SUSPENSION:FRONT:WHEEL BEARING. CHEVROLET: A GRINDING, HOWLING OR ROARING TYPE NOISE COMING FROM THE FRONT OF THE VEHICLE. THIS NOISE MAY BE MORE APPARENT ON TURNS. *PE
PIC-50922009-08-13. Service bulletin. ELECTRICAL SYSTEM:WIRING; ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS; ELECTRICAL SYSTEM. GENERAL MOTORS: PONTIAC/CHEVROLET HAVE INOPERATIVE IPC, WON'T SHIFT OUT OF PARK; BACKLIGHT/DIMMING INOP, SEVERAL FUSES COULD BE OPEN, INCLUDING 100A FUSE ON POSITIVE BATTERY CABLE, EMS 10A FUSE IN UBEC, IPC 15A FUSE IN UBEC, AUDIO/RKE 10A FUSE IN DASH FUSE PANEL. THESE SYMPTOMS HAVE BEEN ROOT CAUSED AND MAY BE THE RESULT OF BEING JUMP STARTED WITH JUMPER CABLES REVERSE. *PE
SB-08-05-25-0082009-05-06. Service bulletin. SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT; SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:WHEEL SPEED SENSOR/TONE RING; SERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR; SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:ABS WARNING LIGHT. CHEVROLET: INTERMITTENT ANTILOCK BRAKE SYSTEM (ABS) WARNING LIGHT ON; WHEEL SPEED SENSOR (WSS)DTCS SET. GM ENGINEERING IS ATTEMPTING TO DETERMINE THE ROOT CAUSE OF THE CONDITION. *PE UPDATED 3/1/10. *PE
PIC-3209-B2009-05-05. Service bulletin. FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM. GENERAL MOTORS: IT HAS BEEN IDENTIFIED THAT THE CURRENT FUEL GAUGE INACCURATE/INOPERATIVE DIAGNOSTICS IN SI-2000 ARE MISSING SOME VERY IMPORTANT INFORMATION. *PE UPDATED 2/16/11. *PE
PIC-4955A2008-11-25. Service bulletin. TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS. GMC: TIRE PRESSURE MONITOR LIGHT ON C0550. A DEFECTIVE TIRE PRESSURE SENSOR CAN BE ONE OF THE CAUSES. *PE

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.