WenmarOpen by Wenmar Pro

Service bulletins for the 2020 BMW 840i

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

176 on file from NHTSA, as of 2026-10-19.

By type

By component

Only bulletins with component: Electrical system are shown. Show all

Bulletins, newest first
B1104262026-08-03. Service bulletin. ENGINE; ELECTRICAL SYSTEM. The manual starting of electronic engine oil level measurement from inside the vehicle, usually afterperforming an engine oil service task, is inoperative or it may lock up at between a 15% to 30% completionrate.
B8402262026-07-31. Service campaign. ELECTRICAL SYSTEM. Once the Telematics Module (TCB2) enters sleep mode, a BMW Data Services trigger for Remote Services(remote engine start, lock/unlock/climate conditioning) will not be able to reactivate the TCB2. Due to this issue, Remote Services will not function in the vehicle when parked and locked.
B5211252025-08-24. Service bulletin. SEATS; ELECTRICAL SYSTEM. If the seat ventilation is deactivated via the switch or due to parking the vehicle, the fans in the seat cushionor under the seat cushion surface are unpleasantly loud. The fans speed up loudly twice and then turn off. The functionality of the fans is not impaired. This behavior only occurs after the vehicle had been programmed to I level S18A- 25-07-520 and higher; upto, but not including S18A- 25-07-551.
B6103212024-03-02. Service bulletin. ELECTRICAL SYSTEM; FUEL SYSTEM, GASOLINE:STORAGE:EVAPORATIVE EMISSIONS:CANISTER; ELECTRICAL SYSTEM:SOFTWARE. SITUATION BMW AG is conducting a Voluntary Emissions Recall (effective April 23, 2021) on a certain Model Year 2020 - 2021 BMW vehicles that were produced between August 13, 2019 and December 11, 2020. Do not deliver to a customer, a New, Certified Pre-Owned or Used vehicle subject to an emissions recall, until the vehicle is repaired. Do not use or sell replacement equipment/parts subject to an emissions recall. The 12 V battery’s dual storage system (DSS) may contain a software error which intermittently causes a continuous resetting of the microcontroller and communication failure. The error is displayed by a red Check Control message.
B6607202024-03-02. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. The functionality of the left rear SRR sensor could be reduced which would display the Driving Assistance Check Control Message.
B6608202024-03-02. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT. The functionality of the right rear SRR sensor could be reduced which would display the "Driving Assistance"- Check Control Message.
B5108192024-02-01. Service bulletin. VISIBILITY:POWER WINDOW DEVICES AND CONTROLS; ELECTRICAL SYSTEM. The basic conditions for initializing the power windows are not met.
B6105242024-02-01. Service bulletin. EQUIPMENT:ELECTRICAL:INFOTAINMENT; ELECTRICAL SYSTEM. The Central Information Display goes black intermittently due to resets of the Head Unit (HU-H3). FaultB7F8F9 â“ âHU-H: Resetâ will be stored in the HU-H3.
B6113052024-02-01. Service bulletin. ELECTRICAL SYSTEM. The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.
B5217232024-02-01. Service bulletin. ELECTRICAL SYSTEM; SEATS. Customer states one of the front seats is inoperative. The seat heater and power supply are inoperative. During the vehicle test, the seat module does not respond. The power supply fuse for the seat module isfound to have blown.
B6308212023-07-24. Service bulletin. EXTERIOR LIGHTING; ELECTRICAL SYSTEM. Headlight check control (CC) message 128 "High beam headlight failure" is displayed. The following fault codes are stored during a vehicle test: 80419A - Left high-beam headlight: Short circuit and/or 8041A5 - light outputs: Number of permitted short circuit cycles exceeded
B0902212023-07-24. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. With the introduction of the BMW Remote Software Upgrade, all Service Pack 18 vehicles and partial Service Pack 15 vehicles may receive new functionality or modifications in their features.
B8403232023-06-26. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT:ELECTRICAL:WIRELESS CHARGER/CRADLE. BMW AG has issued a Delivery Stop (effective February 9, 2023) on certain Model Year 2022 - 2023 BMW vehicles that were produced between June 29, 2022 and February 16, 2023. This was originally called ""Wireless Charging Tray"". Software in potentially affected vehicles may not recognize the removal of the digital key (Key Card or mobile phone) from the wireless charging tray, and thereby not meeting a federal requirement."
SIB6608232023-05-15. Service bulletin. ELECTRICAL SYSTEM:ADAS:HUD:CAMERA/SENSOR; ELECTRICAL SYSTEM:ADAS:DRIVER MONITORING:CAMERA/SENSOR. Issues with the various functions of the camera-based driver assistance systems (KAFAS system) can possibly lead to following customer complaints: KAFAS camera system deactivates itself, due to system restrictions that are not clear to the customer KAFAS camera system cannot be activated due to system restrictions that are not clear to the customer Road signs are sporadically not detected.
B8408222023-05-01. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. The 3G network in the US has been shut down. This means that only the 4G network will be available. In the 4G network, voice calls will be transferred via the Voice over LTE (VoLTE) function. For this purpose, the SIM card must perform an IMS registration in the mobile communication network. Due to a production error, the telematics control units were delivered without an IMS configuration. The Connected Drive voice services (Concierge Call, BMW Assistance, and emergency call voice) can no longer be used regionally in the US in vehicle with telematics control units ATM-1 and TCB-4G. Voice control of the vehicle and all other telephone (paired mobile devices) functions are not affected. Emergency call location data is unaffected.
B6109232023-05-01. Service bulletin. ELECTRICAL SYSTEM. The gear selector switch (GWS) consists of the control electronics circuit and the selector lever. The sensors for recording the gearshift lever position and for inhibiting inadvertent gearshifts are integrated in the control electronics.
SIB6624192022-08-22. Service bulletin. ELECTRICAL SYSTEM; EQUIPMENT. Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column. Note: Opening, closing and starting via the BMW Digital Key or the Digital Key Card are not affected.
SIB0901212022-07-18. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE; ELECTRICAL SYSTEM:SOFTWARE. BMW offers a new special ISTA Installation made available for Roadside Assistance / Mobile Service technicians. The new ISTA Version is also able to be used in case of a Remote Software Upgrade (RSU) programming failure to get the customer car reprogrammed on site. In case of a Remote Software Upgrade failure, the engine start is prevented for safety reasons until the vehicle is programmed correctly. Most of the errors occur when only one control unit fails to program correctly.
SIB6513122022-07-05. Service bulletin. ELECTRICAL SYSTEM. The Headunit High (HU-H), also called NBT, began replacing the Car Information Computer (CIC) on certain MY2013 vehicles with option 609 (as of 7/2012 production). This uses map North America NEXT. The Headunit High 2 (HU-H2), also called NBT-EVO, superseded the NBT HU and was introduced in 3/2014. This uses map North America EVO. The Headunit High 4 (HU-H4, also called MGU21) superseded the MGU starting with certain MY2021 vehicles with option code 6U3 Live Cockpit Professional. This uses map North America JOY. The ENTRY Media/Navigation (HU-B) is the low line business version of the navigation system and was introduced in 3/2014. This uses map North America ROUTE. The ENTRY NAV EVO (HU-B2) replaced Entry Media/Navigation as the low-line business version and was introduced in certain MY2018 vehicles. This uses map North America WAY.
B6107222022-05-31. Service bulletin. ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER. Check Control message (CCM) displays "Vehicle key missing" after engine start.
B8409172022-01-24. Service bulletin. EQUIPMENT; ELECTRICAL SYSTEM. While using the wireless charger, one or both of the following may occur: 1) The BMW display key or mobile phone becomes hot to the touch. 2) The device switches off due to over temperature (built-in device protection).
B8406212022-01-24. Service bulletin. EQUIPMENT; COMMUNICATION:MANUFACTURER TELEMATICS; ELECTRICAL SYSTEM. The SIM card installed in the telematics control unit (ATM2) connects to different mobile providers' networks. However, due to a missing parameter, this does not work and can cause disruption in BMW ConnectedDrive services in areas with insufficient network coverage.
B6624192022-01-24. Service bulletin. ELECTRICAL SYSTEM; ENGINE; STEERING. Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may not start when placing the key against the steering column.
B0010202021-12-27. Service bulletin. ELECTRICAL SYSTEM. BMW of North America (BMW NA) has made information available online to customers about software versions, including any changes to vehicle functionality that will result from each update.
B6116212021-12-20. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. The "energy management" Check control message (ID code 415) is falsely displayed when entering the vehicle.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.