WenmarOpen by Wenmar Pro

Service bulletin TSB_ENG259

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
TypeService bulletin
NHTSA id11024183
Published by NHTSA2025-10-09
Manufacturer's numberTSB_ENG259
Manufacturer's date2025-10-03
Campaign id or software versionCA2509
NHTSA componentENGINE; ELECTRICAL SYSTEM
Manufacturer's systemENG

NHTSA's summary

TECHNICAL SERVICE BULLETIN: ITM REPLACEMENT AND ECM LOGIC IMPROVEMENT (CA2509) - This bulletin provides information to replace the Integrated Thermal Management Module (ITM) and then upgrade the Engine Control Module ‘ECM’ system software on certain vehicles, in the event the Multifunction Indicator Lamp (MIL) is illuminated with DTC(s) P218100, P2181F0, and/or P2181F1 stored. This condition may occur due to degradation of the diaphragm inside the ITM. There are no drivability or other symptoms associated with this condition.

The document

The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.

Components

Electrical system, Engine

Trouble codes named

P2181

Vehicles listed
KIA SPORTAGE2023

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Recalls for the same vehicles and component
25V8740002025-12-17. TRAILER HITCHES; ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
23V2980002023-04-26. ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
20225002022-09-07. Electrical
22V6510002022-08-29. ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.

Other bulletins for the same vehicles and component
TSB_CLI049_R22026-09-02. Service bulletin. TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR – ELECTRICAL A/C COMPRESSOR - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Air Conditioning (A/C) compressor assembly on some 2011MY~ Optima Hybrid (TF HEV, JF HEV/PHEV), 2015MY~ Soul EV (PS EV), 2017MY~ Niro (DE HEV/PHEV/EV), 2022MY~ EV6 (CV), 2021MY~ Sorento (MQ4 HEV/PHEV), 2023MY~ Sportage (NQ5 HEV/PHEV), and 2023MY~ Niro (SG2 EV/HEV/PHEV) vehicles.
TSB_ELE4262026-08-27. Service bulletin. TECHNICAL SERVICE BULLETIN: AVN GEN 5.0 WIDE SOFTWARE UPDATE - This bulletin provides information on the Audio Video Navigation (AVN) system software update for certain vehicles equipped with AVN5W and Navigation System listed in the table below. Affected vehicles may overestimate travel times during route calculation.
TSB_ELE4162026-07-28. Service bulletin. TECHNICAL SERVICE BULLETIN: ON-BOARD CHARGER INSPECTION AND REPLACMENT (SA644) - This bulletin provides information related to charging system diagnosis and repair on certain Sportage (NQ5 PHEV) vehicles produced from December 13, 2022 through May 30, 2023. The affected vehicles may experience interrupted or inoperative high‑voltage battery charging due to an on‑board charger (OBC) internal malfunction. As a result, charging of the high-voltage battery may be interrupted or unavailable, with several diagnostic trouble codes (DTCs) stored related to the OBC unit. If this occurs, the vehicle can still be driven by the internal combustion engine.
TSB_ELE4222026-06-03. Service bulletin. TECHNICAL SERVICE BULLETIN: INFOTAINMENT SYSTEM SOFTWARE UPDATE USING UPDATE.KIA.COM - This bulletin provides information and service procedures for updating the infotainment systems on applicable Kia vehicles using the Kia Navigation Updater available at update.kia.com. The software update may improve system performance, enhance existing features, and apply the latest operating software for supported vehicles (2021-2026MY All Models).
TSB_ELE4172026-05-01. Service bulletin. TECHNICAL SERVICE BULLETIN: INFOTAINMENT SOFTWARE UPDATE PROCEDURE - This bulletin provides information on the process for downloading infotainment software updates and preparing USB for installation on applicable Kia vehicles. The software downloads and USB preparation process is similar across all supported platforms; however, in‑vehicle installation procedures vary by head unit type.
TSB_ELE3942026-03-31. Service bulletin. TECHNICAL SERVICE BULLETIN: AVN5.0W DTC P17A000 DAIGNOSTIC PROCEDURE - This bulletin provides information regarding a potential illuminated Malfunction Indicator Lamp (MIL) accompanied by DTC P17A000 on some 2022-2025MY Hybrid Electric Vehicles (HEV) and Plug-In Hybrid Electric Vehicles (PHEV) equipped with AVN5.0Wide head units listed below. This condition occurs when the Global Positioning System (GPS) module within the Audio Video Navigation (AVN) head unit, sends an inaccurate signal to the Hybrid Power Control Unit (HPCU), causing the DTC to set. There are no drivability symptoms associated with this condition.
SC325_TSB_R12026-02-26. Service bulletin. TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: AEWP INSPECTION AND REPLACEMENT (SC325) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to inspect and, if necessary, replace the Auxiliary Electric Water Pump (AEWP), control harness wiring, and/or engine room junction box for coolant intrusion and/or corrosion on certain 2022-2023MY Kia Hybrid and Plug-in Hybrid vehicles listed in the table below. The AEWP in the subject vehicles may crack internally and allow coolant to intrude into the AEWP circuitry. If coolant enters the AEWP circuitry, the Check Engine Light (CEL) may be illuminated with one or more DTCs listed on page 2. If the vehicle continues to be driven in this condition, the Active Air Flap (AAF) warning message can also activate, and coolant may eventually migrate through the wiring harness to the engine room junction block. This may result in a reduction of motive power and may cause the vehicle to release air pollutants which exceeds Federal and California standards. These standards were established to protect the public health and welfare from the dangers of air pollution.
TSB_ELE399_R12026-02-02. Service bulletin. TECHNICAL SERVICE BULLETIN: BMS DISCHARGE LOGIC IMPROVEMENT - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to upgrade the ‘BMS’ system software on certain 2023-2024MY Sportage HEV (NQ5 HEV) vehicles produced from February 15, 2022, through December 15, 2023, which may experience excessive discharging of the 12V lithium battery while parked, potentially resulting in a no-start condition.
TSB_ENG259_R12025-12-01. Service bulletin. TECHNICAL SERVICE BULLETIN: ITM REPLACEMENT AND ECM LOGIC IMPROVEMENT (CA2509) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to replace the Integrated Thermal Management Module (ITM) and then upgrade the Engine Control Module ‘ECM’ system software on certain vehicles, in the event the Multifunction Indicator Lamp (MIL) is illuminated with DTC(s) P218100, P2181F0, and/or P2181F1 stored. This condition may occur due to degradation of the diaphragm inside the ITM. There are no drivability or other symptoms associated with this condition
TSB_ELE355_R12025-09-23. Service bulletin. TECHNICAL SERVICE BULLETIN: AVNT COAXIAL CABLE REPLACEMENT - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to replace the Audio Video Navigation Telematics (AVNT) head unit coaxial cable on some 2023MY Sportage (NQ5a) vehicles produced from August 5, 2021 through May 25, 2023. The affected vehicles may experience the AVNT screen flickering ‘ON/OFF’ due to an intermittent contact of the coaxial cable connector with the AVNT head unit.