WenmarOpen by Wenmar Pro

Service bulletin B410424

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
TypeService bulletin
NHTSA id11022859
Published by NHTSA2025-09-06
Manufacturer's numberB410424
Manufacturer's date2025-08-20
NHTSA componentSTRUCTURE:BODY

NHTSA's summary

A groaning sound from the front of the vehicle while driving can be heard, particularly while cornering. The groaning sound can be heard in the A-pillar/instrument panel area.

The document

The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.

Components

Body and frame

Vehicles listed
BMW 330I2025
BMW 430I2025
BMW 530I2025
BMW 740I2025
BMW IX2025
BMW M32025
BMW M42025
BMW M52025
BMW X32025
BMW X42025
BMW X52025
BMW X62025
BMW X72025
BMW Z4 M40I2025

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Recalls for the same vehicles and component
24V9100002024-12-05. STRUCTURE:BODY:ROOF AND PILLARS; AIR BAGS

A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.

Other bulletins for the same vehicles and component
B5110262026-10-02. Service campaign. A gap between the rear left door seal and the side frame may allow moisture to enter. This can cause waterto splash onto occupants when the door is opened and may also increase wind and road noise.
B5111252026-09-28. Service bulletin. When pulling on the hood (highlighted inorange in the top photo) release lever (highlighted in orange in the bottomphoto; driver’s footwell shown ) , there is anoticeable lack of cable tension; and the hoodwill not unlock.
B5107262026-07-31. Service campaign. In the affected vehicles, an incorrect screwlocking device (circled) may have been usedfor the mounting bolts of the door latch locks.
B5112252026-07-03. Service bulletin. A “groaning” noise is heard from the tailgatewhen driving on rough roads.
B6412242026-05-18. Service bulletin. 1. Use of aftermarket accessory hang-on cellular phone holders and/or air fresheners can break the instrument panel air vent slats. Damage and/or issues caused by outside influences are not covered under the BMW limited warranties. Originally, the air vent slats were only repairable by replacing the entire front center dash vent assembly; which in some applications, also included the IHKA control module.
B6403202026-05-18. Service bulletin. The center console and front cup holder get noticeably too warm to the touch on long journeys with the interior "Heating on".
B5112242026-05-18. Service bulletin. There are two possible situations (rear left, right or both sides): A. The electric sunshade in the rear door does not function or sticks upon operation, and/or B. The electric sunshade is wavy.
B5106262026-04-27. Service bulletin. While driving on rough surfaces, a “tapping” noise can be heard from the tailgate area
InVeh-InApp-Comm2026-03-30. Over-the-air update. Under certain conditions when driving, the underbody baffles may not completely prevent water ingress. To correct this, the underbody baffles will be re-sealed.
InVeh-InApp-Comm2026-03-30. Over-the-air update. There are body openings on the vehicle underbody, which are closed with paint plugs or adhesive pads. Your vehicle might not have been fitted with a paint plug on the vehicle underbody. Your vehicle will be checked for paint plugs on the underbody, and any missing paint plugs will be installed.