WenmarOpen by Wenmar Pro

Service bulletin 0824923

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
TypeService bulletin
NHTSA id10248940
Published by NHTSA2024-01-16
Manufacturer's number0824923
Manufacturer's date2023-11-21
NHTSA componentEXTERIOR LIGHTING

NHTSA's summary

Flash: Battery Pack Control Module (BPCM) Diagnostic and System Update Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs) have been set: ? P0607-00 - ECU Internal Performance. ? P0C78-00 - Hybrid/EV Battery System Precharge Time Too Long. This bulletin involves updating the BPCM with the latest available software.

The document

The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.

Components

Lighting

Trouble codes named

P0607, P0C78

Vehicles listed
JEEP WRANGLER2021

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Recalls for the same vehicles and component
24V6760002024-09-12. BACK OVER PREVENTION: SENSING SYSTEM: CAMERA; EXTERIOR LIGHTING:BRAKE LIGHTS
20217482021-12-10. Lights And Instruments
20213722021-06-11. Lights And Instruments

A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.

Other bulletins for the same vehicles and component
03002242024-03-18. Service bulletin. Front and Rear Axle Sensor Kit **Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code (DTC) has been set: ? C1451-11 - Service Axle Locker System** Customers may also comment on a Service Axle Locker message displayed in the Electronic Vehicle Information Center (EVIC) for this condition.
23004242024-03-18. Service bulletin. Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head lamp assemblies are fogged with a light layer of condensation on the inside of the lenses.
23029232024-01-02. Service bulletin. Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head lamp assemblies are fogged with a light layer of condensation on the inside of the lenses (Fig. 1) . This bulletin is to communicate the procedure for head lamp condensation clearing.
08048232024-01-02. Service bulletin. Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates Customers may experience a false Malfunction Indicator Lamp (MIL) illumination related to PHEV battery: ? P1A21-00 - HV Battery Contactor Control Sequence Incorrect. ? P0B3E-00 - Hybrid/EV Battery Voltage Sense 1 Circuit High. ? P0607-00 - ECU Internal Performance. ? P1E1B-00 - Hybrid/EV Battery Side Voltage System Isolation. ? P0AA4-00 - Hybrid Battery Negative Contactor Circuit Stuck Closed. ? P1C00-00 - Hybrid/EV Battery Voltage Sense 1 Out Of Range Low. ? P1C01-00 - Hybrid/EV Battery Voltage Sense 1 Out Of Range High. ? P1A9B-00 - Hybrid/EV Battery Temperature Sensor 1 Out Of Range High. ? P0BBD-00 - Hybrid Battery Pack Voltage Variation Exceeded Limit. ? P167B-00 - Controlled System Shutdown. ? U1885-00 - Battery Energy Control Module Lost Communication With HCP. ? P0EDD-00 - Hybrid/EV Battery Pack B Deterioration. ? U0111 - Lost Communication With Hybrid Battery Pack Sensor Module. ? P0CA7-00 - Hybrid/EV Battery Discharging Current High. ? P1A0C-00 - Battery Energy Control Module System Voltage Low. This bulletin involves updating the BPCM with the latest available software. NOTE: Additional module flashes are required for this update to be effective, the following modules are all to be updated along with this BPCM update: ? Powertrain Control Module (PCM). ? Integrated Dual Charging Module (IDCM). ? Transmission Control Module (TCM). ? Battery Pack Control Module (BPCM). ? Hybrid Control Processor (HCP), Auxiliary Hybrid Control Processor (AHCP) also known as the Power Inverter Module (PIM).
08047232024-01-02. Service bulletin. Flash: Integrated Dual Charging Module (IDCM) Enhancements Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following DTCs have been set: ? **B22A9-16 - ECU Internal Performance-Circuit Voltage Below Threshold. ? B22A9-17 - ECU Internal Performance-Circuit Voltage Above Threshold. ? B22A9-19 - ECU Internal Performance-Overcurrent.** ? B22A9-64 - ECU Internal Performance-Signal Plausibility Failure. ? P0D27-00 - Battery Charger 1 Input Voltage Too Low. Customer may also experience the following: ? **Unable to charge the vehicle with level 2 charger.** ? Vehicle would not charge and the charge station circuit breaker in the house / receptacle trips when its plugged into the vehicle. This bulletin involves reprogramming the IDCM with the latest software available. NOTE: Additional module flashes are required for this update to be effective, the following modules are all to be updated along with this IDCM update: ? Powertrain Control Module (PCM). ? Integrated Dual Charging Module (IDCM). ? Transmission Control Module (TCM). ? Battery Pack Control Module (BPCM). ? Hybrid Control Processor (HCP), Auxiliary Hybrid Control Processor (AHCP) also known as the Power Inverter Module (PIM).
S20250000012024-01-02. Service bulletin. Malfunction Indicator Lamp Illumination (MIL). Diagnostic Trouble Code (DTC) P203E ? Reductant Level Sensor 1 Circuit Intermittent-Erratic Set.
23029232023-04-17. Service bulletin. Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head lamp assemblies are fogged with a light layer of condensation on the inside of the lenses (Fig. 1) . This bulletin is to communicate the procedure for head lamp condensation clearing.
08048232023-04-17. Service bulletin. Flash: Battery Pack Control Module (BPCM) Diagnostic and System Updates Customers may experience a false Malfunction Indicator Lamp (MIL) illumination related to PHEV battery: ? P1A21-00 - HV Battery Contactor Control Sequence Incorrect. ? P0B3E-00 - Hybrid/EV Battery Voltage Sense 1 Circuit High. ? P0607-00 - ECU Internal Performance. ? P1E1B-00 - Hybrid/EV Battery Side Voltage System Isolation. ? P0AA4-00 - Hybrid Battery Negative Contactor Circuit Stuck Closed. ? P1C00-00 - Hybrid/EV Battery Voltage Sense 1 Out Of Range Low. ? P1C01-00 - Hybrid/EV Battery Voltage Sense 1 Out Of Range High. ? P1A9B-00 - Hybrid/EV Battery Temperature Sensor 1 Out Of Range High. ? P0BBD-00 - Hybrid Battery Pack Voltage Variation Exceeded Limit. ? P167B-00 - Controlled System Shutdown. ? U1885-00 - Battery Energy Control Module Lost Communication With HCP. ? P0EDD-00 - Hybrid/EV Battery Pack B Deterioration. ? U0111 - Lost Communication With Hybrid Battery Pack Sensor Module. ? P0CA7-00 - Hybrid/EV Battery Discharging Current High. ? P1A0C-00 - Battery Energy Control Module System Voltage Low. This bulletin involves updating the BPCM with the latest available software. NOTE: Additional module flashes are required for this update to be effective, the following modules are all to be updated along with this BPCM update: ? Powertrain Control Module (PCM). ? Integrated Dual Charging Module (IDCM). ? Transmission Control Module (TCM). ? Battery Pack Control Module (BPCM). ? Hybrid Control Processor (HCP), Auxiliary Hybrid Control Processor (AHCP) also known as the Power Inverter Module (PIM).
08047232023-04-17. Service bulletin. Flash: Integrated Dual Charging Module (IDCM) Enhancements Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following DTCs have been set: ? **B22A9-16 - ECU Internal Performance-Circuit Voltage Below Threshold. ? B22A9-17 - ECU Internal Performance-Circuit Voltage Above Threshold. ? B22A9-19 - ECU Internal Performance-Overcurrent.** ? B22A9-64 - ECU Internal Performance-Signal Plausibility Failure. ? P0D27-00 - Battery Charger 1 Input Voltage Too Low. Customer may also experience the following: ? **Unable to charge the vehicle with level 2 charger.** ? Vehicle would not charge and the charge station circuit breaker in the house / receptacle trips when its plugged into the vehicle. This bulletin involves reprogramming the IDCM with the latest software available. NOTE: Additional module flashes are required for this update to be effective, the following modules are all to be updated along with this IDCM update: ? Powertrain Control Module (PCM). ? Integrated Dual Charging Module (IDCM). ? Transmission Control Module (TCM). ? Battery Pack Control Module (BPCM). ? Hybrid Control Processor (HCP), Auxiliary Hybrid Control Processor (AHCP) also known as the Power Inverter Module (PIM).
S20250000012023-04-17. Service bulletin. Malfunction Indicator Lamp Illumination (MIL). Diagnostic Trouble Code (DTC) P203E ? Reductant Level Sensor 1 Circuit Intermittent-Erratic Set.