Service bulletin 2400115
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10229207 |
| Published by NHTSA | 2023-01-09 |
| Manufacturer's number | 2400115 |
| Manufacturer's date | 2015-02-27 |
| NHTSA component | FUEL SYSTEM, GASOLINE; FUEL SYSTEM, DIESEL |
NHTSA's summary
Slight Diesel Odor In The Vehicle This bulletin involves replacing the existing paper cabin filter with an updated charcoal filter. Customers may experience a slight diesel odor inside the vehicle.
The document
The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.
Components
Fuel system
| JEEP GRAND CHEROKEE | 2014 |
|---|
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 2022303 | 2022-06-09. Fuel System |
|---|---|
| 22V406000 | 2022-06-09. FUEL SYSTEM, DIESEL:DELIVERY:FUEL PUMP |
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| 105038 | 2025-05-20. Service bulletin. TUBE - FUEL INJECTOR SUPPLY & GASKET - NONE |
|---|---|
| 105039 | 2025-05-16. Service bulletin. TUBE - FUEL INJECTOR SUPPLY & GASKET - NONE |
| 102812 | 2025-03-05. Service bulletin. RAIL - FUEL |
| 9100494 | 2025-01-30. Service bulletin. FUEL PUMP/LEVEL UNIT MODULE For vehicles with Saddle Fuel Tanks, need to determine if there are any DTCs in wiTECH. Follow Service Diagnostics published prior to making any changes. Review any existing SOL or TSBs published for customer complaint issue. Only the Fuel Pump Module should be replaced if there are DTCs associated with the Fuel Level Sensor number 1. Only the Auxiliary Level Sender should be replaced if there are DTCs associated with the Fuel Level Sensor number 2. If there is a mixture of DTCs between the Fuel Pump Module and the Auxiliary Level Sensor, then investigate if there is a Jumper Harness or circuit issue between the Level Sender and the PCM. Verify fuel transfer between auxiliary tank and the primary tank by monitoring the auxiliary level sensor to verify it drops after driving. |
| S1625000005 | 2022-10-17. Service bulletin. (Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR Inducement - Forced Engine Shutdown. |
| 2400115 | 2022-10-17. Service bulletin. Slight Diesel Odor In The Vehicle This bulletin involves replacing the existing paper cabin filter with an updated charcoal filter. Customers may experience a slight diesel odor inside the vehicle. |
| 1400115 | 2022-10-17. Service bulletin. Diesel Fuel Filter Weepage in Extreme Cold Conditions This bulletin involves installing a new fuel/ water separator filter. Diesel fuel weepage from bottom of the vehicle when a cold soaked vehicle is started at temperatures of -13 F (-25 C) or below when using artic diesel fuel or a cold weather diesel fuel additive. |
| 9003704 | 2022-09-26. Service bulletin. Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. The fluid in the 8 speeds can be detected with a black light and there are aftermarket spray on leak detection materials to help ensure that the leak is properly diagnosed and not from another location such as cooler lines, heater tubes, or case porosity. Please note that the transmission pan gasket is available for many of the 8 speed applications FCA offers. Please review the available quick connect and transfer tube parts, as replacement of the TMU may not be required. If a TOC line connection is found to be the source, the quick connect may need replacement. If the leak source is coming from the connection of the TMU to the transmission, the transfer tube may need replacement. When parts are returned to the QEC the retaining clips (snap ring) for the quick disconnect fittings are missing. (This leaves a question as to whether the clips were missing from the assembly plant, or the technician removed them in order to make line removal easier.) Please return the clips with the transmission heater and note if they were not there to begin with. For any questions regarding transmission heater, contact FCA Redacted Content. If no response in 15 minutes, proceed with repair. |
| 24-001-15 | 2022-09-26. Service bulletin. Slight Diesel Odor In The Vehicle This bulletin involves replacing the existing paper cabin filter with an updated charcoal filter. Customers may experience a slight diesel odor inside the vehicle. |
| 14-001-15 | 2022-09-26. Service bulletin. Diesel Fuel Filter Weepage in Extreme Cold Conditions This bulletin involves installing a new fuel/ water separator filter. Diesel fuel weepage from bottom of the vehicle when a cold soaked vehicle is started at temperatures of -13 F (-25 C) or below when using artic diesel fuel or a cold weather diesel fuel additive. |