Service bulletin 68206041A
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10218270 |
| Published by NHTSA | 2022-08-22 |
| Manufacturer's number | 68206041A |
| Manufacturer's date | 2016-06-22 |
| NHTSA component | POWER TRAIN |
NHTSA's summary
Fan Support Assembly, Fan Support Bearing, Fan Pulley If you are replacing this part due to fan hub bearing failure, please also replace the fan clutch assembly using current Mopar stock (part number 52014729A$).~ Once installed, contact Christine Donegan at (866) 799-1692 ext 1257 to initiate a fast track request for the return of the parts for analysis.
The document
The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.
Components
Transmission and driveline
| RAM 2500 | 2013, 2014, 2015, 2016 |
|---|---|
| RAM 3500 | 2013, 2014, 2015, 2016 |
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 2017659 | 2017-12-21. Powertrain |
|---|---|
| 17V821000 | 2017-12-20. POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT |
| 16V495000 | 2016-07-01. POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) |
| 2016337 | 2016-06-29. Powertrain |
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| 102307 | 2025-01-06. Service bulletin. GEAR - REACTION SUN |
|---|---|
| 102387 | 2025-01-04. Service bulletin. SEAL - OUTPUT SHAFT |
| 102389 | 2025-01-04. Service bulletin. SEAL - OUTPUT SHAFT |
| 101232 | 2024-11-07. Service bulletin. Plate - Planetary |
| 2103714 | 2023-02-21. Service bulletin. 66RFE Transmission Slip Under High Engine Load And Premature Wear |
| 1803014 | 2023-02-21. Service bulletin. 6.7L Diagnostic and System Improvements |
| 1800114 | 2023-02-21. Service bulletin. Powertrain Diagnostic And System Enhancements |
| S1623000028 Rev. | 2023-02-13. Service bulletin. Outside Power Fold Rearview Mirror Noise Or Loose At Pivot. Mirror Contacts Door Window Glass In The Folded Position. |
| 1813022REVA | 2023-01-17. Service bulletin. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. The customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following DTCs: P20EE - SCR NOx Catalyst Efficiency Below Threshold - Bank 1. P1C54 - SCR NOx Catalyst Missing. P229F - Aftertreatment NOx Sensor Circuit Performance - Bank 1 Sensor 2. P207F - Reductant Quality Performance. P2002 - Diesel Particulate Filter Efficiency Below Threshold. P2201 - Aftertreatment NOx Sensor Circuit Performance - Bank 1 Sensor 1. P202E - (Diesel Exhaust Fluid) Reductant Injector Performance. P0300 - Multiple Cylinder Misfire. P0301-00 - Cylinder 1 Misfire. P0302-00 - Cylinder 2 Misfire. P0303-00 - Cylinder 3 Misfire. P0304-00 - Cylinder 4 Misfire. P0305-00 - Cylinder 5 Misfire. P0306-00 - Cylinder 6 Misfire. P249E - Closed Loop SCR Reductant Injection Control At Limit - Flow Too High. P0128 - Thermostat Rationality. P218F - Reductant No Flow Detected. U0001-00 - CAN C BUS. P24A5 - EGR Cooler Bypass Bank 1 Control Stuck. P1451 - Diesel Particulate Filter System Performance. P229E - NOx Sensor Circuit - Bank 1 Sensor 2. P0218 - Transmission High Temperature Operation Activated (68RFE Only). P0868 - Line Pressure Low, MIL Action (68RFE Only). U110E - Lost Ambient Temperature Message. P205E - (Diesel Exhaust Fluid) Reductant Tank Temperature Sensor Circuit Intermittent (setting when the block heater is plugged in). The following DTCs have been changed from a one trip fault to a two trip fault:P0421 - Catalyst 1 Efficiency Below Threshold Bank 1. P2280 - Air Flow Restriction / Leak Between Air Cleaner And MAF. P203C - (Diesel Exhaust Fluid) Reductant Level Sensor Circuit Low. P208D - (Diesel Exhaust Fluid) Reductant Pump Control Circuit High. In addition to addressing the above DTCs, |
| 1813022 | 2023-01-17. Service bulletin. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. The customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following DTCs. P0401 - EGR System Performance. P2281 - Air Leak Between MAF and Throttle Body. P0402 - Egr Flow Excessive Detected. P0234 - Turbocharger Overboost Condition. P049D - Egr Control Position Exceeded Learning Limit. P040B - Exhaust Gas Recirculation Temperature Sensor "A" Circuit Performance. P064F - Unauthorized Software/Calibration Detected. P20EE - SCR NOx Catalyst Efficiency Below Threshold - Bank 1. P1C54 - SCR NOx Catalyst Missing. P229F -Aftertreatment NOx Sensor Circuit Performance - Bank 1 Sensor 2. P207F - Reductant Quality Performance. P2002 - Diesel Particulate Filter Efficiency Below Threshold. P2201 - Aftertreatment NOx Sensor Circuit Performance - Bank 1 Sensor 1. P202E - (Diesel Exhaust Fluid) Reductant Injector Performance. P0300 - Multiple Cylinder Misfire. P0301-00 - Cylinder 1 Misfire. P0302-00 - Cylinder 2 Misfire. P0303-00 - Cylinder 3 Misfire. P0304-00 - Cylinder 4 Misfire. P0305-00 - Cylinder 5 Misfire. P0306-00 - Cylinder 6 Misfire. P249E - Closed Loop SCR Reductant Injection Control At Limit - Flow Too High. P0128 - Thermostat Rationality. P218F - Reductant No Flow Detected. U0001-00 - CAN C BUS. P24A5 - EGR Cooler Bypass Bank 1 Control Stuck. P1451 - Diesel Particulate Filter System Performance. P229E - NOx Sensor Circuit - Bank 1 Sensor 2. P0218 - Transmission High Temperature Operation Activated (68RFE Only). P0868 - Line Pressure Low, MIL Action (68RFE Only). U110E - Lost Ambient Temperature Message. P205E - (Diesel Exhaust Fluid) Reductant Tank Temperature Sensor Circuit Intermittent (setting when the block heater is plugged in). |