WenmarOpen by Wenmar Pro

Service bulletin SSM 50323

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
TypeService bulletin
NHTSA id10205446
Published by NHTSA2021-12-26
Manufacturer's numberSSM 50323
Manufacturer's date2021-12-07
NHTSA componentENGINE AND ENGINE COOLING

NHTSA's summary

Some 2017-2022 F-Super Duty and 2016-2022 F-650/F-750 with 6.7L diesel engines, 2015-2019 Transit with 3.2L diesel engines and 2018-2021 F-150 with 3.0L diesel engines may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P206C in the powertrain control module (PCM). Review of repair data supports that P206C is often the result of incorrect diesel exhaust fluid (DEF) concentration. Per Powertrain Control/Emissions Diagnosis (PC/ED) Pinpoint Test (PPT) RJ, a DEF concentration reading below 28% will set P206C and cause vehicle derate. If low concentration is suspected, drain fluid and replace with known good DEF before replacing any parts. Low concentration of DEF is not a warrantable condition.

The document

The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.

Components

Engine

Trouble codes named

P206C

Vehicles listed
FORD F-1502018, 2019, 2020, 2021
FORD F-250 SD2017, 2018, 2019, 2020, 2021, 2022 (the catalog's model; the bulletin names a series or trim of it)
FORD F-350 SD2017, 2018, 2019, 2020, 2021, 2022 (the catalog's model; the bulletin names a series or trim of it)
FORD F-450 SD2017, 2018, 2019, 2020, 2021, 2022 (the catalog's model; the bulletin names a series or trim of it)
FORD F-550 SD2017, 2018, 2019, 2020, 2021, 2022 (the catalog's model; the bulletin names a series or trim of it)
FORD F-650 SD2016, 2017, 2018, 2019, 2020, 2021, 2022 (the catalog's model; the bulletin names a series or trim of it)
FORD F-750 SD2016, 2017, 2018, 2019, 2020, 2021, 2022 (the catalog's model; the bulletin names a series or trim of it)
FORD TRANSIT2015, 2016, 2017, 2018, 2019

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Recalls for the same vehicles and component
20244922024-08-23. Engine
24V6350002024-08-23. ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL
19V2780002019-04-08. ENGINE; EQUIPMENT:ELECTRICAL
18V8940002018-12-18. ENGINE
20175152017-10-24. Engine
17V6720002017-10-23. ENGINE
16V6180002016-08-24. FUEL SYSTEM, DIESEL; ENGINE AND ENGINE COOLING:ENGINE:DIESEL

A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.

Other bulletins for the same vehicles and component
SSM 552282026-10-12. Service bulletin. Some 2020-2026 Aviator/Explorer/F-150/Bronco/Ranger vehicles equipped with a 2.7L or 3.0L (non-diesel) engine may need the front engine cover removed and reinstalled for various reasons. The Workshop Manual (WSM), Section 303-01 Engine > Removal and Installation > Engine Front Cover service procedure has been updated to include a new essential special service tool (ESST) guide pin alignment tool (303-1790) that is used to align the engine front cover to the engine block, preventing the O-ring seal on the engine oil galley feed tube from getting damaged during installation.
26E022026-09-01. Other. NEW VEHICLE DELIVERY HOLD Emissions Recall 26E02 Certain 2016-2019 F-650 - 750 and 2017-2019 F-350 - 550 Vehicles Equipped With 6.7L Diesel Engines Crankcase Ventilation (CCV) Inspection And Replacement
26N032026-09-01. Other. Customer Satisfaction Program 26N03 Certain 2017-2019 Model Year Super Duty Vehicles w/ 6.7L Diesel Engines Diesel Particulate Filter Replacement, If Required After Dealer Evaluation
SSM 550982026-08-25. Service bulletin. Some 2013-2016 Super Duty vehicles equipped with a 6.7L diesel engine and 2015-2019 Transit vehicles equipped with a 3.2L diesel engine may not pass a state smog test due to the exhaust gas system (EGS) monitor that will not run after completing the exhaust gas sensor drive cycle located within Section 2 of the Powertrain Control/Emissions Diagnostics (PC/ED) Manual > Drive Cycles. This may be due to the vehicles diesel oxidation catalyst (DOC) age counter being under the 120-minute age requirement. There is an all-new "PCM Catalytic Converter Age Evaluation" application within the latest version of the Ford Diagnosis and Repair System (FDRS). Use this new FDRS application to determine the age (in minutes) of the DOC. If the age is less than 120 minutes, perform manual regenerations to increase the catalyst age counter to satisfy the monitor age requirement. If further assistance is needed, contact the technical assistance center (TAC). Note: this article only applies to the EGS monitor. Problems with other vehicle monitors not running successfully must be addressed using normal diagnostics located i
TSB 26-23752026-08-19. Service bulletin. This article supersedes TSB 26-2050 to increase the labor operation allowance of labor operations A and B. Some of the vehicles listed in the Model statement above may exhibit all of the following conditions: Poor shift quality Illuminated powertrain malfunction (wrench) indicator with diagnostic trouble codes (DTC) P2704 and P0771 stored in the PCM/TCM. This may be due to a calibration in the TCM and/or wear between the input shaft and the E clutch hub causing the input shaft O-rings to become damaged resulting in an open E clutch circuit. Additional model information: 6.7L Diesel Engine 2022-2024 F-550 or F-600 F-Super Duty vehicles built on or before 15-May-2024 with over 5,000 miles (8,000km)
25M012026-08-04. Other. Customer Satisfaction Program 25M01 Certain 2021 Model Year F-150 3.0L Diesel Engine and 2020-2022 Model Year Super Duty with 6.7L Diesel Engine Nitrogen Oxide (NOx) Sensor Replacement, If Required After Dealer Evaluation Reference: Emissions Recalls 22E02, 22E04, 23E01, and 25E09
25E092026-07-01. Emissions. NEW VEHICLE DEMONSTRATION / DELIVERY HOLD Emissions Recall 25E09 Certain 2022 Model Year F-250 - F-600 Vehicles with 6.7L Engines Powertrain Control Module Programming and Particulate Matter Sensor Installation
25N142026-07-01. Other. Certain 2022 Model Year F-250 - F-600 with 6.7L Diesel Engines One-Time Replacement for Diesel Particulate Filter Assembly Failures, If Required After Dealer Evaluation
22N05-S32026-07-01. Service bulletin. Customer Satisfaction Program 22N05 - Supplement #3 Certain 2022 Model Year Super Duty with 6.7L Diesel Engine One-Time Replacement for Diesel Particulate Filter Assembly If Required After Dealer Evaluation
TSB 26-22562026-06-22. Service bulletin. This article supersedes TSB 25-2572 to update the Parts List to correct the part number LC3Z-6006-L to LC3Z-6781-A, remove the flex plate bolts AL3Z-6379-BA from the parts list as these bolts are in kit LC3Z-6781-A, update the claim quantity of the part number W709771-S440 to 9 pieces (F-650/F750-Engine Replacement), W706447-S437 and W715068-S437 to 4 pieces, W712861-S439 to 8 pieces(F-Super Duty Pickup And Chassis Cab-Engine Replacement) / 8 pieces (F-53 Motorhome/F-59 Stripped Chassis Cab/F-650,F750 Engine Replacement) / W714286-S442 to 4 pieces (F-Super Duty Pickup And Chassis Cab-Camshaft and Tappet Repair / F-Super Duty Pickup And Chassis Cab-Engine Replacement), include LC3Z-6020-A for the Engine replacement lists, include 1 fuel injector seal kit to the Camshaft and Tappet repair lists, include 4 pieces of W520114-S440 to the E Series-Camshaft and Tappet Repair list, and update the engine oil part numbers XO-5W30-Q1SP and CXO-5W30-LSP6. Some of the vehicles listed in the Model statement above may exhibit an upper engine ticking or tapping noise at idle. Customers may also report experiencing ro