Service bulletin SSM 48578
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10171963 |
| Published by NHTSA | 2020-03-03 |
| Manufacturer's number | SSM 48578 |
| Manufacturer's date | 2020-02-24 |
| NHTSA component | EXTERIOR LIGHTING |
NHTSA's summary
Some 2013-2016 MKZ vehicles equipped with adaptive headlamps may exhibit a Check Headlamp System fault message in the instrument panel cluster (IPC) after the right headlamp is replaced. Diagnostic trouble code (DTC) B1D65 may also be stored in the headlamp control module (HCM). To correct this condition install a new right headlamp (13008). Right headlamps built on or after 17-Oct-2019, or reworked headlamp assemblies identified with a green dot on the box and/or a green paint mark on the headlamp near the part number label, will no longer have this issue. For claiming, use Causal Part (13008) and applicable Labor Times in the Service Labor Time Standards (SLTS) Manual.
The document
The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.
Components
Lighting
Trouble codes named
B1D65
| LINCOLN MKZ | 2013, 2014, 2015, 2016 |
|---|
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 2015179 | 2015-04-28. Lights And Instruments |
|---|---|
| 15V248000 | 2015-04-27. EXTERIOR LIGHTING:HEADLIGHTS |
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| 22R01-S1 | 2022-05-19. Service bulletin. Certain 2014 - 2015 Model Year, Fusion and MKZ and 2015 Model Year Mustang Vehicles Brake Stop Lamps Remain On - Under Safety Recall 22S02, in some of the affected vehicles, exposure to a high temperature, high humidity, and high salinity environment is causing the brake pedal “stop bumper” to disintegrate and fall off on some of the affected vehicles resulting in the brake stop lamps remaining on continuously, even when the brake pedal is not applied. If the brake pedal bumper is missing on automatic transmission vehicles, the engine can be started, and the transmission can shift out of park without depressing the brake pedal. For 22R01, owners will be instructed to request a repair under this regional program if their vehicle exhibits brake pedal concerns or if they are concerned about the brake pedals in their vehicles. |
|---|---|
| 22R01 | 2022-04-04. Service bulletin. Certain 2014-2015 Model Year, Fusion and MKZ and 2015 Model Year Mustang Vehicles - Brake Stop Lamps Remain On. Under Safety Recall 22S02, in some of the affected vehicles, exposure to a high temperature, high humidity, and high salinity environment is causing the brake pedal "stop bumper" to disintegrate and fall off on some of the affected vehicles resulting in the brake stop lamps remaining on continuously, even when the brake pedal is not applied. If the brake pedal bumper is missing on automatic transmission vehicles, the engine can be started, and the transmission can shift out of park without depressing the brake pedal. For 22R01, owners will be instructed to request a repair under this regional program if their vehicle exhibits brake pedal concerns or if they are concerned about the brake pedals in their vehicles. |
| SSM 48263 | 2019-11-05. Service bulletin. Some 2013-2016 MKZs vehicles with Adaptive Headlamps may exhibit a Check Headlamp System fault message in the instrument panel cluster (IPC) after one or both headlamps were replaced. Diagnostic trouble codes (DTCs) B1D64 and/or B1D65 may also be stored in the headlamp control module (HCM). Confirm the headlamps illuminate normally, but do not attempt additional repairs at this time. Engineering is investigating, monitor OASIS for updates. The swivel function will remain inoperative until a corrective action becomes available. The headlamps will continue to function to fully meet all applicable lighting requirements. |
| TSB-14-0175 | 2015-08-01. Service bulletin. FORD/LINCOLN: THE AMBIENT LIGHTING ON LINCOLN (MYLINCOLN TOUCH) VEHICLES WILL DEFAULT TO WHITE AND ON FORD (MYFORD TOUCH) VEHICLES WILL DEFAULT TO ICE BLUE AFTER THE IGNITION SWITCH CYCLE. *PE |
| TSB-14-0128 | 2015-01-16. Service bulletin. FORD/LINCOLN: SOME VEHICLES, AFTER ENGINE START UP, HAVE HEADLAMP SWITCH IN AN AUTO LAMP POSITION AND IS OPERATING INTERMITTENTLY. MODEL 2013-2014 FUSION, MKZ. *PE |
| TSB-14-0086 | 2014-11-14. Service bulletin. FORD/LINCOLN: WHEN HEADLAMP SWITCH IS IN AUTOLAMP POSITION, AFTER ENGINE START UP, THE AMBIENT LIGHTING IS INOPERATIVE, INTERMITTENTLY AND BODY CONTROL MODULE (BCM) NEEDS REPROGRAMMING TO LATEST CALIBRATION. MODEL 2013-2014 FUSION, MKZ. *PE |
| ASI-44419 | 2014-06-24. Service bulletin. FORD/LINCOLN: AFTER ENGINE HAS STARTED UP, THE AMBIENT LIGHTS ARE NOT COMING ON, INTERMITTENTLY, WHEN IN AUTO LAMP POSITION AND HEADLAMPS ARE ON NORMALLY. MODEL 2013-2014 FUSION TITANIUM, MKZ. *PE |