Service bulletin 22-016
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10169711 |
| Published by NHTSA | 2020-01-04 |
| Manufacturer's number | 22-016 |
| Manufacturer's date | 2019-12-10 |
| NHTSA component | EQUIPMENT ADAPTIVE/MOBILITY; WHEELS; POWER TRAIN; EQUIPMENT |
NHTSA's summary
This bulletin has been obsoleted and replaced by Safety Recall 19KWE.
The document
The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.
Components
Equipment and accessories, Transmission and driveline, Wheels
| KENWORTH T680 | 2020 |
|---|---|
| KENWORTH T880 | 2020 |
| KENWORTH W990 | 2020 |
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 20V506000 | 2020-08-26. POWER TRAIN:AXLE ASSEMBLY |
|---|---|
| 19V911000 | 2019-12-19. POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT; POWER TRAIN:DRIVELINE:DRIVESHAFT |
| 2019118 | 2019-03-07. Powertrain |
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| 26-035 | 2026-07-21. Service bulletin. Updated Eaton's TAIB0885EN Bulletin link. |
|---|---|
| E311 | 2025-09-03. Other. Condition, Chassis Affected, and Warranty sections updated with the following verbiage “E311 must be flagged and open in Service Information Record (SIR) at the time of RO open date to qualify.” Also, “Through Standard Warranty or any applicable active Extended Warranty” verbiage was removed from Warranty section. |
| 45-065 | 2023-10-03. Service bulletin. Certain T680 Next Gen Cummins X15 have fan hub bracket hardware that is under torqued and could become loose and/or fail. Procedures are available to replace and properly torque the hardware. |
| 02-174 | 2023-09-01. Service bulletin. Certain W990 hood-mounted engine air intake covers could loosen and rattle or separate from vehicle. New air intake covers are available with improved retention. Installation of new covers requires hood modification. Procedures are available for replacement of hood-mounted engine air intake covers. |
| 51-013 | 2022-03-04. Service bulletin. Due to major data carriers phasing out 3G networks, chassis currently utilizing first generation Peoplenet Mobile Gateway (PMG001) will experience severe 3G service degradation as early as January of 2022. Chassis currently utilizing 3G antennas as a primary antenna may experience this degradation |
| T012 | 2022-01-06. Service bulletin. Non-Safety Campaign: Drivers of vehicles equipped with PACCAR TX-12 transmissions may experience harsh shifts and gear grinding noise. Premature Main Drive Gear damage may occur due to clutch housing and main case countershaft bearing bore wear. |
| 26-038 | 2022-01-06. Service bulletin. Non-Safety Campaign: Eaton Endurant transmissions may experience premature Main Drive Gear damage due to clutch housing and main case countershaft bearing bore wear. A Clutch Housing Front Cover Kit will be installed to address the issue. |
| 02-160 | 2021-03-10. Service bulletin. Information Only – Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter. |
| 51-008 | 2021-02-01. Service bulletin. T680 predictive cruise control(PCC) incompatibility with cummins engine. |
| E275 | 2021-01-06. Service bulletin. Non-Safety Campaign - Vehicles included in Model Year 2021 Pre-Production Engine program have an Emissions Exemption label that must be replaced. The current Emissions Exemption label will expire on 12/31/2020 and requires a new label to extend the exempt |