WenmarOpen by Wenmar Pro

Service bulletin B160818

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
TypeService bulletin
NHTSA id10152660
Published by NHTSA2019-01-07
Manufacturer's numberB160818
Manufacturer's date2018-11-01
NHTSA componentFUEL SYSTEM, GASOLINE

NHTSA's summary

SERVICE ACTION: CHECK AND, IF NECESSARY, REPLACE THE FUEL DELIVERY UNIT. The fuel delivery unit (in-tank fuel pump) may be the incorrect part installed for the Model/Market.

The document

The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.

Components

Fuel system

Vehicles listed
BMW 530E2018
BMW 530I2017, 2018
BMW 540D2018
BMW 540I2017
BMW 640I2018
BMW 740E2017
BMW 740I2017
BMW 740LI2016 to 2017
BMW 750LI2016 to 2017
BMW F800 R2017
BMW M550I2017
BMW M760I2017

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Other bulletins for the same vehicles and component
B0104242024-10-20. Warranty extension. EVAP SYSTEM PURGE (VENT) VALVE EXT LTD WTY (ELW) 15 YEARS/150,000 MILES
B0110192024-07-02. Warranty extension. Component-Specific Extended Limited Warranty (ELW) Issues with the fuel supply module/level sensor assembly and its related components, the fuel doorcover pot (ejector and drive), the filler flap (door) itself and/or the emergency release mechanism arenot included under this extended warranty coverage.
B1601232024-02-01. Service bulletin. A vehicle arrives at your center to be diagnosed for a micro-leak in the fuel evaporative (EVAP) system(NVLD natural vacuum leak detection). For this condition, the following fault is stored in the DME: 190302 - fuel tank ventilation and scavenging air system, micro-leak: leakage more than 0.5mm For: Model vehicles other that the ones listed above, or for EVAP faults related to a “large leak,” after confirming that the fuel filler cap is fitted properly, then, proceed to follow the corresponding test plan
B1606232024-01-03. Service bulletin. Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE
B1601232023-07-24. Service bulletin. A vehicle arrives at your center to be diagnosed for a micro-leak in the fuel evaporative (EVAP) system (NVLD natural vacuum leak detection). For this condition, the following fault is stored in the DME: 190302 - fuel tank ventilation and scavenging air system, micro-leak: leakage more than 0.5 mm.
B1701212022-06-21. Service bulletin. The quick disconnect coupling on the cylinder head coolant vent line could break at the cylinder head. This would lead to loss of coolant from the engine.
B1105212022-05-31. Service bulletin. The belt pulley on the mechanical coolant pump may fracture allowing the engine drive belt to come off the coolant pump and alternator.
B1105212022-02-22. Service bulletin. The belt pulley on the mechanical coolant pump may fracture allowing the engine drive belt to come off the coolant pump and alternator.
B0113212021-07-19. Service bulletin. CLASS ACTION SETTLEMENT: N54/N54T/N55 ELECTRIC ENGINE COOLANT PUMP . With the court's FINAL approval, BMW of North America, LLC (BMW NA) has entered a nationwide settlement with the plaintiffs in the following class action: Oliver, et al v. BMW NA, et al
B1202212021-07-06. Service bulletin. SERVICE ACTION: INSPECTION OF THE ELECTRONIC WASTEGATE ACTUATOR CONNECTOR . Due to a software error, long charging times (10-12 hours) for the Plug-in Hybrid Electric Vehicle (PHEV) high-voltage battery may damage the internal printed circuit board and the electrical connection to the electronic wastegate actuator. A software error in the Digital Motor Electronics (DME).