Service bulletin TSB 18-2266
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10148703 |
| Published by NHTSA | 2018-11-19 |
| Manufacturer's number | TSB 18-2266 |
| Manufacturer's date | 2018-10-09 |
| NHTSA component | ENGINE AND ENGINE COOLING |
NHTSA's summary
Some 2015-2018 Transit vehicles equipped with a 3.5L or 3.7L engine may exhibit a lack of heat or uneven heat from side to side. This condition may be due to deposits from the engine coolant trapped in the heater core. Follow the Service Procedure steps to correct the condition.
The document
The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.
Components
Engine
| FORD TRANSIT | 2015, 2016, 2017, 2018 |
|---|
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 16V618000 | 2016-08-24. FUEL SYSTEM, DIESEL; ENGINE AND ENGINE COOLING:ENGINE:DIESEL |
|---|
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| SSM 55098 | 2026-08-25. Service bulletin. Some 2013-2016 Super Duty vehicles equipped with a 6.7L diesel engine and 2015-2019 Transit vehicles equipped with a 3.2L diesel engine may not pass a state smog test due to the exhaust gas system (EGS) monitor that will not run after completing the exhaust gas sensor drive cycle located within Section 2 of the Powertrain Control/Emissions Diagnostics (PC/ED) Manual > Drive Cycles. This may be due to the vehicles diesel oxidation catalyst (DOC) age counter being under the 120-minute age requirement. There is an all-new "PCM Catalytic Converter Age Evaluation" application within the latest version of the Ford Diagnosis and Repair System (FDRS). Use this new FDRS application to determine the age (in minutes) of the DOC. If the age is less than 120 minutes, perform manual regenerations to increase the catalyst age counter to satisfy the monitor age requirement. If further assistance is needed, contact the technical assistance center (TAC). Note: this article only applies to the EGS monitor. Problems with other vehicle monitors not running successfully must be addressed using normal diagnostics located i |
|---|---|
| SSM 54690 | 2026-04-06. Service bulletin. Some 2013-2016 Super Duty vehicles equipped with a 6.7L diesel engine and 2015-2019 Transit vehicles equipped with a 3.2L diesel engine may not pass a state smog test due to the exhaust gas system (EGS) monitor that will not run after completing the Exhaust Gas Sensor drive cycle located within Section 2 of the Powertrain Control/Emissions Diagnostics (PC/ED) Manual > Drive Cycles. This may be due to the vehicles diesel oxidation catalyst (DOC) age counter being under the 120-minute requirement. Engineering is investigating this issue and working on a solution. |
| SSM 52335 | 2024-03-20. Service bulletin. For 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak inspection and testing methods. Ford has evaluated turbochargers replaced for oil leak symptoms and although oil may collect on the external surface of a turbocharger, it is extremely rare for a turbocharger assembly to be the root cause of the oil leak. Careful inspection of the turbocharger oil feed and drain tubes should be performed along with the recommended WSM procedures as needed. Warranty claims for turbocharger replacement going forward will be assessed. |
| 23N04 | 2024-03-05. Service bulletin. Certain 2015-2019 Model Year Transit Vehicles Equipped With 3.2L Diesel Engine - Exhaust Gas Temperature (EGT) Sensor Replacement |
| 23N01 | 2023-10-03. Service bulletin. Certain 2015-2019 Model Year Transit Vehicles with 3.2L Diesel Engine - Crankcase Ventilation Hose Assembly Replacement and Powertrain Control Module Software Update |
| SSM 51033 | 2022-08-22. Service bulletin. Some 2015 Transit vehicles equipped with a 3.2L Duratorq-TDCi engine built on or after 06-Mar-2015 may set diagnostic trouble code (DTC) P2539 during a KOEO self-test. This DTC sets when the powertrain control module (PCM) does not detect a change in the fuel delivery pressure switch after engine shutdown. If DTC P2539 is not present after performing a key on engine running (KOER) self-test, there is no illuminated malfunction indicator lamp (MIL) while the engine is running, no drivability concerns, and no other DTCs, then P2539 should be ignored. No further service action is required. |
| 21M03 | 2022-02-04. Service bulletin. Certain 2017-2019 Model Year Transit Vehicles with a 3.2L Diesel Engine EGR Cooler Replacement- Owner Letter sent |
| 21M03-S1 | 2022-01-03. Service bulletin. Certain 2017-2019 Model Year Transit Vehicles with a 3.2L Diesel Engine EGR Cooler Replacement Vehicles Covered By This Program: The build date range for the affected vehicles was incorrectly listed as June 4, 2015 through October 24, 2019. The correct build date range is June 21, 2017 through October 24, 2019. |
| SSM 50323 | 2021-12-26. Service bulletin. Some 2017-2022 F-Super Duty and 2016-2022 F-650/F-750 with 6.7L diesel engines, 2015-2019 Transit with 3.2L diesel engines and 2018-2021 F-150 with 3.0L diesel engines may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P206C in the powertrain control module (PCM). Review of repair data supports that P206C is often the result of incorrect diesel exhaust fluid (DEF) concentration. Per Powertrain Control/Emissions Diagnosis (PC/ED) Pinpoint Test (PPT) RJ, a DEF concentration reading below 28% will set P206C and cause vehicle derate. If low concentration is suspected, drain fluid and replace with known good DEF before replacing any parts. Low concentration of DEF is not a warrantable condition. |
| TSB160001 | 2021-12-20. Service bulletin. 49 CFR Part 579.5 Monthly Communications - March 2016 Air bag warning light illuminated with diagnostic trouble code (DTC) B141B and/or B141C |