WenmarOpen by Wenmar Pro

Service bulletin 35460

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
TypeService bulletin
NHTSA id10090435
Published by NHTSA2017-02-03
Manufacturer's number35460
Manufacturer's date2016-03-30
NHTSA componentENGINE; ENGINE AND ENGINE COOLING:ENGINE:DIESEL

NHTSA's summary

35460 - CUSTOMER SATISFACTION PROGRAM. SOME VEHICLES EQUIPPED WITH A DURAMAX DIESEL ENGINE (RPO LML) MAY HAVE A CONDITION IN WHICH THE INTAKE AIR HEATER’S FIELD-EFFECT TRANSISTOR COULD GENERATE EXCESSIVE HEAT IF THE SYSTEM VOLTAGE EXCEEDS 13.5V. THIS HEAT CAN CAUSE A SHORT CIRCUIT IN THE TRANSISTOR AND, IN RARE CASES, A FIRE IN THE VEHICLE’S ENGINE COMPARTMENT. DEALERS ARE TO REPROGRAM AND UPDATE THE GLOW-PLUG CONTROL MODULE WITH NEW SOFTWARE WHICH LIMITS THE INTAKE AIR HEATER INPUT VOLTAGE TO 13.5V.

The document

No address for NHTSA's copy can be built for this communication. Ask the dealer for it by the manufacturer's number.

Components

Engine

Vehicles listed
CHEVROLET SILVERADO 15002015 (the catalog's model; the bulletin names a series or trim of it)
GMC SIERRA 15002015 (the catalog's model; the bulletin names a series or trim of it)

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Recalls for the same vehicles and component
20145772014-12-18. Engine
14V0070002014-01-13. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.

Other bulletins for the same vehicles and component
00-06-01-026R2025-12-03. Service bulletin. This service bulletin provides information on replacing the intake manifold when the engine is replaced after severe internal engine damage.
23-NA-1532025-10-25. Service bulletin. The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.
22-NA-0802025-10-16. Service bulletin. This technical bulletin provides a procedure to replace the camshaft actuator magnet to correct customer concerns of engine related shudder.
15-NA-0102025-07-07. Service bulletin. This service bulletin provides information to dealership personnel for new vehicles with less than 1,000 miles that may not pass California smog inspection or smog inspection in other states.
25-NA-0522025-04-28. Service bulletin. This bulletin advises the technician to flush the cooling system multiple times if oil has been found in the cooling system and replace the parts that may be contaminated due to oil in system.
25-NA-0522025-04-10. Service bulletin. This bulletin advises the technician to flush the cooling system multiple times if oil has been found in the cooling system and replace the parts that may be contaminated due to oil in system.
22-NA-0742025-02-12. Service bulletin. This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
21-NA-0432025-02-12. Service bulletin. This bulletin advises the dealers to maintain the vehicle stock on hand by doing a full inspection on the vehicles before being sold (prepping) to the customer.
20-NA-1662025-01-23. Service bulletin. This service bulletin advises the technician of possible coolant entering the areas of the engine, either through failed parts or defects in the castings, that may be the cause of the concerns related to the MIL or the engine running rough.
09-06-04-026Z2025-01-23. Service bulletin. This bulletin provides information on identifying Non-GM Engine Calibrations for Gasoline Engines using the Tech 2 or GDS 2.