Service bulletin TSB-09-20-5
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10032625 |
| Published by NHTSA | 2010-04-21 |
| Manufacturer's number | TSB-09-20-5 |
| Manufacturer's date | 2010-04-01 |
| NHTSA component | VEHICLE SPEED CONTROL:ACCELERATOR PEDAL; POWER TRAIN:DRIVELINE |
NHTSA's summary
FORD: SHUDDER OR VIBRATION ON ACCELERATION, ESPECIALLY WHEN LOADED. SOME SUPER DUTY VEHICLES WITH SINGLE REAR WHEELS (SRW) AND DUAL REAR WHEEL (DRW) MAY EXHIBIT AN EXCESSIVE DRIVE AWAY SHUDDER OR VIBRATION UNDER MODERATE TO HEAVY ACCELERATION FROM A STOP, ESPECIALLY WHEN HEAVILY LOADED. *PE
The document
No address for NHTSA's copy can be built for this communication. Ask the dealer for it by the manufacturer's number.
Components
Throttle and cruise control, Transmission and driveline
| FORD F SUPER DUTY | 2008 |
|---|---|
| FORD F-250 SD | 2008, 2009, 2010 (the catalog's model; the bulletin names a series or trim of it) |
| FORD F-350 SD | 2008, 2009, 2010 (the catalog's model; the bulletin names a series or trim of it) |
| FORD SUPER DUTY | 2009 to 2010 |
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 07V139000 | 2007-03-26. POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM) |
|---|
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| SSM 51909 | 2023-10-04. Service bulletin. When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of MERCON SP and can be used going forward. Mixing MERCON LV and MERCON SP in the same transmission is acceptable. After 30-Jun-2023, MERCON SP ATF will no longer be manufactured and will only be available until inventory depletes. |
|---|---|
| TSB160057 | 2021-12-20. Service bulletin. Torqshift Transmission - Malfunction indicator lamp (MIL) diagnostic trouble codes (DTCS) P0751, P0730 and/or P2700 |
| SSM 47976 | 2019-06-07. Service bulletin. On vehicles equipped with an automatic transmission it is imperative that the converter pilot hub be greased with Motorcraft Multi-Purpose Grease Spray XL-5-A even if grease was not applied from the factory. Also verify that the engine/transmission alignment dowel pins are present as well as the engine crankshaft dowel pin, if equipped, when installing the transmission. Failure to adequately lubricate the converter hub greatly increases the likelihood of the flexplate cracking in the future. Missing dowels may cause a misalignment issue also resulting in a premature failure. Refer to Workshop Manual (WSM), Section 307-01. |
| ASI-44534 | 2014-10-01. Service bulletin. FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *PE |
| TSB-13-12-22 | 2014-02-24. Service bulletin. FORD: THE MALFUNCTION INDICATOR LAMP (MIL) ON AND DIAGNOSTIC TROUBLE CODES (DTCS) P0713 AND/OR P0710 REGARDING TORQSHIFT TRANSMISSION. MODEL 2008-2009 F-53 MOTORHOME CHASSIS, LOW CAB FORWARD, 2008-2010 F-250, F-350, 2008-2011 E-350, E-450, F-450, F-550, 2011 F-53 MOTORHOME CHASSIS, F-50 COMMERCIAL STRIPPED CHASSIS. *PE |
| 12-3-15 | 2012-05-14. Service bulletin. FORD: SOME 2009- 2011 E-SERIES, F-SUPER DUTY-F-53 MOTORHOME AND F-59 STRIPPED CHASSIS VEHICLES EQUIPPED WITH A TORQSHIFT TRANSMISSION MAY EXHIBIT MIL WITH DTCS P0751, P0730 AND/OR P2700. *JS |
| CSP-11B23 | 2011-09-21. Service bulletin. FORD SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THERE ARE MULTIPLE PROBLEMS WITH THE VEHICLE. POSSIBLIY INCLUDING: MALFUNCTION LIGHT ON, RUNS ROUGH, REDUCED POWER, EXCESSIVE SMOKE FROM THE EXHAUST, FUEL SMELL FROM THE CRANKCASE, COOLANT LOSS, AND ENGINE NOISE. *RM |
| AS-21687 | 2011-07-07. Service bulletin. FORD: THERE MAY BE A LOSS OF POWER, HESITATION, SURGE, OR LACK OF THROTTLE RESPONSE WHILE DRIVING. THE BRAKE OVER ACCELERATOR FEATURE MAY BE ACTIVATING. *RM |
| AS-21769 | 2011-07-07. Service bulletin. FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM |
| CSP-10M05 | 2011-01-06. Service bulletin. FORD SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CATALYST Y PIPE WARRANTY EXTENSION.. IN SOME OF THE AFFECTED VEHICLES, CERTAIN VEHICLE OPERATING CONDITIONS CAN CAUSE THE CATALYST SUBSTRATE TO CRACK OR MELT. THIS CAN CAUSE SYMPTOMS INCLUDING BUT NOT LIMITED TO AUDIBLE NOISE FROM THE CATALYST Y PIPE AND/OR MALFUNCTION INDICATOR LAMP ILLUMINATION. CSC LETTER WAS RECEIVED. *PE |