{"vehicle":{"id":"2025_mazda_cx-70","year":2025,"make":"Mazda","model":"CX-70"},"code":"P0AA6","generic":true,"description":null,"bulletins":{"as_of":"2026-10-19","count":12,"bulletins":[{"nhtsa_id":11023704,"type":"warranty_extension","type_name":"Warranty extension","date_added":"2025-10-03","date":"2025-09-11","document_id":"SSPD9 Owner Ltr","mfr_campaign":"SSPD9","component":"ENGINE","summary":"SSPD9 – Adding coverage for Towing Subject: Notification of Warranty Extension Program - Special Service Program (SSP) D9 2024 CX-90 and 2025 CX-70, SKYACTIV-G 2.5 PHEV – Water Heater Malfunction Mazda Motor Corporation has decided to conduct a Special Service Program (SSP) to extend the warranty coverage for a specific repair of the water heater concern on certain MY2024 CX-90 PHEV and MY2025 CX-70 PHEV vehicles that are equipped with the suspected water heater. The warranty coverage for an applicable repair has been extended to 8 years (96 months) from the original warranty start date, with no mileage limitation. Concern Outline: On certain subject vehicles, while warming up the cabin after starting the vehicle in EV mode, the nichrome wire in the water heater may break or a decrease in insulation resistance may be detected, causing the concerns described below: 1) The heater does not work properly. 2) The hybrid system warning light may turn on and the DTC P0AA6:00 may be stored in memory. - P0AA6:00 – High voltage insulation malfunction: Decrease in vehicle insulation resistance. This is a warranty extension for the specified repair only. Inspection and replacement of non-failed parts will not be eligible for reimbursement under this SSP to the dealer or customer. This program extends the warranty period for actual failures due to defects in workmanship or materials in accordance with the Mazda Warranty Policy and Procedures. If a customer arrives at your dealership with the concern described, please repair the vehicle under this Special Service Program. SSPD9 – Water Heater Malfunction WARRANTY EXTENSION For certain 2024 CX-90 PHEV and 2025 CX-70 PHEV vehicles that are equipped with the suspected water heater, the warranty coverage for an applicable repair of the water heater has been extended to 8 years (96 months) from the original warranty start date, with no mileage limitation. CONDITION OF CONCERN While warning up the cabin using the water heater after starting the vehicle in EV mode, the nichrome wire in the water heater may break or a decrease in insulation resistance may be detected, causing the concerns described below: Heater performance may become poor: 1. The hybrid system warning light may turn on and the DTC P0AA6:00 may be stored. 2. P0AA6:00 – High voltage insulation malfunction: Decrease in vehicle insulation resistance OWNER NOTIFICATION Mazda will notify all U.S. owners of the subject vehicles by first class mail no later than September 1, 2025. • Owners will be advised that they do not need to bring their vehicle to a dealer if it does not exhibit the affected conditions. • Owners will also be advised that any previous repair on the water heater due to concerns related to this SSP will be eligible for reimbursement if the repair was performed at the owner’s expense. Please refer the customer to the Owner Letter for reimbursement instructions. NO COVERAGE FOR BRANDED AND OTHER LIMITATIONS - EXCLUDED COVERAGE • Per Warranty policy 3.26 all limitations apply to this Warranty Extension. There is no coverage for total loss/insurance/salvage or rebuilt titles (W1). If you are unsure about the policy please contact the Warranty Department. REPAIR PROCEDURE If you receive customer complaints about the check engine light ON with P0AA6:00 with any of the symptoms mentioned above, verify the concerns and perform appropriate repair according to the Service Information Technical Service Bulletin (TSB) No. 07-006/24. Note: Please always refer to the latest version of TSB.","document":{"url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11023704-0001.pdf","alternate_url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11023704-9999.pdf","confirmed":false},"url":"https://open.wenmarpro.com/bulletins/11023704"},{"nhtsa_id":11023695,"type":"service_bulletin","type_name":"Service bulletin","date_added":"2025-10-03","date":"2025-09-25","document_id":"07-006-25","mfr_campaign":null,"component":"UNKNOWN OR OTHER","summary":"Some customers may complain that the heater does not work properly and that a warning about a hybrid abnormality appears on the Instrument Cluster. Upon inspection, the vehicle may have DTC P0AA6:00 (High voltage insulation malfunction: Decrease in vehicle insulation resistance) stored in memory. This is caused by an inappropriate casting method of the water heater during the manufacturing process. To eliminate this concern, the casting method for the aluminum heat sink has been modified from low-pressure to high pressure casting and a seal has been added to the sheath pipe opening in the circuit board compartment.","document":{"url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11023695-0001.pdf","alternate_url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11023695-9999.pdf","confirmed":false},"url":"https://open.wenmarpro.com/bulletins/11023695"},{"nhtsa_id":11022773,"type":"warranty_extension","type_name":"Warranty extension","date_added":"2025-09-05","date":"2025-08-26","document_id":"SSPD9 Repair b","mfr_campaign":"SSPD9","component":"ENGINE","summary":"SSPD9 August 25, 2025 – Adding coverage for Towing Subject: Notification of Warranty Extension Program - Special Service Program (SSP) D9 2024 CX-90 and 2025 CX-70, SKYACTIV-G 2.5 PHEV – Water Heater Malfunction Mazda Motor Corporation has decided to conduct a Special Service Program (SSP) to extend the warranty coverage for a specific repair of the water heater concern on certain MY2024 CX-90 PHEV and MY2025 CX-70 PHEV vehicles that are equipped with the suspected water heater. The warranty coverage for an applicable repair has been extended to 8 years (96 months) from the original warranty start date, with no mileage limitation. Concern Outline: On certain subject vehicles, while warming up the cabin after starting the vehicle in EV mode, the nichrome wire in the water heater may break or a decrease in insulation resistance may be detected, causing the concerns described below: 1) The heater does not work properly. 2) The hybrid system warning light may turn on and the DTC P0AA6:00 may be stored in memory. - P0AA6:00 – High voltage insulation malfunction: Decrease in vehicle insulation resistance. This is a warranty extension for the specified repair only. Inspection and replacement of non-failed parts will not be eligible for reimbursement under this SSP to the dealer or customer. This program extends the warranty period for actual failures due to defects in workmanship or materials in accordance with the Mazda Warranty Policy and Procedures. If a customer arrives at your dealership with the concern described, please repair the vehicle under this Special Service Program. SSPD9 – Water Heater Malfunction WARRANTY EXTENSION For certain 2024 CX-90 PHEV and 2025 CX-70 PHEV vehicles that are equipped with the suspected water heater, the warranty coverage for an applicable repair of the water heater has been extended to 8 years (96 months) from the original warranty start date, with no mileage limitation. CONDITION OF CONCERN While warning up the cabin using the water heater after starting the vehicle in EV mode, the nichrome wire in the water heater may break or a decrease in insulation resistance may be detected, causing the concerns described below: Heater performance may become poor: 1. The hybrid system warning light may turn on and the DTC P0AA6:00 may be stored. 2. P0AA6:00 – High voltage insulation malfunction: Decrease in vehicle insulation resistance OWNER NOTIFICATION Mazda will notify all U.S. owners of the subject vehicles by first class mail no later than September 1, 2025. • Owners will be advised that they do not need to bring their vehicle to a dealer if it does not exhibit the affected conditions. • Owners will also be advised that any previous repair on the water heater due to concerns related to this SSP will be eligible for reimbursement if the repair was performed at the owner’s expense. Please refer the customer to the Owner Letter for reimbursement instructions. NO COVERAGE FOR BRANDED AND OTHER LIMITATIONS - EXCLUDED COVERAGE • Per Warranty policy 3.26 all limitations apply to this Warranty Extension. There is no coverage for total loss/insurance/salvage or rebuilt titles (W1). If you are unsure about the policy please contact the Warranty Department. REPAIR PROCEDURE If you receive customer complaints about the check engine light ON with P0AA6:00 with any of the symptoms mentioned above, verify the concerns and perform appropriate repair according to the Service Information Technical Service Bulletin (TSB) No. 07-006/24. Note: Please always refer to the latest version of TSB.","document":{"url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11022773-0001.pdf","alternate_url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11022773-9999.pdf","confirmed":false},"url":"https://open.wenmarpro.com/bulletins/11022773"},{"nhtsa_id":11022770,"type":"warranty_extension","type_name":"Warranty extension","date_added":"2025-09-05","date":"2025-08-21","document_id":"SSPD9 Repair a","mfr_campaign":"SSPD9","component":"ELECTRICAL SYSTEM","summary":"Subject: Notification of Warranty Extension Program - Special Service Program (SSP) D9 2024 CX-90 and 2025 CX-70, SKYACTIV-G 2.5 PHEV – Water Heater Malfunction Mazda Motor Corporation has decided to conduct a Special Service Program (SSP) to extend the warranty coverage for a specific repair of the water heater concern on certain MY2024 CX-90 PHEV and MY2025 CX-70 PHEV vehicles that are equipped with the suspected water heater. The warranty coverage for an applicable repair has been extended to 8 years (96 months) from the original warranty start date, with no mileage limitation. Concern Outline: On certain subject vehicles, while warming up the cabin after starting the vehicle in EV mode, the nichrome wire in the water heater may break or a decrease in insulation resistance may be detected, causing the concerns described below: 1) The heater does not work properly. 2) The hybrid system warning light may turn on and the DTC P0AA6:00 may be stored in memory. - P0AA6:00 – High voltage insulation malfunction: Decrease in vehicle insulation resistance. This is a warranty extension for the specified repair only. Inspection and replacement of non-failed parts will not be eligible for reimbursement under this SSP to the dealer or customer. This program extends the warranty period for actual failures due to defects in workmanship or materials in accordance with the Mazda Warranty Policy and Procedures. If a customer arrives at your dealership with the concern described, please repair the vehicle under this Special Service Program. SSPD9 – Water Heater Malfunction WARRANTY EXTENSION For certain 2024 CX-90 PHEV and 2025 CX-70 PHEV vehicles that are equipped with the suspected water heater, the warranty coverage for an applicable repair of the water heater has been extended to 8 years (96 months) from the original warranty start date, with no mileage limitation. CONDITION OF CONCERN While warning up the cabin using the water heater after starting the vehicle in EV mode, the nichrome wire in the water heater may break or a decrease in insulation resistance may be detected, causing the concerns described below: Heater performance may become poor: 1. The hybrid system warning light may turn on and the DTC P0AA6:00 may be stored. 2. P0AA6:00 – High voltage insulation malfunction: Decrease in vehicle insulation resistance OWNER NOTIFICATION Mazda will notify all U.S. owners of the subject vehicles by first class mail no later than September 1, 2025. • Owners will be advised that they do not need to bring their vehicle to a dealer if it does not exhibit the affected conditions. • Owners will also be advised that any previous repair on the water heater due to concerns related to this SSP will be eligible for reimbursement if the repair was performed at the owner’s expense. Please refer the customer to the Owner Letter for reimbursement instructions. NO COVERAGE FOR BRANDED AND OTHER LIMITATIONS - EXCLUDED COVERAGE • Per Warranty policy 3.26 all limitations apply to this Warranty Extension. There is no coverage for total loss/insurance/salvage or rebuilt titles (W1). If you are unsure about the policy please contact the Warranty Department. REPAIR PROCEDURE If you receive customer complaints about the check engine light ON with P0AA6:00 with any of the symptoms mentioned above, verify the concerns and perform appropriate repair according to the Service Information Technical Service Bulletin (TSB) No. 07-006/24. Note: Please always refer to the latest version of TSB.","document":{"url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11022770-0001.pdf","alternate_url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11022770-9999.pdf","confirmed":false},"url":"https://open.wenmarpro.com/bulletins/11022770"},{"nhtsa_id":11022765,"type":"warranty_extension","type_name":"Warranty extension","date_added":"2025-09-05","date":"2025-08-21","document_id":"SSPD9 Dlr Ltr","mfr_campaign":"SSPD9","component":"ELECTRICAL SYSTEM","summary":"Subject: Notification of Warranty Extension Program - Special Service Program (SSP) D9 2024 CX-90 and 2025 CX-70, SKYACTIV-G 2.5 PHEV – Water Heater Malfunction Mazda Motor Corporation has decided to conduct a Special Service Program (SSP) to extend the warranty coverage for a specific repair of the water heater concern on certain MY2024 CX-90 PHEV and MY2025 CX-70 PHEV vehicles that are equipped with the suspected water heater. The warranty coverage for an applicable repair has been extended to 8 years (96 months) from the original warranty start date, with no mileage limitation. Concern Outline: On certain subject vehicles, while warming up the cabin after starting the vehicle in EV mode, the nichrome wire in the water heater may break or a decrease in insulation resistance may be detected, causing the concerns described below: 1) The heater does not work properly. 2) The hybrid system warning light may turn on and the DTC P0AA6:00 may be stored in memory. - P0AA6:00 – High voltage insulation malfunction: Decrease in vehicle insulation resistance. This is a warranty extension for the specified repair only. Inspection and replacement of non-failed parts will not be eligible for reimbursement under this SSP to the dealer or customer. This program extends the warranty period for actual failures due to defects in workmanship or materials in accordance with the Mazda Warranty Policy and Procedures. If a customer arrives at your dealership with the concern described, please repair the vehicle under this Special Service Program.","document":{"url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11022765-0001.pdf","alternate_url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11022765-9999.pdf","confirmed":false},"url":"https://open.wenmarpro.com/bulletins/11022765"},{"nhtsa_id":11019173,"type":"service_campaign","type_name":"Service campaign","date_added":"2025-06-05","date":"2025-05-21","document_id":"7325C Repair","mfr_campaign":"7325C","component":"ENGINE; ELECTRICAL SYSTEM","summary":"7325C - EMISSION RECALL - 2024-2025 CX-90 AND 2025 CX-70 PHEV ONLY - HYBRID SYSTEM WARNING LIGHT MAY TURN ON. Mazda Motor Corporation has decided to conduct an Emission Recall on certain 2024-2025 CX-90 and 2025 CX-70 PHEV vehicles. Please see the description, model, year, and VIN range below for all vehicles in this campaign. There are 38,812 vehicles affected by this concern in the U.S. and U.S. Territories. Vehicles produced and sold by Mazda Canada Inc. are also included in this campaign and should be repaired if presented to your dealership following Mazda Warranty policy 3.30.STOP DELIVERY OF AFFECTED VEHICLES: MAZDA SALES AND SERVICE TEAMS - ACTION ITEM: There are approximately 5,197 vehicles in stock at U.S. Mazda dealers which must be repaired prior to delivery. All Mazda dealers must quarantine any affected new, used or CPO in-stock vehicles until the repair is completed. The affected dealer inventory list was provided to each District Service Manager with the notification of this dealer email. Once completed, the car can be delivered, and the Warranty claim can be submitted later without penalty since the car has been repaired. To All Mazda Dealers: Failure to properly perform any recall repair is a direct violation of Paragraph 14(F) of the Dealer Agreement and can cause one or more of the following: Mechanical breakdown or failure, crash or injury, Dealership penalties/fines by Mazda and CARB/EPA, increased liability risk for the dealership, Missed Recall penalties, loss of customer trust and a poor Customer Experience. Concern Outline: All vehicles can be repaired immediately upon receipt of this Mazda Dealer announcement by following the repair and warranty claiming procedures housed in Mazda Global Service Support (MGSS). On certain subject vehicles, during normal driving, a temporary decrease in insulation resistance may be detected, which could be mistakenly judged as an electric leakage, causing the hybrid system warning light to turn on and the leakage detection message to be displayed. The DTC P0AA6:00 may be stored in memory. In such a condition, once the vehicle power is switched off, it may become impossible to restart the vehicle due to fail-safe mode activation. Repair Outline: Reprogram the PCM with the Mazda Modular Diagnostic System (M-MDS), using Mazda Diagnostic and Repair Software (MDARS). The DTC code that may appear is P0AA6:00 - High voltage insulation malfunction: Decrease in vehicle insulation resistance. The software update will re-calibrate electrical leakage detection criteria and allow vehicle re-start. Legitimate electrical leakage faults can still be detected and store DTC P0AA6:00. If DTC P0AA6:00 - High voltage insulation malfunction: Decrease in vehicle insulation resistance is still present after repair of the 7325C Recall, please diagnose the issue using the Workshop Manual or search for a current Technical Service Bulletin.","document":{"url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11019173-0001.pdf","alternate_url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11019173-9999.pdf","confirmed":false},"url":"https://open.wenmarpro.com/bulletins/11019173"},{"nhtsa_id":11017711,"type":"emissions","type_name":"Emissions","date_added":"2025-05-05","date":"2025-04-23","document_id":"7325C Owner Letter","mfr_campaign":"7325C","component":"ELECTRICAL SYSTEM","summary":"7325C - EMISSION RECALL - 2024-2025 CX-90 AND 2025 CX-70 PHEV ONLY - HYBRID SYSTEM WARNING LIGHT MAY TURN ON. Mazda Motor Corporation has decided to conduct an Emission Recall on certain 2024-2025 CX-90 and 2025 CX-70 PHEV vehicles. Please see the description, model, year, and VIN range below for all vehicles in this campaign. There are 38,812 vehicles affected by this concern in the U.S. and U.S. Territories. Vehicles produced and sold by Mazda Canada Inc. are also included in this campaign and should be repaired if presented to your dealership following Mazda Warranty policy 3.30.STOP DELIVERY OF AFFECTED VEHICLES: MAZDA SALES AND SERVICE TEAMS - ACTION ITEM: There are approximately 5,197 vehicles in stock at U.S. Mazda dealers which must be repaired prior to delivery. All Mazda dealers must quarantine any affected new, used or CPO in-stock vehicles until the repair is completed. The affected dealer inventory list was provided to each District Service Manager with the notification of this dealer email. Once completed, the car can be delivered, and the Warranty claim can be submitted later without penalty since the car has been repaired. To All Mazda Dealers: Failure to properly perform any recall repair is a direct violation of Paragraph 14(F) of the Dealer Agreement and can cause one or more of the following: Mechanical breakdown or failure, crash or injury, Dealership penalties/fines by Mazda and CARB/EPA, increased liability risk for the dealership, Missed Recall penalties, loss of customer trust and a poor Customer Experience. Concern Outline: All vehicles can be repaired immediately upon receipt of this Mazda Dealer announcement by following the repair and warranty claiming procedures housed in Mazda Global Service Support (MGSS). On certain subject vehicles, during normal driving, a temporary decrease in insulation resistance may be detected, which could be mistakenly judged as an electric leakage, causing the hybrid system warning light to turn on and the leakage detection message to be displayed. The DTC P0AA6:00 may be stored in memory. In such a condition, once the vehicle power is switched off, it may become impossible to restart the vehicle due to fail-safe mode activation. Repair Outline: Reprogram the PCM with the Mazda Modular Diagnostic System (M-MDS), using Mazda Diagnostic and Repair Software (MDARS). The DTC code that may appear is P0AA6:00 - High voltage insulation malfunction: Decrease in vehicle insulation resistance. The software update will re-calibrate electrical leakage detection criteria and allow vehicle re-start. Legitimate electrical leakage faults can still be detected and store DTC P0AA6:00. If DTC P0AA6:00 - High voltage insulation malfunction: Decrease in vehicle insulation resistance is still present after repair of the 7325C Recall, please diagnose the issue using the Workshop Manual or search for a current Technical Service Bulletin.","document":{"url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11017711-0001.pdf","alternate_url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11017711-9999.pdf","confirmed":false},"url":"https://open.wenmarpro.com/bulletins/11017711"},{"nhtsa_id":11016386,"type":"emissions","type_name":"Emissions","date_added":"2025-04-02","date":"2025-03-20","document_id":"7325C Warranty","mfr_campaign":"7325C","component":"ENGINE","summary":"7325C - EMISSION RECALL - 2024-2025 CX-90 AND 2025 CX-70 PHEV ONLY - HYBRID SYSTEM WARNING LIGHT MAY TURN ON. Mazda Motor Corporation has decided to conduct an Emission Recall on certain 2024-2025 CX-90 and 2025 CX-70 PHEV vehicles. Please see the description, model, year, and VIN range below for all vehicles in this campaign. There are 38,812 vehicles affected by this concern in the U.S. and U.S. Territories. Vehicles produced and sold by Mazda Canada Inc. are also included in this campaign and should be repaired if presented to your dealership following Mazda Warranty policy 3.30. STOP DELIVERY OF AFFECTED VEHICLES: MAZDA SALES AND SERVICE TEAMS - ACTION ITEM: There are approximately 5,197 vehicles in stock at U.S. Mazda dealers which must be repaired prior to delivery. All Mazda dealers must quarantine any affected new, used or CPO in-stock vehicles until the repair is completed. The affected dealer inventory list was provided to each District Service Manager with the notification of this dealer email. Once completed, the car can be delivered, and the Warranty claim can be submitted later without penalty since the car has been repaired.To All Mazda Dealers: Failure to properly perform any recall repair is a direct violation of Paragraph 14(F) of the Dealer Agreement and can cause one or more of the following: Mechanical breakdown or failure, crash or injury, Dealership penalties/fines by Mazda and CARB/EPA, increased liability risk for the dealership, Missed Recall penalties, loss of customer trust and a poor Customer Experience. Concern Outline: All vehicles can be repaired immediately upon receipt of this Mazda Dealer announcement by following the repair and warranty claiming procedures housed in Mazda Global Service Support (MGSS). On certain subject vehicles, during normal driving, a temporary decrease in insulation resistance may be detected, which could be mistakenly judged as an electric leakage, causing the hybrid system warning light to turn on and the leakage detection message to be displayed. The DTC P0AA6:00 may be stored in memory. In such a condition, once the vehicle power is switched off, it may become impossible to restart the vehicle due to fail-safe mode activation. Repair Outline: Reprogram the PCM with the Mazda Modular Diagnostic System (M-MDS), using Mazda Diagnostic and Repair Software (MDARS). The DTC code that may appear is P0AA6:00 - High voltage insulation malfunction: Decrease in vehicle insulation resistance. The software update will re-calibrate electrical leakage detection criteria and allow vehicle re-start. Legitimate electrical leakage faults can still be detected and store DTC P0AA6:00. If DTC P0AA6:00 - High voltage insulation malfunction: Decrease in vehicle insulation resistance is still present after repair of the 7325C Recall, please diagnose the issue using the Workshop Manual or search for a current Technical Service Bulletin.","document":{"url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11016386-0001.pdf","alternate_url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11016386-9999.pdf","confirmed":false},"url":"https://open.wenmarpro.com/bulletins/11016386"},{"nhtsa_id":11016385,"type":"emissions","type_name":"Emissions","date_added":"2025-04-02","date":"2025-03-20","document_id":"7325C Repair","mfr_campaign":"7325C","component":"ENGINE","summary":"7325C - EMISSION RECALL - 2024-2025 CX-90 AND 2025 CX-70 PHEV ONLY - HYBRID SYSTEM WARNING LIGHT MAY TURN ON. Mazda Motor Corporation has decided to conduct an Emission Recall on certain 2024-2025 CX-90 and 2025 CX-70 PHEV vehicles. Please see the description, model, year, and VIN range below for all vehicles in this campaign. There are 38,812 vehicles affected by this concern in the U.S. and U.S. Territories. Vehicles produced and sold by Mazda Canada Inc. are also included in this campaign and should be repaired if presented to your dealership following Mazda Warranty policy 3.30. STOP DELIVERY OF AFFECTED VEHICLES: MAZDA SALES AND SERVICE TEAMS - ACTION ITEM: There are approximately 5,197 vehicles in stock at U.S. Mazda dealers which must be repaired prior to delivery. All Mazda dealers must quarantine any affected new, used or CPO in-stock vehicles until the repair is completed. The affected dealer inventory list was provided to each District Service Manager with the notification of this dealer email. Once completed, the car can be delivered, and the Warranty claim can be submitted later without penalty since the car has been repaired.To All Mazda Dealers: Failure to properly perform any recall repair is a direct violation of Paragraph 14(F) of the Dealer Agreement and can cause one or more of the following: Mechanical breakdown or failure, crash or injury, Dealership penalties/fines by Mazda and CARB/EPA, increased liability risk for the dealership, Missed Recall penalties, loss of customer trust and a poor Customer Experience. Concern Outline: All vehicles can be repaired immediately upon receipt of this Mazda Dealer announcement by following the repair and warranty claiming procedures housed in Mazda Global Service Support (MGSS). On certain subject vehicles, during normal driving, a temporary decrease in insulation resistance may be detected, which could be mistakenly judged as an electric leakage, causing the hybrid system warning light to turn on and the leakage detection message to be displayed. The DTC P0AA6:00 may be stored in memory. In such a condition, once the vehicle power is switched off, it may become impossible to restart the vehicle due to fail-safe mode activation. Repair Outline: Reprogram the PCM with the Mazda Modular Diagnostic System (M-MDS), using Mazda Diagnostic and Repair Software (MDARS). The DTC code that may appear is P0AA6:00 - High voltage insulation malfunction: Decrease in vehicle insulation resistance. The software update will re-calibrate electrical leakage detection criteria and allow vehicle re-start. Legitimate electrical leakage faults can still be detected and store DTC P0AA6:00. If DTC P0AA6:00 - High voltage insulation malfunction: Decrease in vehicle insulation resistance is still present after repair of the 7325C Recall, please diagnose the issue using the Workshop Manual or search for a current Technical Service Bulletin.","document":{"url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11016385-0001.pdf","alternate_url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11016385-9999.pdf","confirmed":false},"url":"https://open.wenmarpro.com/bulletins/11016385"},{"nhtsa_id":11016384,"type":"emissions","type_name":"Emissions","date_added":"2025-04-02","date":"2025-03-20","document_id":"7325C Dealer Letter","mfr_campaign":"7325C","component":"ENGINE","summary":"7325C - EMISSION RECALL - 2024-2025 CX-90 AND 2025 CX-70 PHEV ONLY - HYBRID SYSTEM WARNING LIGHT MAY TURN ON. Mazda Motor Corporation has decided to conduct an Emission Recall on certain 2024-2025 CX-90 and 2025 CX-70 PHEV vehicles. Please see the description, model, year, and VIN range below for all vehicles in this campaign. There are 38,812 vehicles affected by this concern in the U.S. and U.S. Territories. Vehicles produced and sold by Mazda Canada Inc. are also included in this campaign and should be repaired if presented to your dealership following Mazda Warranty policy 3.30. STOP DELIVERY OF AFFECTED VEHICLES: MAZDA SALES AND SERVICE TEAMS - ACTION ITEM: There are approximately 5,197 vehicles in stock at U.S. Mazda dealers which must be repaired prior to delivery. All Mazda dealers must quarantine any affected new, used or CPO in-stock vehicles until the repair is completed. The affected dealer inventory list was provided to each District Service Manager with the notification of this dealer email. Once completed, the car can be delivered, and the Warranty claim can be submitted later without penalty since the car has been repaired.To All Mazda Dealers: Failure to properly perform any recall repair is a direct violation of Paragraph 14(F) of the Dealer Agreement and can cause one or more of the following: Mechanical breakdown or failure, crash or injury, Dealership penalties/fines by Mazda and CARB/EPA, increased liability risk for the dealership, Missed Recall penalties, loss of customer trust and a poor Customer Experience. Concern Outline: All vehicles can be repaired immediately upon receipt of this Mazda Dealer announcement by following the repair and warranty claiming procedures housed in Mazda Global Service Support (MGSS). On certain subject vehicles, during normal driving, a temporary decrease in insulation resistance may be detected, which could be mistakenly judged as an electric leakage, causing the hybrid system warning light to turn on and the leakage detection message to be displayed. The DTC P0AA6:00 may be stored in memory. In such a condition, once the vehicle power is switched off, it may become impossible to restart the vehicle due to fail-safe mode activation. Repair Outline: Reprogram the PCM with the Mazda Modular Diagnostic System (M-MDS), using Mazda Diagnostic and Repair Software (MDARS). The DTC code that may appear is P0AA6:00 - High voltage insulation malfunction: Decrease in vehicle insulation resistance. The software update will re-calibrate electrical leakage detection criteria and allow vehicle re-start. Legitimate electrical leakage faults can still be detected and store DTC P0AA6:00. If DTC P0AA6:00 - High voltage insulation malfunction: Decrease in vehicle insulation resistance is still present after repair of the 7325C Recall, please diagnose the issue using the Workshop Manual or search for a current Technical Service Bulletin.","document":{"url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11016384-0001.pdf","alternate_url":"https://static.nhtsa.gov/odi/tsbs/2025/MC-11016384-9999.pdf","confirmed":false},"url":"https://open.wenmarpro.com/bulletins/11016384"}],"url":"https://open.wenmarpro.com/makes/mazda/cx-70/2025/bulletins?code=P0AA6"},"related":{"components":[],"bulletins":[],"recalls":{"may_apply":true,"recalls":[],"lookup":{"nhtsa":"https://www.nhtsa.gov/recalls","tc":"https://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/menu.aspx?lang=eng","maker":null}}},"url":"https://open.wenmarpro.com/makes/mazda/cx-70/2025/codes/P0AA6","note":"The bulletins listed name this code in NHTSA's summary, or are about the same components. A bulletin or a recall listed here may apply to the model year. None of it is a diagnosis.","attribution":["Contains information licensed under the Open Government Licence – Canada."]}