Transport Canada recall 2024062
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | Transport Canada (Canada) |
|---|---|
| Campaign number | 2024062 |
| Manufacturer's number | R0251 |
| Reported | 2024-02-01 |
| Component | Powertrain |
| Notification type | Safety Mfr |
| Units potentially affected | 160 |
What is wrong
Issue:
On certain vehicles, the rear inner axle shaft may not have been manufactured properly. As a result, the inner axle shaft could break and cause a loss of power to the wheels.
Safety Risk:
A sudden loss of power to the wheels could increase the risk of a crash.
Corrective Actions:
Hyundai will notify owners by mail and advise you to take your vehicle to a dealership to replace the rear inner axle shaft.
| 2023 HYUNDAI IONIQ 5 | |
|---|---|
| 2023 HYUNDAI IONIQ 6 |
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| 25-01-042H TSB | 2025-07-15. Service campaign. Certain 2024MY Kona Electric (SX2 EV) and 2023-2024MY IONIQ 5 (NE EV) vehicles are equipped with a Motor and Reduction Gear System, also known as Motor-Gear Driven Unit (MGDU), that may have received an incorrect amount of oil/fluid during manufacturing. In some cases, the motor and/or reduction gear can produce a grinding/whining noise during operation. Follow the procedures in this bulletin to drain the existing oil and replace it with new oil to resolve this condition. |
|---|---|
| 24-EV-003H | 2024-04-02. Service bulletin. Certain 2022-2024 MY IONIQ 5 (NE1) and 2023MY IONIQ 6 (CE1) may have a condition of the power down warning light (turtle symbol) with "Power is limited" displayed in the cluster, and possible DTC P0A2F. If you are servicing a vehicle with either of these conditions, follow this bulletin to inspect the EOP. |
| 23-01-067H-1 | 2023-11-07. Service bulletin. Updated Vehicle Control Unit (VCU) software relating to the brake light logic for regenerative braking on certain IONIQ 5 Electric (NE1) & IONIQ 6 (CE1) vehicles is now available to improve the vehicle’s system logic and performance. An “Owner’s Manual Supplement” leaflet is also to be provided to 2022MY IONIQ 5 vehicle customers to explain the change & application of the Electronic Parking Brake (EPB) system of their vehicle. |
| 23-01-067H-1 | 2023-11-07. Service bulletin. This updated Vehicle Control Unit (VCU) software package includes the following: • Brake light logic update for regenerative braking. • i-Pedal mode operation logic update. • 12V battery saver logic update allows charging from EV Battery as low as 10% SOC when parked. The Ioniq 5 update includes these earlier items that Ioniq 6 had included from start of production: • EPB (Electronic Parking Brake) auto engagement when shift into Park/auto disengagement shift out of Park when shifting to D or R while brake pedal is engaged. • DTE (Distance to Empty) strategy. • Snow road surface performance. • Air conditioning performance during AC slow charging. • Enhance charging sequence. |
| 23-EV-006H | 2023-09-06. Service bulletin. This bulletin provides service information on how to inspect the charging port and if needed, replace any missing/damaged insulation cap(s) at the charging port on certain 2022-2023MY Ioniq 5 (NE1) and 2023MY (CE1) . The charging insulation caps are important to ensure proper charger connector orientation and fit to the vehicle charge port. |
| 23-HA-002H | 2023-09-05. Service bulletin. Certain IONIQ 5 (NE1) vehicles may experience an inoperative heater or air conditioning with one or more HVAC system related DTCs B169588, B160C88, and/or B183088. To correct this condition, follow the inspection diagnostics and repair procedure outlined in this bulletin. |
| 23-01-060H | 2023-08-02. Service bulletin. Certain 2022-2023MY IONIQ 5 (NE1) and 2023MY IONIQ 6 (CE1) vehicles may exhibit a condition where low 12V auxiliary battery charging occurs due to an ICCU (Intelligent Charging Control Unit) fault which may set the following DTC P1A9096 – “DC/DC Converter Input Voltage Sensor Fault”. When a fault occurs, the vehicle may enter a reduced power mode while various warning lights, an audible chime will sound, and large messaging in the vehicle’s instrument cluster will appear, instructing the driver to stop the vehicle. The vehicle will be inspected for a DTC P1A9096 and may require either an ICCU software update or ICCU replacement and potential fuse replacement (if fuse is blown when inspected). |
| 23-01-060H | 2023-08-02. Service bulletin. Certain 22-23MY Ioniq 5 (NE1) & 23MY Ioniq 6 (CE1) vehicles may have a condition where low 12V auxiliary battery charging occurs due to an ICCU (Intelligent Charging Control Unit) fault and may set the following DTC P1A9096 – “DC/DC Converter Input Voltage Sensor Fault”. When a fault occurs, the vehicle may enter a reduced power mode while various warning lights, an audible chime will sound, and large messaging in the vehicle’s instrument cluster will appear and instruct the driver to stop the vehicle. The Service Procedure flow to be followed is outlined by the flowchart on Page-3. The ICCU system is to be checked by GDS for DTC P1A9096 and depending on the result, will involve either an ICCU software update, or ICCU and potential fuse replacement. Only replace the fuse after it is inspected to confirm to be blown/open. |
| 23-01-039H | 2023-07-01. Service bulletin. This bulletin applies the following continuous improvements from a Vehicle Control Unit (VCU) Software Update. An “Owner’s Manual Supplement” leaflet is to be provided to 2022MY vehicle customers to explain the change it makes to the Electronic Parking Brake (EPB) system. (NOTE: 2023MY vehicle Owner’s Manual already contains the EPB supplement content). • Enhance i-Pedal mode operation. • EPB (Electronic Parking Brake) auto engagement when shift into Park/auto disengagement shift out of Park when shifting to D or R while brake pedal is engaged. • DTE (Distance to Empty) strategy. • Snow road surface performance. • Air conditioning performance during AC slow charging. • Enhance charging sequence. |
| 23-EV-003H | 2023-04-04. Service bulletin. If you are servicing a vehicle with either of the following conditions perform the procedure in this Bulletin to update VCMS software. • Intermittently stops charging before charging completes. • EV Light On with DTC P1BAD “Charger Coupler Temperature Too High”. |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.